Product Categories See All
Track Order Status
Sheet 0075400Printer Friendly View
Safety Data Sheet Date of Issue: |Revision Date: 4/16/2015 |Revision Number: Imperial Supplies Part Number: 0075400 SECTION 1: IDENTIFICATION 1.1. Product Identifier Product Form: Product Name: Dynatex� 49486 Pipe Sealant w/ PTFE CAS No: Synonyms: 49486WH06 1.2. Intended Use of the Product Use of the substance/mixture: Refer to Technical Data 1.3. Name, Address, and Telephone of the Responsible Party Company Dynatex Inc. 350 Ring Road Elizabethtown, KY, 42701 USA Phone: (270) 769-3385 1.4. Emergency Telephone Number Emergency | (800) 424-9300 Chemtrec number | SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) ACUTE TOXICITY|Category 4 - INHALATION | ACUTE TOXICITY|Category 4 - ORAL | EYE |Category 2A DAMAGE/IRRITAT| ION | SENSITIZATION |Category 1 - SKIN | SKIN |Category 2 CORROSION/IRRI| TATION | SPECIFIC |Category 3 TARGET ORGAN | TOXICITY | 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) |Exclamat| | | | | |ion Mark| | | | | Signal Word (GHS-US) |Warning Hazard Statements (GHS-US) |Causes serious eye irritation. |Causes skin irritation. |Harmful if inhaled. |Harmful if swallowed. |May cause an allergic skin reaction. |May cause respiratory irritation. Precautionary Statements |Response: If eye irritation persists: Get medical (GHS-US) |advice/attention. |If in eyes: Rinse cautiously with water for several |minutes. |Remove contact lenses, if present and easy to do. |Continue |rinsing. |If inhaled: Remove person to fresh air and keep |comfortable for |breathing. |If on skin: Wash with plenty of soap and water. |If skin irritation occurs: Get medical |advice/attention. |If skin irritation or rash occurs: Get medical |advice/attention. |If swallowed: Call a poison center/doctor if you |feel unwell. |Read label before use. |Rinse mouth. |Take off contaminated clothing and wash it before |reuse. |Wash contaminated clothing before reuse. |Prevention: Avoid breathing dust/fume/gas/mist/ |vapors/spray. |Contaminated work clothing must not be allowed out |of the |workplace. |Do not eat, drink or smoke when using this product. |Use only outdoors or in a well-ventilated area. |Wash hands thoroughly after handling. |Wear eye protection/face protection. |Wear protective gloves. |Storage: Store in a well-ventilated place. Keep |container tightly closed. |Store locked up. |Disposal: Dispose of contents/container in |accordance with |local/regional/national/international regulations. 2.3. Other Hazards Other Hazards Not Contributing to the Classification: None known. 2.4. Unknown Acute Toxicity (GHS-US) Ingredients of unknown Toxicity 0% SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name |Product identifier |% |Classification | | |(GHS-US) Cumene Hydroperoxide |80-15-9 |0.1% - | | |1% | Cellulose Acetate Butyrate |9004-36-8 |2.5% - | | |10% | Polyethylene glycol 200 | |25% - | dimethacrylate | |50% | Polyethylene glycol 200 |9004-96-0 |25% - | monooleate | |50% | | | | Occupational exposure limits, if available, are listed in Section 8. SECTION 4: FIRST AID MEASURES 4.1. Description of First Aid Measures First-aid Measures General: First-aid Measures After Inhalation: Remove to fresh air. If symptoms persist, obtain appropriate medical attention. First-aid Measures After Skin Contact: Wash affected area thoroughly with soap and water. Remove contaminated clothing and launder before re-use. Get medical attention if irritation develops. First-aid Measures After Eye Contact: Flush with warm water for 15 minutes. Obtain medical attention. First-aid Measures After Ingestion: Do not induce vomiting. Keep individual calm. Obtain medical attention. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: Carbon Dioxide, Dry Chemical, Foam. Unsuitable Extinguishing Media: N/A. 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: None known. Explosion Hazard: Hazardous Products Formed by Fire or Thermal Decomposition: Irritating organic vapors; oxides of carbon, sulfur and nitrogen. Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Firefighting Instructions: None. Protection During Firefighting: SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: 6.1.1. For Non-emergency Personnel Protective Equipment: Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: Emergency Procedures: 6.2. Environmental Precautions 6.3. Methods and Material for Containment and Cleaning Up For Containment: Methods for Cleaning Up: Steps to be taken in case of spill or release: Observe all personal protection equipment recommendations. Soak up with inert absorbent. Store in a partly filled, closed container until disposal. Prevent product from entering drains. Local, state and federal regulations may apply to releases and disposal of this material, as well as those materials and items employed in cleanup of releases. 6.4. Reference to Other Sections See heading 8, Exposure Controls and Personal Protection. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: Avoid contact with skin, eyes and clothing. Avoid breathing vapor or mist. Wash thoroughly after handling. Hygiene Measures: 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Storage Conditions: Store at or below 100F. Keep away from heat, sparks and open flames. 7.3. Specific End Use(s) SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters Ingredient Name ACGIH TLV OSHA PEL STEL Cumene Hydroperoxide None None N/A Cellulose Acetate Butyrate N/A N/A N/A Polyethylene glycol 200 dimethacrylate N/A N/A N/A Polyethylene glycol 200 monooleate N/A N/A N/A 8.2. Exposure Controls Appropriate Engineering | Controls | Personal Protective Equipment|Goggles, Gloves. Materials for Protective | Clothing | Hand Protection | Eye Protection |Safety goggles or glasses with side shields are |recommended. Skin and Body Protection |Rubber, polyethylene, or neoprene gloves. Respiratory Protection |Use NIOSH approved respirator for individuals who |are sensitive. Thermal Hazard Protection | SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State |Paste Appearance | Odor |Characteristic Odor Threshold |Not determined pH |Not determined Relative Evaporation Rate |Not determined (butylacetate=1) | Melting Point |Undetermined Freezing Point | Boiling Point |>149 C 300F Flash Point |>94 C 201F TCC Auto-ignition Temperature |Product is not selfigniting Decomposition Temperature |Not determined Flammability (solid, gas) |Not applicable Vapor Pressure |Not determined Relative Vapor Density at 20 �C |Not determined Relative Density | Specific Gravity |1.1 Solubility |Not miscible or difficult Partition coefficient: |Not determined n-octanol/water | Viscosity |Not determined Lower Flammable Limit | Upper Flammable Limit | 9.2. Other Information SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity 10.2 Chemical Stability Stable 10.3 Possibility of Hazardous Reactions 10.4 Conditions to Avoid 10.5 Incompatible Materials Strong oxidizers, free radical initiators, strong reducing agents, alkalis. 10.6 Hazardous Decomposition Products Oxides of carbon, sulfur, and nitrogen. SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: Oral: LD50 >10,000 mg/kg (rat). Dermal: LD50 > 5000 mg/kg (rabbit). Skin Corrosion/Irritation: Serious Eye Damage/Irritation: Respiratory or Skin Sensitization: Germ Cell Mutagenicity: Carcinogenicity: Reproductive Toxicity: Specific Target Organ Toxicity (Single Exposure): Specific Target Organ Toxicity (Repeated Exposure): Aspiration Hazard: Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Chronic Symptoms: SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity Complete information is not yet available. 12.2. Persistence and Degradability 12.3. Bioaccumulative Potential 12.4. Mobility in Soil 12.5. Other Adverse Effects Environmental Effects: Complete information is not yet available. Environmental Fate and Distribution: Complete information is not yet available. Fate and Effects in Waste Water Treatment Plants: Complete information is not yet available. SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: We make no guarantee or warranty of any kind that the use or disposal of this product complies with all local, state, or federal laws. It is also the obligation of each user of the product mentioned herein to determine and comply with the requirements of all applicable statutes. This product is not known to be regulated under RCRA regulations. Disposal of unused portions of this product and process waste containing this product should be done only after a careful evaluation and in compliance with all federal, local and state laws. Additional Information: SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name |Not subject to DOT regulations. Hazard Class |N/A |<PICTOGRAM PHRASE> Identification Number|N/A | Label Codes | | ERG Number | 14.2 In Accordance with IMDG Proper Shipping Name |Not subject to IMDG code. Hazard Class | Identification Number| Label Codes | |<PICTOGRAM PHRASE> ntification Of The | | Substance/m | | EmS-No. (Fire) | | EmS-No. (Spillage) | | 14.3 In Accordance with IATA Proper Shipping Name |Not subject to IATA regulations. Identification Number| |<PICTOGRAM PHRASE> Hazard Class | | Label Codes | | ntification Of The | | Substance/m | | ERG Code (IATA) | SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations <COMPONENT> CERCLA SARA 313 This product contains the following toxic chemicals subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act of 1986 (40 CFR 372). Cumene hydroperoxide (CAS# 80-15-9). SARA Section 311/312 Hazard Classes | Toxic Substances Control Act (TSCA) |All chemical substances found in this product |comply with the Toxic Substances Control Act |inventory reporting requirements. 15.2 US State Regulations <COMPONENT> CA Proposition 65: This product contains a chemical known in the State of California to cause cancer. This product contains a chemical known to the State of California to cause birth defects or other reproductive harm. SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date |4/16/2015 Other |This document has been prepared in accordance with the SDS Information |requirements of the OSHA Hazard Communication Standard 29 CFR |1910.1200. GHS Full Text Phrases: ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | Grainger disclaimer.
The information contained in this was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this '' shall be created or inferred by any statement in this ''. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this ''. The user is responsible for full compliance.