Product Categories See All
Track Order Status
SDS Sheet 0072260Printer Friendly View
SECTION 1: IDENTIFICATION 1.1. Product Identifier Product Form: Product Name: A00238LP MST TRAD LEMON PL HH 20net10 CAS No: Synonyms: 1.2. Intended Use of the Product Use of the substance/mixture: 1.3. Name, Address, and Telephone of the Responsible Party Company Zep Inc. 1310 Seaboard Industrial Blvd., NW Atlanta, GA 30318 Phone: 404-352-1680 1.4. Emergency Telephone Number Emergency |1-877-428-9937, 877-541-2016, 800-424-9300, 202-483-7616 number | SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) Flammable |Category 1 aerosols | Gases under |Liquefied gas pressure | Eye irritation|Category 2A Skin |Category 1 sensitisation | Specific |Category 3 target organ |(Central toxicity - |nervous single |system) exposure | 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) |Flame |Gas Cylinder |Exclamation Mark Signal Word (GHS-US) |Danger Hazard Statements (GHS-US) |H222 Extremely flammable aerosol. |H280 Contains gas under pressure; may explode if |heated. |H317 May cause an allergic skin reaction. |H319 Causes serious eye irritation. |H336 May cause drowsiness or dizziness. Precautionary Statements |Prevention: (GHS-US) |P210 Keep away from heat, hot surfaces, sparks, open |flames and other ignition sources. No smoking. |P211 Do not spray on an open flame or other ignition |source. |P251 Pressurized container: Do not pierce or burn, |even after use. |P261 Avoid breathing dust/ fume/ gas/ mist/ vapours/ |spray. |P264 Wash skin thoroughly after handling. |P271 Use only outdoors or in a well-ventilated area. | |P272 Contaminated work clothing should not be |allowed out of the workplace. |P280 Wear eye protection/ face protection. |P280 Wear protective gloves. |Response: |P302 + P352 IF ON SKIN: Wash with plenty of soap and |water. |P304 + P340 + P312 IF INHALED: Remove victim to |fresh air and keep at rest in a position comfortable |for breathing. Call a POISON CENTER or doctor/ |physician if you feel unwell. |P305 + P351 + P338 IF IN EYES: Rinse cautiously with |water for several minutes. Remove contact lenses, if |present and easy to do. Continue rinsing. |P333 + P313 If skin irritation or rash occurs: Get |medical advice/ attention. |P337 + P313 If eye irritation persists: Get medical |advice/ attention. |P363 Wash contaminated clothing before reuse. |Storage: |P403 + P233 Store in a well-ventilated place. Keep |container tightly closed. |P405 Store locked up. |P410 + P412 Protect from sunlight. Do not expose to |temperatures exceeding 50 Â°C/ 122 Â°F. |Disposal: |P501 Dispose of contents/container in accordance |with local regulation. 2.3. Other Hazards Other Hazards Not Contributing to the Classification: 2.4. Unknown Acute Toxicity (GHS-US) SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name |Product identifier |% |Classification | | |(GHS-US) Acetone |67-64-1 |>= 70 - | | |< 90 | Propane |74-98-6 |>= 10 - | | |< 20 | Butane |106-97-8 |>= 5 - <| | |10 | PROPRIETARY Fragrance Component |Not Assigned |>= 1 - <| | |5 | Citral |5392-40-5 |>= 0.1 -| | |< 1 | SECTION 4: FIRST AID MEASURES 4.1. Description of First Aid Measures First-aid Measures General: Show this safety data sheet to the doctor in attendance. First-aid Measures After Inhalation: Remove to fresh air. Call a physician or poison control centre immediately. First-aid Measures After Skin Contact: If skin irritation persists, call a physician. If on clothes, remove clothes. Wash off immediately with plenty of water for at least 15 minutes. First-aid Measures After Eye Contact: Remove contact lenses. Protect unharmed eye. Keep eye wide open while rinsing. If eye irritation persists, consult a specialist. Rinse immediately with plenty of water for at least 15 minutes. First-aid Measures After Ingestion: If swallowed: DO NOT induce vomiting unless directed to do so by a physician or poison control center. Take victim immediately to hospital. Never give anything by mouth to an unconscious person. Keep respiratory tract clear. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: Foam Carbon dioxide (CO2) Dry chemical Water Unsuitable Extinguishing Media: High volume water jet. 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: Explosion Hazard: Hazardous combustion products: Carbon dioxide (CO2), Carbon monoxide, Smoke Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Do not allow run-off from fire fighting to enter drains or water courses. Firefighting Instructions:Use extinguishing measures that are appropriate to local circumstances and the surrounding environment. Further information: For safety reasons in case of fire, cans should be stored separately in closed containments. Use a water spray to cool fully closed containers. Protection During Firefighting: For safety reasons in case of fire, cans should be stored separately in closed containments. Use a water spray to cool fully closed containers. SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: Use personal protective equipment. Ensure adequate ventilation. Remove all sources of ignition. Evacuate personnel to safe areas. Beware of vapours accumulating to form explosive concentrations. Vapours can accumulate in low areas. 6.1.1. For Non-emergency Personnel Protective Equipment: Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: Emergency Procedures: 6.2. Environmental Precautions Prevent product from entering drains. Prevent further leakage or spillage if safe to do so. If the product contaminates rivers and lakes or drains inform respective authorities. 6.3. Methods and Material for Containment and Cleaning Up For Containment: Methods for Cleaning Up: Soak up with inert absorbent material (e.g. sand, silica gel, acid binder, universal binder, sawdust). Sweep up and shovel into suitable containers for disposal. 6.4. Reference to Other Sections See heading 8, Exposure Controls and Personal Protection. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: Do not breathe vapours or spray mist. Avoid exposure - obtain special instructions before use. Avoid contact with skin and eyes. Take precautionary measures against static discharges. Use only with adequate ventilation. Always replace cap after use. Hygiene Measures: When using do not eat or drink. When using do not smoke. Wash hands before breaks and at the end of workday. 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Storage Conditions: BEWARE: Aerosol is pressurized. Keep away from direct sun exposure and temperatures over 50 Â°C. Do not open by force or throw into fire even after use. Do not spray on flames or red-hot objects. No smoking. Observe label precautions. Electrical installations / working materials must comply with the technological safety standards. Keep in a dry, cool and well-ventilated place. Materials to avoid: Store and keep away from bases and alkalies. 7.3. Specific End Use(s) SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters Components with workplace control parameters Components CAS-No. Value type (Form of exposure) Control parameters / Permissible concentration Basis Acetone 67-64-1 TWA 500 ppm ACGIH STEL 750 ppm ACGIH TWA 250 ppm 590 mg/m3 NIOSH REL TWA 1,000 ppm 2,400 mg/m3 OSHA Z-1 STEL 750 ppm 1,800 mg/m3 OSHA P0 Propane 74-98-6 TWA 1,000 ppm 2,400 mg/m3 OSHA P0 TWA 1,000 ppm ACGIH TWA 1,000 ppm 1,800 mg/m3 NIOSH REL TWA 1,000 ppm 1,800 mg/m3 OSHA Z-1 TWA 1,000 ppm 1,800 mg/m3 OSHA P0 Butane 106-97-8 TWA 800 ppm 1,900 mg/m3 NIOSH REL TWA 800 ppm 1,900 mg/m3 OSHA P0 Biological occupational exposure limits Component CAS-No. Control parameters Biological specimen Sampling time Permissible concentration Basis 2-PROPANONE 67-64-1 Acetone Urine End of shift (As soon as possible after exposure ceases) 50 mg/l ACGIH BEI 8.2. Exposure Controls Appropriate Engineering | Controls | Personal Protective Equipment| Materials for Protective | Clothing | Hand Protection |Remarks: The suitability for a specific workplace |should be discussed with the producers of the |protective gloves. Eye Protection |Safety glasses. Ensure that eyewash stations and |safety showers are close to the workstation |location. Skin and Body Protection |Impervious clothing. Choose body protection |according to the amount and concentration of the |dangerous substance at the work place. Respiratory Protection |In case of insufficient ventilation, wear suitable |respiratory equipment. Thermal Hazard Protection | SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State | Appearance |Aerosol containing a liquefied gas Odor |characteristic Odor Threshold |no data available pH |not applicable Relative Evaporation Rate |not determined (butylacetate=1) | Melting Point |no data available Freezing Point |no data available Boiling Point |not applicable Flash Point |not applicable Auto-ignition Temperature |not determined Decomposition Temperature |no data available Flammability (solid, gas) |Extremely flammable aerosol. Vapor Pressure |no data available Relative Vapor Density at 20 Â°C |no data available Relative Density | Specific Gravity | Solubility |soluble Partition coefficient: |no data available n-octanol/water | Viscosity |no data available Lower Flammable Limit |no data available Upper Flammable Limit |no data available 9.2. Other Information SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity Stable. 10.2 Chemical Stability Stable under normal conditions. 10.3 Possibility of Hazardous Reactions Vapours may form explosive mixture with air. No decomposition if stored and applied as directed. 10.4 Conditions to Avoid Heat, flames and sparks. Extremes of temperature and direct sunlight. 10.5 Incompatible Materials Oxidizing agents Bases Amines 10.6 Hazardous Decomposition Products Carbon dioxide (CO2), Carbon monoxide SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: Product: Acute oral toxicity: Acute toxicity estimate : > 5,000 mg/kg Method: Calculation method Skin Corrosion/Irritation: Product: Remarks: Irritating to eyes. Serious Eye Damage/Irritation: Product: Remarks: Irritating to eyes. Respiratory or Skin Sensitization: Product: Remarks: Causes sensitisation. Germ Cell Mutagenicity: no data available Carcinogenicity: no data available Reproductive Toxicity: no data available. Specific Target Organ Toxicity (Single Exposure): no data available Specific Target Organ Toxicity (Repeated Exposure): no data available Aspiration Hazard: no data available Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Chronic Symptoms: SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity no data available 12.2. Persistence and Degradability no data available 12.3. Bioaccumulative Potential Product: Partition coefficient: n-octanol/water: Remarks: no data available Components: Butane: Partition coefficient: n-octanol/water: Pow: 2.89 Citral: Partition coefficient: n-octanol/water: Pow: 2.76 12.4. Mobility in Soil no data available 12.5. Other Adverse Effects no data available. Product: Regulation: 40 CFR Protection of Environment; Part 82 Protection of Stratospheric Ozone - CAA Section 602 Class I Substances Remarks: This product neither contains, nor was manufactured with a Class I or Class II ODS as defined by the U.S. Clean Air Act Section 602 (40 CFR 82, Subpt. A, App.A + B). Additional ecological information: no data available. SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: Dispose of in accordance with local regulations. Additional Information: Contaminated packaging: Empty remaining contents. Dispose of as unused product. Do not re-use empty containers. Do not burn, or use a cutting torch on, the empty drum. SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name | Hazard Class | |<PICTOGRAM PHRASE> Identification Number| | Label Codes | | ERG Number | 14.2 In Accordance with IMDG Proper Shipping Name |Vessel: AEROSOLS Hazard Class |2.1 Identification Number|UN1950 Label Codes | |<PICTOGRAM PHRASE> ntification Of The | | Substance/m | | EmS-No. (Fire) | | EmS-No. (Spillage) | | 14.3 In Accordance with IATA Proper Shipping Name |Cargo Air: Aerosols |Passenger Air: Aerosols Identification Number|AEROSOLS, |<PICTOGRAM PHRASE> Hazard Class |2.1 | Label Codes | | ntification Of The | | Substance/m | | ERG Code (IATA) | SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations EPCRA - Emergency Planning and Community Right-to-Know Act: CERCLA Reportable Quantity: Components CAS-No. Component RQ (lbs)c Calculated product RQ (lbs) Acetone 67-64-1 5000 * *: Calculated RQ exceeds reasonably attainable upper limit. SARA 304 Extremely Hazardous Substances Reportable Quantity This material does not contain any components with a section 304 EHS RQ. SARA 302: No chemicals in this material are subject to the reporting requirements of SARA Title III, Section 302. SARA 313: SARA 313: This material does not contain any chemical components with known CAS numbers that exceed the threshold (De Minimis) reporting levels established by SARA Title III, Section 313. SARA Section 311/312 Hazard Classes |Fire Hazard |Sudden Release of Pressure Hazard |Acute Health Hazard Toxic Substances Control Act (TSCA) | On TSCA Inventory 15.2 US State Regulations California Prop 65: This product does not contain any chemicals known to State of California to cause cancer, birth defects, or any other reproductive harm. SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date |02/19/2015 Other |This document has been prepared in accordance with the SDS Information |requirements of the OSHA Hazard Communication Standard 29 CFR |1910.1200. GHS Full Text Phrases: ----|Hazard statements |Extremely flammable aerosol. Contains gas -- | |under pressure; may explode if heated. May | |cause an allergic skin reaction. Causes | |serious eye irritation. May cause drowsiness | |or dizziness. ----|Precautionary statements |Prevention: Keep away from heat, hot -- | |surfaces, sparks, open flames and other | |ignition sources. No smoking. Do not spray on | |an open flame or other ignition source. | |Pressurized container: Do not pierce or burn, | |even after use. Avoid breathing dust/ fume/ | |gas/ mist/ vapours/ spray. Wash skin | |thoroughly after handling. Use only outdoors | |or in a well-ventilated area. Contaminated | |work clothing should not be allowed out of | |the workplace. Wear eye protection/ face | |protection. Wear protective gloves. | |Response: IF ON SKIN: Wash with plenty of | |soap and water. IF INHALED: Remove victim to | |fresh air and keep at rest in a position | |comfortable for breathing. Call a POISON | |CENTER or doctor/ physician if you feel | |unwell. IF IN EYES: Rinse cautiously with | |water for several minutes. Remove contact | |lenses, if present and easy to do. Continue | |rinsing. If skin irritation or rash occurs: | |Get medical advice/ attention. If eye | |irritation persists: Get medical advice/ | |attention. Wash contaminated clothing before | |reuse. | |Storage: Store in a well-ventilated place. | |Keep container tightly closed. Store locked | |up. Protect from sunlight. Do not expose to | |temperatures exceeding 50 Â°C/ 122 Â°F. | |Disposal: Dispose of contents/container in | |accordance with local regulation. Grainger disclaimer.
The information contained in this SDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this 'SDS' shall be created or inferred by any statement in this 'SDS'. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this 'SDS'. The user is responsible for full compliance.