Product Categories See All
Track Order Status
SDS Sheet 0075430Printer Friendly View
SECTION 1: IDENTIFICATION 1.1. Product Identifier Product Form: Product Name: DynatexÂ¨ 49451 Red Boltlocker - High Strength CAS No: Synonyms: 49451RD21 1.2. Intended Use of the Product Use of the substance/mixture: Refer to Technical Data 1.3. Name, Address, and Telephone of the Responsible Party Company Dynatex Inc. 350 Ring Road Elizabethtown, KY, 42701 USA Phone: (270) 769-3385 1.4. Emergency Telephone Number Emergency | (800) 424-9300 Chemtrec number | SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) ACUTE TOXICITY-INHALATION |Category |4 ACUTE TOXICITY - ORAL |Category |4 EYE DAMAGE/IRRITATION |Category |2A SENSITIZATION - SKIN |Category |1 SKIN CORROSION/IRRITATION |Category |2 SPECIFIC TARGET ORGAN TOXICITY |Category (Single Exposure) |3 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) |Exclamation Mark Signal Word (GHS-US) |Warning Hazard Statements (GHS-US) |Causes serious eye irritation, Causes skin |irritation, Harmful if, inhaled, Harmful if |swallowed, May cause an allergic skin reaction, May |cause respiratory irritation. Precautionary Statements |Response: Call a poison center/doctor if you feel (GHS-US) |unwell. If eye irritation persists: Get medical |advice/attention. If in eyes: Rinse cautiously with |water for several minutes. Remove contact lenses, if |present and easy to do. Continue rinsing. If |inhaled: Remove person to fresh air and keep |comfortable for breathing. If on skin: Wash with |plenty of soap and water. If skin irritation occurs: |Get medical advice/attention. If skin irritation or |rash occurs: Get medical advice/attention. If |swallowed: Call a poison center/doctor if you feel |unwell. Read label before use. Rinse mouth. Take off |contaminated clothing and wash it before reuse. Wash |contaminated clothing before reuse. Prevention: |Avoid breathing dust/fume/gas/mist/ vapors/spray. |Contaminated work clothing must not be allowed out |of the workplace. Do not eat, drink or smoke when |using this product. Use only outdoors or in a |well-ventilated area. Wash hands thoroughly after |handling. Wear eye protection/face protection. Wear |protective gloves. Storage: Store in a |well-ventilated place. Keep container tightly |closed. Store locked up. Disposal: Dispose of |contents/container in accordance with |local/regional/national/international regulations. 2.3. Other Hazards Other Hazards Not Contributing to the Classification: 2.4. Unknown Acute Toxicity (GHS-US) Ingredients of unknown Toxicity 0% SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name |Product identifier |% |Classification | | |(GHS-US) ?,? -dimethylbenzyl |80-15-9 |0.1% - | hydroperoxide | |1% | 2-Hydroxypropyl methacrylate |27813-02-1 |2.5% - | | |10% | Polyethylene glycol 200 |9004-96-0 |25% - | monooleate | |50% | Dimethacrylate Ester |25852-47-5 |50% - | | |100% | | | | Occupational exposure limits, if available, are listed in Section 8. SECTION 4: FIRST AID MEASURES 4.1. Description of First Aid Measures First-aid Measures General: First-aid Measures After Inhalation: Remove to fresh air. If symptoms persist, obtain appropriate medical attention. First-aid Measures After Skin Contact: Wash affected area throughly with soap and water. Remove contaminated clothing and launder before re-use. Get medical attention if irritation develops. First-aid Measures After Eye Contact: Rinse with water for 15 minutes. Obtain medical attention. First-aid Measures After Ingestion: Wash affected area throughly with soap and water. Remove contaminated clothing and launder before re-use. Get medical attention if irritation develops. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: N/A. Extinguishing Media: Carbon Dioxide, Dry Chemical, Foam Unsuitable Extinguishing Media: N/A 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: None Explosion Hazard: Hazardous Decomposition Products: Thermal breakdown of this product during fire or very high heat conditions may evolve the following hazardous decomposition products: Irritating organic vapors Oxides of carbon, sulfur and nitrogen. Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Firefighting Instructions: Protection During Firefighting: SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: Observe all personal protection equipment recommendations. Soak up with inert absorbent. Store in a partly filled, closed container until disposal. Prevent product from entering drains. Local, state and federal regulations may apply to releases and disposal of this material, as well as those materials and items employed in cleanup of releases. 6.1.1. For Non-emergency Personnel Protective Equipment: Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: Emergency Procedures: 6.2. Environmental Precautions 6.3. Methods and Material for Containment and Cleaning Up For Containment: Methods for Cleaning Up: 6.4. Reference to Other Sections See heading 8, Exposure Controls and Personal Protection. SECTION 7: HANDLING AND STORAGE 7.1 Precautions for safe handling Additional Hazards when Processed: Avoid contact with skin, eyes, and clothing. Avoid breathing vapor or mist. Hygiene Measures: 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Storage Conditions: Store at or below 100F. Keep away from heat, sparks and open flames. 7.3. Specific End Use(s) SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters Ingredient Name ACGIH TLV OSHA PEL STEL ?,? -Dimethylbenzyl hydroperoxide N/A N/A N/A 2-Hydroxypropyl methacrylate N/A N/A N/A Polyethylene glycol 200 monooleate N/A N/A N/A Dimethacrylate Ester None None N/A 8.2. Exposure Controls Appropriate Engineering | Controls | Personal Protective Equipment|Goggles, Gloves. |Local exhaust ventilation is recommended to maintain |vapor level below TLV. Materials for Protective | Clothing | Hand Protection | Eye Protection |Safety goggles or glasses with side shields are |recommended. Skin and Body Protection |Rubber, polyethylene, or neoprene gloves. Respiratory Protection |Use NIOSH approved respirator for individuals who |are sensitive. Thermal Hazard Protection | SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES Physical State |Liquid Appearance | Odor |Mild Odor Threshold |N/A pH |N/A Relative Evaporation Rate |N/A (butylacetate=1) | Melting Point |N/A Freezing Point | Boiling Point |> 300Â¡F Flash Point |>200Â¡F TCC Auto-ignition Temperature |N/A Decomposition Temperature |N/A Flammability (solid, gas) | Vapor Pressure |< 5mm Hg |@ 200Â¡F Relative Vapor Density at 20 Â°C | Relative Density | Specific Gravity | Solubility |Negligible Partition coefficient: | n-octanol/water | Viscosity | Lower Flammable Limit | Upper Flammable Limit | 9.2. Other Information Note: The above information is not intended for use in preparing product specifications. Contact Soudal Accumentric before writing specifications. SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity 10.2 Chemical Stability Stable 10.3 Possibility of Hazardous Reactions 10.4 Conditions to Avoid None known 10.5 Incompatible Materials 10.6 Hazardous Decomposition Products Oxides of carbon, sulfur, and nitrogen SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: No known applicable information. Skin Corrosion/Irritation: Serious Eye Damage/Irritation: Respiratory or Skin Sensitization: Germ Cell Mutagenicity: Carcinogenicity: Reproductive Toxicity: Specific Target Organ Toxicity (Single Exposure): Specific Target Organ Toxicity (Repeated Exposure): Aspiration Hazard: Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Chronic Symptoms: SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity Complete information is not yet available. 12.2. Persistence and Degradability 12.3. Bioaccumulative Potential 12.4. Mobility in Soil 12.5. Other Adverse Effects Environmental Effects: Complete information is not yet available. Environmental Fate and Distribution: Complete information is not yet available. Fate and Effects in Waste Water Treatment Plants: Complete information is not yet available. SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: Additional Information: Waste Disposal Method: We make no guarantee or warranty of any kind that the use or disposal of this product complies with all local, state, or federal laws. It is also the obligation of each user of the product mentioned herein to determine and comply with the requirements of all applicable statutes. This product is not known to be regulated under RCRA regulations. Disposal of unused portions of this product and process waste containing this product should be done only after a careful evaluation and in compliance with all federal, local and state laws. SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name |Not subject to DOT regulations. Hazard Class | |<PICTOGRAM PHRASE> Identification Number|N/A | Label Codes | | ERG Number | 14.2 In Accordance with IMDG Proper Shipping Name |Not subject to IMDG code. Hazard Class | Identification Number| Label Codes | |<PICTOGRAM PHRASE> ntification Of The | | Substance/m | | EmS-No. (Fire) | | EmS-No. (Spillage) | | 14.3 In Accordance with IATA Proper Shipping Name |Not subject to IATA regulations. Identification Number| |<PICTOGRAM PHRASE> Hazard Class | | Label Codes | | ntification Of The | | Substance/m | | ERG Code (IATA) | SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations <COMPONENT> SARA Section 311/312 Hazard Classes |Acute: Yes |Chronic: No |Fire: No |Pressure: No |Reactive: No Toxic Substances Control Act (TSCA) |All chemical substances found in this product |comply with the Toxic Substances Control Act |inventory reporting requirements. The |contents of this MSDS comply with the OSHA |Hazard Communication Standard 29 CFR |1910.1200. 15.2 US State Regulations <COMPONENT> New Jersey: Cumene hydroperoxide (80-15-9) Saccharin (81-07-2) California Proposition 65: This product contains the following chemical(s) listed by the State of California under the Safe Drinking Water and Toxic Enforcement Act of 1986 (Proposition 65) as being known to cause cancer, birth defects or other reproductive harm: Saccharin. Proper usage necessitates no Proposition 65 warning. SARA Title III Section 313 Toxic Chemicals :- Cumene Hydroperoxide (80-15-9) SARA Titre III Section 304 CERCLA Substances Dangereuses -: None Pennsylvania: Cumene hydroperoxide (80-15-9) Saccharin (81-07-2) SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date |5/18/2015 Other |This document has been prepared in accordance with the SDS Information |requirements of the OSHA Hazard Communication Standard 29 CFR |1910.1200. GHS Full Text Phrases: ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | Grainger disclaimer.
The information contained in this SDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this 'SDS' shall be created or inferred by any statement in this 'SDS'. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this 'SDS'. The user is responsible for full compliance.