Product Categories See All
Track Order Status
SDS Sheet 0066500Printer Friendly View
SECTION 1: IDENTIFICATION 1.1. Product Identifier Product Form: Product Name: 122GA CHAIN LUBE 5 OZ AE CAS No: Synonyms: None 1.2. Intended Use of the Product Use of the substance/mixture: Aerosol Lubricant 1.3. Name, Address, and Telephone of the Responsible Party Company ITW Permatex 10 Columbus Blvd. Hartford, CT 06106 USA Phone: (877) 376-2839 1.4. Emergency Telephone Number Emergency |800-255-3924, 00+1+ 813-248-0585 number | SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) Flammable |Category 1 aerosols | | | 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) |Flame Signal Word (GHS-US) |Danger Hazard Statements (GHS-US) |Extremely flammable aerosol Precautionary Statements |Prevention (GHS-US) |Keep away from heat/sparks/open flames/hot surfaces. |- No smoking |Do not spray on an open flame or other ignition |source |Pressurized container: Do not pierce or burn, even |after use |Storage |Protect from sunlight. Do not expose to temperatures |exceeding 50 Â°C/122 Â°F |Disposal |Dispose of contents/container to an approved waste |disposal plant 2.3. Other Hazards Other Hazards Not Contributing to the Classification: - The classification as a carcinogen or mutagen need not apply if it can be shown that the substance contains less than 0.1 % w/w 1,3-butadiene (EINECS No. 203-450-8). If the substance is not classified as a carcinogen or mutagen, at least the S-phrases (2-)9-16 (Table 3.2) should apply. This note applies only to certain complex oil-derived substances in Part 3. - The classification as a carcinogen need not apply if it can be shown that the substance contains less than 3 % DMSO extract as measured by IP 346. This note applies only to certain complex oil derived substances in Annex I. 2.4. Unknown Acute Toxicity (GHS-US) 9.9 % of the mixture consists of ingredient(s) of unknown toxicity. SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name |Product identifier |% |Classification | | |(GHS-US) DISTILLATES (PETROLEUM), |64742-53-6 |30 - 60 | HYDROTREATED | | | LIGHT NAPHTHENIC | | | DISTILLATES (PETROLEUM), |64742-52-5 |10 - 30 | HYDROTREATED | | | HEAVY NAPHTHENIC | | | PETROLEUM GASES, LIQUEFIED, |68476-86-8 |10 - 30 | SWEETENED | | | | | | | | | SECTION 4: FIRST AID MEASURES 4.1. Description of First Aid Measures First-aid Measures General: Get medical advice/attention if you feel unwell. Self-protection of the first aider: Use personal protective equipment as required. Avoid contact with skin, eyes or clothing. First-aid Measures After Inhalation: IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing. If symptoms persist, call a physician. First-aid Measures After Skin Contact: IF ON SKIN: Wash skin with soap and water. If skin irritation persists, call a physician. Wash contaminated clothing before reuse. First-aid Measures After Eye Contact: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists: Get medical advice/attention. First-aid Measures After Ingestion: IF SWALLOWED: Do NOT induce vomiting. Never give anything by mouth to an unconscious person. Call a physician. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: See section 2 for more information. Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed Note to physicians: Treat symptomatically. SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: Carbon dioxide (CO2), Dry chemical, Foam. Unsuitable Extinguishing Media: None. 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: Extremely flammable aerosol. In a fire or if heated, a pressure increase will occur and the container may burst, with the risk of a subsequent explosion. Explosion Hazard: Sensitivity to Mechanical Impact: None. Sensitivity to Static Discharge: None. Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Firefighting Instructions: Protection During Firefighting: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: Ensure adequate ventilation, especially in confined areas. Avoid contact with skin, eyes or clothing. Use personal protective equipment as required. Contents under pressure. Remove all sources of ignition. 6.1.1. For Non-emergency Personnel Protective Equipment: Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: Emergency Procedures: 6.2. Environmental Precautions See Section 12 for additional ecological information. 6.3. Methods and Material for Containment and Cleaning Up For Containment: Prevent further leakage or spillage if safe to do so. Methods for Cleaning Up: Eliminate all ignition sources if safe to do so. Ensure adequate ventilation. Soak up with inert absorbent material. Sweep up and shovel into suitable containers for disposal. Prevention of secondary hazards: Clean contaminated objects and areas thoroughly observing environmental regulations. 6.4. Reference to Other Sections See heading 8, Exposure Controls and Personal Protection. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: Handle in accordance with good industrial hygiene and safety practice. Avoid breathing vapors or mists. Avoid contact with skin, eyes or clothing. Wash thoroughly after handling. Wash contaminated clothing before reuse. Use personal protective equipment as required. Contents under pressure. Do not puncture or incinerate cans. Remove all sources of ignition. Hygiene Measures: Handle in accordance with good industrial hygiene and safety practice. Regular cleaning of equipment, work area and clothing is recommended. 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Storage Conditions: Do not expose to temperatures exceeding 50 Â°C/122 Â°F. Incompatible materials: Strong oxidizing agents. 7.3. Specific End Use(s) SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters 8.2. Exposure Controls Appropriate Engineering |Showers Controls |Eyewash stations |Ventilation systems. Personal Protective Equipment| Materials for Protective | Clothing | Hand Protection | Eye Protection |Wear safety glasses with side shields (or goggles). Skin and Body Protection |Wear protective gloves and protective clothing. Respiratory Protection |Use NIOSH-approved air-purifying respirator with |organic vapor cartridge or canister, as appropriate. Thermal Hazard Protection | SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State |Liquid; Aerosol Appearance |Brown Odor |Mild Odor Threshold |No information available pH |No information available Relative Evaporation Rate |No information available (butylacetate=1) | Melting Point |No information available Freezing Point |No information available Boiling Point |> 38 Â°C / >100 Â°F Flash Point |No information available, Gives a flame |projection at full valve opening or flashback |at any degree of valve opening Auto-ignition Temperature |No information available Decomposition Temperature |No information available Flammability (solid, gas) |No information available Vapor Pressure |No information available Relative Vapor Density at 20 Â°C | Relative Density |0.89 Specific Gravity | Solubility |Insoluble in water Partition coefficient: |No information available n-octanol/water | Viscosity |No information available Lower Flammable Limit |No information available Upper Flammable Limit |No information available 9.2. Other Information Softening point: No information available Molecular weight: No information available VOC Content (%): 19.2% Density: No information available Bulk density: No information available SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity No data available. 10.2 Chemical Stability Stable under recommended storage conditions. 10.3 Possibility of Hazardous Reactions None under normal processing. 10.4 Conditions to Avoid Heat, flames and sparks. 10.5 Incompatible Materials Strong oxidizing agents. 10.6 Hazardous Decomposition Products Carbon oxides Aldehydes SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: Skin Corrosion/Irritation: Serious Eye Damage/Irritation: Respiratory or Skin Sensitization: No information available. Germ Cell Mutagenicity: No information available. Carcinogenicity: The table below indicates whether each agency has listed any ingredient as a carcinogen. Reproductive Toxicity: Specific Target Organ Toxicity (Single Exposure): Specific Target Organ Toxicity (Repeated Exposure): Aspiration Hazard: Symptoms/Injuries After Inhalation: May cause irritation of respiratory tract. Symptoms/Injuries After Skin Contact: May cause skin irritation and/or dermatitis. Symptoms/Injuries After Eye Contact: Contact with eyes may cause irritation. May cause redness and tearing of the eyes. Symptoms/Injuries After Ingestion: Ingestion may cause irritation to mucous membranes. Chronic Symptoms: SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity Ecotoxicity: 30 % of the mixture consists of components(s) of unknown hazards to the aquatic environment. Chemical Name Algae/aquatic plants Fish Crustacea DISTILLATES (PETROLEUM), HYDROTREATED LIGHT NAPHTHENIC 64742-53-6 - 5000: 96 h Oncorhynchus mykiss mg/L LC50 1000: 48 h Daphnia magna mg/L EC50 DISTILLATES (PETROLEUM), HYDROTREATED HEAVY NAPHTHENIC 64742-52-5 - 5000: 96 h Oncorhynchus mykiss mg/L LC50 1000: 48 h Daphnia magna mg/L EC50 12.2. Persistence and Degradability No information available. 12.3. Bioaccumulative Potential No information available. 12.4. Mobility in Soil No information available. Chemical Name Partition coefficient PETROLEUM GASES, LIQUEFIED, SWEETENED 68476-86-8 <=2.8 12.5. Other Adverse Effects No information available. SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: Disposal of wastes: Disposal should be in accordance with applicable regional, national and local laws and regulations. Additional Information: Contaminated packaging: Do not reuse container. US EPA Waste Number: D001 SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name |Aerosols, Limited Quantity (LQ) Hazard Class |2.1 |<PICTOGRAM PHRASE> Identification Number|UN1950 | Label Codes | | ERG Number |126 14.2 In Accordance with IMDG Proper Shipping Name |Aerosols, Limited Quantity (LQ) Hazard Class |2.1 Identification Number|UN1950 Label Codes | |<PICTOGRAM PHRASE> ntification Of The | | Substance/m | | EmS-No. (Fire) |F-D | EmS-No. (Spillage) |S-U | 14.3 In Accordance with IATA Proper Shipping Name |Consumer commodity Identification Number|ID 8000 |<PICTOGRAM PHRASE> Hazard Class |9 | Label Codes | | ntification Of The | | Substance/m | | ERG Code (IATA) |9L SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations <COMPONENT> SARA 313: Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product does not contain any chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372. CWA (Clean Water Act): This product does not contain any substances regulated as pollutants pursuant to the Clean Water Act (40 CFR 122.21 and 40 CFR 122.42). CERCLA: This material, as supplied, does not contain any substances regulated as hazardous substances under the Comprehensive Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302) or the Superfund Amendments and Reauthorization Act (SARA) (40 CFR 355). There may be specific reporting requirements at the local, regional, or state level pertaining to releases of this material. SARA Section 311/312 Hazard Classes |Acute health hazard: |Yes |Chronic Health Hazard: |No |Fire hazard: |Yes |Sudden release of pressure hazard: No |Reactive Hazard: |No Toxic Substances Control Act (TSCA) |Complies 15.2 US State Regulations <COMPONENT> California Proposition 65: This product does not contain any Proposition 65 chemicals. U.S. State Right-to-Know Regulations: Chemical Name New Jersey Massachusetts Pennsylvania DISTILLATES (PETROLEUM), HYDROTREATED LIGHT NAPHTHENIC 64742-53-6 - X - U.S. EPA Label Information: EPA Pesticide Registration Number: Not applicable. SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date |18-Jun-2015 Other |This document has been prepared in accordance with the SDS Information |requirements of the OSHA Hazard Communication Standard 29 CFR |1910.1200. GHS Full Text Phrases: ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | Grainger disclaimer.
The information contained in this SDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this 'SDS' shall be created or inferred by any statement in this 'SDS'. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this 'SDS'. The user is responsible for full compliance.