Product Categories See All
Track Order Status
SDS Sheet 0075930Printer Friendly View
Safety Data Sheet Date of Issue: |Revision Date: 10/9/2015 |Revision Number: Imperial Supplies Part Number: 0075930 SECTION 1: IDENTIFICATION 1.1. Product Identifier Product Form: Product Name: CPI/DynatexÂ® Hi-Tack Gasket Adhesive/Sealant CAS No: Synonyms: CPI 39358; Dynatex 49358 1.2. Intended Use of the Product Use of the substance/mixture: Refer to Technical Information 1.3. Name, Address, and Telephone of the Responsible Party Company Dynatex a division of Soudal Accumetric 350 Ring Road Elizabethtown, KY, 42701 USA Phone: (270) 769-3385 1.4. Emergency Telephone Number Emergency |(800) 424-9300 CHEMTREC number | SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) ACUTE TOXICITY|Category 5 - INHALATION | ACUTE TOXICITY|Category 4 - ORAL | ASPIRATION |Category 2 HAZARD | EYE |Category 2B DAMAGE/IRRITAT| ION | FLAMMABLE |Category 1 AEROSOLS | SKIN |Category 2 CORROSION/IRRI| TATION | SPECIFIC |Category 3 TARGET ORGAN | TOXICITY | (Single | Exposure) | 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) |Health |Flame |Exclamati| | | |hazard | |on mark | | | Signal Word (GHS-US) |Danger Hazard Statements (GHS-US) |Causes eye irritation |Causes skin irritation |Extremely flammable aerosol |Harmful if swallowed |May be harmful if inhaled |May be harmful if swallowed and enters airways |May cause drowsiness or dizziness. Precautionary Statements |Response: (GHS-US) |Call a poison center/doctor if you feel unwell. |Do NOT induce vomiting. |If eye irritation persists: Get medical |advice/attention. |If in eyes: Rinse cautiously with water for several |minutes. Remove contact |lenses, if present and easy to do. Continue rinsing. | |IF INHALED: Call a POISON CENTER or doctor if you |feel unwell |If inhaled: Remove person to fresh air and keep |comfortable for breathing. |If on skin: Wash with plenty of soap and water. |If skin irritation occurs: Get medical |advice/attention. |If swallowed: Rinse mouth. Do NOT induce vomiting. |Immediately call a |poison center/doctor. |Read label before use. |Rinse mouth. |Take off contaminated clothing and wash it before |reuse. |Prevention: |Avoid breathing dust/fume/gas/mist/ vapors/spray. |Do not eat, drink or smoke when using this product. |Do not spray on an open flame or other ignition |source. |Keep away from heat. |Pressurized container: Do not pierce or burn, even |after use. |Use only outdoors or in a well-ventilated area. |Wash thoroughly after handling. |Wear protective gloves. |Storage: |Protect from sunlight. Do not expose to temperatures |exceeding 50C/122F. |Store in a well-ventilated place. Keep container |tightly closed. |Store locked up. |Disposal: |Dispose of contents/container in accordance with |local, state and federal |regulations. 2.3. Other Hazards Other Hazards Not Contributing to the Classification: Additional Information: None known. 2.4. Unknown Acute Toxicity (GHS-US) 0%. SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name |Product identifier |% |Classification | | |(GHS-US) Liquified Petroleum Gas |68476-86-8 |20% - | | |30% | Hexane |110-54-3 |22% - | | |38% | 2-Propanone |67-64-1 |22% - | | |38% | | | | | | | SECTION 4: FIRST AID MEASURES 4.1. Description of First Aid Measures First-aid Measures General: First-aid Measures After Inhalation: Remove individual to fresh air. Give oxygen if breathing is labored. If breathing has stopped give artificial respiration. Keep person warm, quiet and seek medical attention. First-aid Measures After Skin Contact: Remove contaminated clothing and wash skin with soap and water. Get medical attention if irritation persists. Launder clothing before reuse. First-aid Measures After Eye Contact: Move to fresh air. Flush eyes gently with water while holding eyelids apart. If symptoms persist or there is any visual difficulty, seek medical attention. First-aid Measures After Ingestion: Seek medical attention. DO NOT give anything by mouth; place individual on the left side with the head down. Contact a physician, medical facility, or poison control center for advice about whether to induce vomiting. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed Notes to Physician: Inhalation of high concentrations of this material, as could occur in enclosed spaces or during deliberate abuse, may be associated with cardiac arrhythmias. Sympathomimetic drugs may initiate cardiac arrhythmias in persons exposed to this material. This material is an aspiration hazard. SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: Dry powder, foam, carbon dioxide. Unsuitable Extinguishing Media: Water may be ineffective. 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: Contents under pressure. Do not expose to temperatures exceeding 120Â° F as containers may vent, rupture or burst. Material is volatile and readily gives off vapors which may travel along the ground or be moved by ventilation and ignited by pilot lights, flames, sparks, heaters, smoking, electric motors, static discharge or other ignition sources at locations near the material handling point. Never use welding or cutting torch on or near area of use because product (even just residue) can ignite explosively. Explosion Hazard: Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Firefighting Instructions: Wear full firefighting turn-out gear (full Bunker gear), and respiratory protection (SCBA). Water may be ineffective for extinguishment unless used under favorable conditions by experienced fire fighters. Use water spray to cool fire exposed containers and structures until fire is out if it can be done with minimal risk. Avoid spreading burning material with water used for cooling purposes. Protection During Firefighting: SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: 6.1.1. For Non-emergency Personnel Protective Equipment: Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: Emergency Procedures: 6.2. Environmental Precautions 6.3. Methods and Material for Containment and Cleaning Up For Containment: Methods for Cleaning Up: Steps to be taken in case of spill or release: Absorb spill with inert material then place in a chemical waste container. Dispose of spill material in accordance with regulations. 6.4. Reference to Other Sections See heading 8, Exposure Controls and Personal Protection. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: DANGER! EXTREMELY FLAMMABLE. VAPOR HARMFUL. HARMFUL OR FATAL IF INHALED OR SWALLOWED. Contents under pressure. Keep away from heat, sparks, sources of ignition and open flames. Do not smoke while using or near area of use. Avoid contact with eyes. Avoid prolonged or repeated contact with skin. Use only in a well-ventilated area. Do not store at temperatures above 120Â°F. Intentional misuse by deliberately concentrating and inhaling the vapors (contents) may be harmful or fatal. Hygiene Measures: 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Storage Conditions: Keep out of reach of children. Do not store near heat, sparks, or open flames. Do not expose to temperatures above 120Â°F as container may vent, rupture or burst. Do not puncture or incinerate container. Do not store in direct sunlight. Store in a cool, dry, well-ventilated area away from incompatible materials. Store in accordance with NFPA 30B for Level 3 Aerosols. Other Precautions: Read label precautions carefully. Follow label directions to avoid injury. 7.3. Specific End Use(s) SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters Occupational Exposure Limits: Ingredient Name ACGIH TLV OSHA PEL STEL Liquified Petroleum Gas 1000 ppm Not Est. N/A Hexane 50 ppm 500 ppm 1000 ppm 2-Propanone 500 ppm 1000 ppm 750 ppm 8.2. Exposure Controls Appropriate Engineering | Controls | Personal Protective Equipment|N/A. |Ventilation: Local Exhaust: Maintain adequate |ventilation. Mechanical (General): Materials for Protective |Wash hands after use and before eating, drinking, Clothing |chewing gum or smoking. Hand Protection |Protective Gloves: Chemical resistant gloves. Eye Protection |Chemical goggles with side shields or face shield |recommended. Skin and Body Protection | Respiratory Protection |Maintain exposure below exposure guidelines below |levels that cause known, |suspected or apparent adverse effects. Thermal Hazard Protection | SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State |Aerosol spray can Appearance | Odor |Hydrocarbon Odor Threshold |N/A pH |N/A Relative Evaporation Rate (butyl |> 1.00 (BuAc=1) acetate=1) | Melting Point |N/A Freezing Point | Boiling Point |Not established Flash Point |<17C concentrate Auto-ignition Temperature |N/A Decomposition Temperature |N/A Flammability (solid, gas) |Flammable Vapor Pressure |Not established Relative Vapor Density at 20 Â°C |Not established Relative Density | Specific Gravity |0.76 Solubility |Insoluble in water Partition coefficient: |N/A n-octanol/water | Viscosity |Not established Lower Flammable Limit |N/A Upper Flammable Limit |N/A 9.2. Other Information VOC%: 60.08% Note: The above information is not intended for use in preparing product specifications. Contact Soudal Accumetric before writing specifications. SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity 10.2 Chemical Stability Stable. 10.3 Possibility of Hazardous Reactions Hazardous polymerization: Will not occur. 10.4 Conditions to Avoid Open flames; Temperatures above 120F. 10.5 Incompatible Materials Concentrated nitric and sulfuric acid mixtures, oxidizing materials, chloroform, alkalis, chlorine compounds, acids, potassium t-butoxide. 10.6 Hazardous Decomposition Products Carbon monoxide, carbon dioxide, hydrocarbons. SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: Skin Corrosion/Irritation: Serious Eye Damage/Irritation: Respiratory or Skin Sensitization: Germ Cell Mutagenicity: Carcinogenicity: No ingredient in this product is an IARC, NTP or OSHA listed carcinogen. Reproductive Toxicity: Specific Target Organ Toxicity (Single Exposure): Specific Target Organ Toxicity (Repeated Exposure): Aspiration Hazard: Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Chronic Symptoms: Intentional misuse by deliberately concentrating and inhaling the contents may be harmful or fatal. Reports have associated repeated and prolonged occupational overexposure to solvents with permanent brain and nervous system damage. SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity 12.2. Persistence and Degradability 12.3. Bioaccumulative Potential 12.4. Mobility in Soil 12.5. Other Adverse Effects Fate and Effects in Waste Water Treatment Plants: Complete information is not yet available. Environmental Effects: Complete information is not yet available. Environmental Fate and Distribution: Complete information is not yet available. SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: We make no guarantee or warranty of any kind that the use or disposal of this product complies with all local, state, or federal laws. It is also the obligation of each user of the product mentioned herein to determine and comply with the requirements of all applicable statutes. This product is not known to be regulated under RCRA regulations, but contains SARA regulated substances. Disposal of unused portions of this product and process waste containing this product should be done only after a careful evaluation and in compliance with all federal, local and state laws. Additional Information: SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name |Aerosols, flammable Hazard Class |2.1 |<PICTOGRAM PHRASE> Identification Number|1950 | Label Codes | | ERG Number | 14.2 In Accordance with IMDG Proper Shipping Name |Aerosols, flammable (ACETONE, HEPTANE) Hazard Class |2.1 Identification Number|UN1950 Label Codes |2.1 |<PICTOGRAM PHRASE> ntification Of The | | Substance/m | | EmS-No. (Fire) | | EmS-No. (Spillage) | | 14.3 In Accordance with IATA Proper Shipping Name |Aerosols, flammable (ACETONE, HEPTANE) Identification Number|UN1950 |<PICTOGRAM PHRASE> Hazard Class |2.1 | Label Codes |2.1 | ntification Of The | | Substance/m | | ERG Code (IATA) | SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations <COMPONENT> The contents of this MSDS comply with the OSHA Hazard Communication Standard 29 CFR 1910.1200. SARA Section 311/312 Hazard Classes | Toxic Substances Control Act (TSCA) |All chemical substances found in this product |comply with the Toxic Substances Control Act |inventory reporting requirements. 15.2 US State Regulations <COMPONENT> California Proposition 65: This product contains the following chemical(s) listed by the State of California under the Safe Drinking Water and Toxic Enforcement Act of 1986 (Proposition 65) as being known to cause cancer, birth defects or other reproductive harm: None known. SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date |10/9/2015 Other |This document has been prepared in accordance with the SDS Information |requirements of the OSHA Hazard Communication Standard 29 CFR |1910.1200. GHS Full Text Phrases: ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | Grainger disclaimer.
The information contained in this SDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this 'SDS' shall be created or inferred by any statement in this 'SDS'. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this 'SDS'. The user is responsible for full compliance.