Product Categories See All
Track Order Status
SDS Sheet 0066160Printer Friendly View
Safety Data Sheet Date of Issue: 05-27-2015 |Revision Date: |Revision Number: 01 Imperial Supplies Part Number: 0066160 SECTION 1: IDENTIFICATION 1.1. Product Identifier Product Form: Aerosol. Product Name: M1 MOLY CHAIN & CABLE LUBRICANT CAS No: Synonyms: 1.2. Intended Use of the Product Use of the substance/mixture: Lubricant. 1.3. Name, Address, and Telephone of the Responsible Party Company Sprayway, Inc. 1005 S. Westgate Drive Addison, IL 60101 United States Phone: 1-630-628-3000 1.4. Emergency Telephone Number Emergency | 1-866-836-8855, 1-952-852-4646 number | SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) Flammable |Category 1 aerosols | Sensitization,|Category 1 skin | Carcinogenicit|Category 2 y | Specific |Category 1 target organ | toxicity, | repeated | exposure | 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) |Flame |Health |Exclamat| | | | |Hazard |ion Mark| | | Signal Word (GHS-US) |Danger Hazard Statements (GHS-US) |Extremely flammable aerosol. May cause an allergic |skin reaction. Suspected of causing cancer. Causes |damage to organs through prolonged or repeated |exposure. Precautionary Statements |Prevention: (GHS-US) |Obtain special instructions before use. Do not |handle until all safety precautions have been read |and understood. Keep away from heat/sparks/open |flames/hot surfaces. - No smoking. Do not spray on |an open flame or other ignition source. Pressurized |container: Do not pierce or burn, even after use. Do |not breathe gas. Do not eat, drink or smoke when |using this product. Contaminated work clothing must |not be allowed out of the workplace. Wear protective |gloves/protective clothing/eye protection/face |protection. |Response: |If on skin: Wash with plenty of water. If exposed or |concerned: Get medical advice/attention. Specific |treatment (see this label). If skin irritation or |rash occurs: Get medical advice/attention. Wash |contaminated clothing before reuse. |Storage: |Store locked up. Protect from sunlight. Do not |expose to temperatures exceeding 50Â°C/122Â°F. |Disposal: |Not available. 2.3. Other Hazards Other Hazards Not Contributing to the Classification: None known. 2.4. Unknown Acute Toxicity (GHS-US) None. SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name |Product identifier |% |Classification | | |(GHS-US) Propane |74-98-6 |10 - 20 | Mineral Spirits |8052-41-3 |2.5 - 10| Cocoyl Diethanolamide |68603-42-9 |1 - 2.5 | Solvent Naphtha (Petroleum), |64742-88-7 |1 - 2.5 | Medium Aliphatic | | | Diethanolamine |111-42-2 |0.1 - 1 | Other components below | |60 - 80 | reportable levels | | | SECTION 4: FIRST AID MEASURES 4.1. Description of First Aid Measures First-aid Measures General: Take off all contaminated clothing immediately. IF exposed or concerned: Get medical advice/attention. If you feel unwell, seek medical advice (show the label where possible). Ensure that medical personnel are aware of the material(s) involved, and take precautions to protect themselves. Wash contaminated clothing before reuse. First-aid Measures After Inhalation: Move to fresh air. Call a physician if symptoms develop or persist. First-aid Measures After Skin Contact: Take off immediately all contaminated clothing. Wash off with soap and plenty of water. In case of eczema or other skin disorders: Seek medical attention and take along these instructions. Launder contaminated clothing before reuse. First-aid Measures After Eye Contact: Immediately flush eyes with plenty of water for at least 15 minutes. Remove contact lenses, if present and easy to do. Get medical attention if irritation develops and persists. First-aid Measures After Ingestion: Rinse mouth. Get medical attention if symptoms occur. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: Dermatitis. Rash. Direct contact with eyes may cause temporary irritation. May cause an allergic skin reaction. Prolonged exposure may cause chronic effects. Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed Provide general supportive measures and treat symptomatically. Keep victim under observation. Symptoms may be delayed. SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: Alcohol resistant foam. Water fog. Dry chemical powder. Carbon dioxide (CO2). Unsuitable Extinguishing Media: Do not use water jet as an extinguisher, as this will spread the fire. 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: Contents under pressure. Pressurized container may explode when exposed to heat or flame. During fire, gases hazardous to health may be formed. Extremely flammable aerosol. Explosion Hazard: Specific methods: Use standard firefighting procedures and consider the hazards of other involved materials. Move containers from fire area if you can do so without risk. In the event of fire and/or explosion do not breathe fumes. Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Firefighting Instructions: Move containers from fire area if you can do so without risk. Containers should be cooled with water to prevent vapor pressure build up. For massive fire in cargo area, use unmanned hose holder or monitor nozzles, if possible. If not, withdraw and let fire burn out. Protection During Firefighting: Firefighters must use standard protective equipment including flame retardant coat, helmet with face shield, gloves, rubber boots, and in enclosed spaces, SCBA. SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: Keep unnecessary personnel away. Keep people away from and upwind of spill/leak. Keep out of low areas. Eliminate all ignition sources (no smoking, flares, sparks, or flames in immediate area). Wear appropriate protective equipment and clothing during clean-up. Do not breathe gas. Do not touch damaged containers or spilled material unless wearing appropriate protective clothing. Ventilate closed spaces before entering them. Local authorities should be advised if significant spillages cannot be contained. For personal protection, see section 8 of the SDS. 6.1.1. For Non-emergency Personnel Protective Equipment: Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: Emergency Procedures: 6.2. Environmental Precautions Avoid discharge into drains, water courses or onto the ground. 6.3. Methods and Material for Containment and Cleaning Up For Containment: Methods for Cleaning Up: Refer to attached safety data sheets and/or instructions for use. Eliminate all ignition sources (no smoking, flares, sparks, or flames in immediate area). Keep combustibles (wood, paper, oil, etc.) away from spilled material. Stop leak if you can do so without risk. Move the cylinder to a safe and open area if the leak is irreparable. Use water spray to reduce vapors or divert vapor cloud drift. Isolate area until gas has dispersed. Prevent entry into waterways, sewer, basements or confined areas. Following product recovery, flush area with water. Wipe up with absorbent material (e.g. cloth, fleece). Clean surface thoroughly to remove residual contamination. For waste disposal, see section 13 of the SDS. Never return spills in original containers for re-use. 6.4. Reference to Other Sections See heading 8, Exposure Controls and Personal Protection. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: Obtain special instructions before use. Do not handle until all safety precautions have been read and understood. Pressurized container: Do not pierce or burn, even after use. Do not use if spray button is missing or defective. Do not spray on a naked flame or any other incandescent material. Do not smoke while using or until sprayed surface is thoroughly dry. Do not cut, weld, solder, drill, grind, or expose containers to heat, flame, sparks, or other sources of ignition. All equipment used when handling the product must be grounded. Use non-sparking tools and explosion-proof equipment. Do not re-use empty containers. Do not breathe gas. Do not get in eyes, on skin, on clothing. Avoid contact with eyes, skin, and clothing. When using, do not eat, drink or smoke. Use only outdoors or in a well-ventilated area. Should be handled in closed systems, if possible. Wear appropriate personal protective equipment. Wash hands thoroughly after handling. Observe good industrial hygiene practices. Wash contaminated clothing before reuse. Hygiene Measures: When using do not smoke. Always observe good personal hygiene measures, such as washing after handling the material and before eating, drinking, and/or smoking. Routinely wash work clothing and protective equipment to remove contaminants. Contaminated work clothing should not be allowed out of the workplace. 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Storage Conditions: Level 3 Aerosol. Store locked up. Pressurized container. Protect from sunlight and do not expose to temperatures exceeding 50Â°C/122 Â°F. Do not puncture, incinerate or crush. Do not handle or store near an open flame, heat or other sources of ignition. This material can accumulate static charge which may cause spark and become an ignition source. Refrigeration recommended. Store away from incompatible materials (see Section 10 of the SDS). Level 3 Aerosol. 7.3. Specific End Use(s) SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters Occupational exposure limits: US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.1000) Components Type Value Mineral Spirits (CAS 8052-41-3) PEL 2900 mg/m3 500 ppm Propane (CAS 74-98-6) PEL 1800 mg/m3 1000 ppm US. ACGIH Threshold Limit Values Components Type Value Form Diethanolamine (CAS 111-42-2) TWA 1 mg/m3 Inhalable fraction and vapor. Mineral Spirits (CAS 8052-41-3) TWA 100 ppm US. NIOSH: Pocket Guide to Chemical Hazards Components Type Value Diethanolamine (CAS 111-42-2) TWA 15 mg/m3 3 ppm Mineral Spirits (CAS 8052-41-3) Ceiling TWA 1800 mg/m3 350 mg/m3 Propane (CAS 74-98-6) TWA 1800 mg/m3 1000 ppm Biological limit values: No biological exposure limits noted for the ingredient(s). Exposure guidelines: US - California OELs: Skin designation: Diethanolamine (CAS 111-42-2) Can be absorbed through the skin. US ACGIH Threshold Limit Values: Skin designation: Diethanolamine (CAS 111-42-2) Can be absorbed through the skin. 8.2. Exposure Controls Appropriate Engineering |Explosion-proof general and local exhaust Controls |ventilation. Good general ventilation (typically 10 |air changes per hour) should be used. Ventilation |rates should be matched to conditions. If |applicable, use process enclosures, local exhaust |ventilation, or other engineering controls to |maintain airborne levels below recommended exposure |limits. If exposure limits have not been |established, maintain airborne levels to an |acceptable level. Personal Protective Equipment| Materials for Protective | Clothing | Hand Protection |Wear appropriate chemical resistant gloves. Eye Protection |If contact is likely, safety glasses with side |shields are recommended. Skin and Body Protection |Other: Wear appropriate chemical resistant clothing. |Use of an impervious apron is recommended. Respiratory Protection |If permissible levels are exceeded use NIOSH |mechanical filter / organic vapor cartridge or an |air-supplied respirator. Thermal Hazard Protection |Wear appropriate thermal protective clothing, when |necessary. SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State |Liquid. Appearance |Viscous. Liquid. Odor |Solvent. Odor Threshold |Not available. pH |Not applicable estimated Relative Evaporation Rate |Not available. (butylacetate=1) | Melting Point |Not available. Freezing Point |Not available. Boiling Point |-43.78 Â°F (-42.1 Â°C) estimated Flash Point |-156.0 Â°F (-104.4 Â°C) Propellant estimated Auto-ignition Temperature |Not available. Decomposition Temperature |Not available. Flammability (solid, gas) |Not available. Vapor Pressure |80 - 90 psig @ 70F estimated Relative Vapor Density at 20 Â°C | Relative Density |Not available. Specific Gravity |0.89 - 0.905 estimated Solubility |Not available. Partition coefficient: |Not available. n-octanol/water | Viscosity |50 - 150 cP Lower Flammable Limit |2.2 % estimated Upper Flammable Limit |9.5 % estimated 9.2. Other Information SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity The product is stable and non-reactive under normal conditions of use, storage and transport. 10.2 Chemical Stability Material is stable under normal conditions. 10.3 Possibility of Hazardous Reactions No dangerous reaction known under conditions of normal use. Hazardous polymerization does not occur. 10.4 Conditions to Avoid Avoid heat, sparks, open flames and other ignition sources. Avoid temperatures exceeding the flash point. Contact with incompatible materials. 10.5 Incompatible Materials Strong oxidizing agents. Fluorine. Chlorine. Nitrates. 10.6 Hazardous Decomposition Products No hazardous decomposition products are known. SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: Harmful in contact with skin. May cause an allergic skin reaction. Skin Corrosion/Irritation: Prolonged skin contact may cause temporary irritation. Serious Eye Damage/Irritation: Direct contact with eyes may cause temporary irritation. Respiratory or Skin Sensitization: Respiratory sensitization: Not a respiratory sensitizer. Skin sensitization: May cause an allergic skin reaction. Germ Cell Mutagenicity: No data available to indicate product or any components present at greater than 0.1% are mutagenic or genotoxic. Carcinogenicity: Suspected of causing cancer. Reproductive Toxicity: This product is not expected to cause reproductive or developmental effects. Specific Target Organ Toxicity (Single Exposure): Not classified. Specific Target Organ Toxicity (Repeated Exposure): Respiratory system. Skin. Kidneys. Central nervous system. Eyes. Lungs. Causes damage to organs through prolonged or repeated exposure. Aspiration Hazard: Not an aspiration hazard. Not likely, due to the form of the product. Symptoms/Injuries After Inhalation: May cause damage to organs through prolonged or repeated exposure by inhalation. Symptoms/Injuries After Skin Contact: Harmful in contact with skin. May cause an allergic skin reaction. Symptoms/Injuries After Eye Contact: Direct contact with eyes may cause temporary irritation. Symptoms/Injuries After Ingestion: Not available. Chronic Symptoms: If aspirated into lungs during swallowing or vomiting, may cause chemical pneumonia, pulmonary injury or death. Dermatitis. Rash. Direct contact with eyes may cause temporary irritation. May cause an allergic skin reaction. Prolonged exposure may cause chronic effects. Causes damage to organs through prolonged or repeated exposure. SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity Ecotoxicity: Harmful to aquatic life with long lasting effects. 12.2. Persistence and Degradability No data is available on the degradability of this product. 12.3. Bioaccumulative Potential No data available. 12.4. Mobility in Soil No data available. 12.5. Other Adverse Effects No other adverse environmental effects (e.g. ozone depletion, photochemical ozone creation potential, endocrine disruption, global warming potential) are expected from this component. SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: Disposal instructions: Collect and reclaim or dispose in sealed containers at licensed waste disposal site. Contents under pressure. Do not puncture, incinerate or crush. Dispose of contents/container in accordance with local/regional/national/international regulations. Local disposal regulations: Dispose in accordance with all applicable regulations. Hazardous waste code: The waste code should be assigned in discussion between the user, the producer and the waste disposal company. Waste from residues / unused products: Dispose of in accordance with local regulations. Empty containers or liners may retain some product residues. This material and its container must be disposed of in a safe manner (see: Disposal instructions). Additional Information: Contaminated packaging: Empty containers should be taken to an approved waste handling site for recycling or disposal. Since emptied containers may retain product residue, follow label warnings even after container is emptied. Do not re-use empty containers. SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name |Aerosols, flammable, (each not exceeding 1 L capacity) Hazard Class |2.1 |<PICTOGRAM PHRASE> | |Class 2 - Flammable Gases Identification Number|UN1950 | Label Codes |2.1 | ERG Number | 14.2 In Accordance with IMDG Proper Shipping Name |AEROSOLS Hazard Class |2.1 Identification Number|UN1950 Label Codes |2.1 |<PICTOGRAM PHRASE> ntification Of The | |Class 2 - Flammable Gases Substance/m | | EmS-No. (Fire) |F-D | EmS-No. (Spillage) |S-U | 14.3 In Accordance with IATA Proper Shipping Name |Aerosols, flammable Identification Number|UN1950 |<PICTOGRAM PHRASE> | |Class 2 - Flammable Gases Hazard Class |2.1 | Label Codes |2.1 | ntification Of The | | Substance/m | | ERG Code (IATA) |10L SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations <COMPONENT> This product is a "Hazardous Chemical" as defined by the OSHA Hazard Communication Standard, 29 CFR 1910.1200. CERCLA Hazardous Substance List (40 CFR 302.4) Diethanolamine (CAS 111-42-2) Listed. SARA 304 Emergency release notification: Not regulated. OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050): Not listed. SARA 302 Extremely hazardous substance: Not listed. SARA 313 (TRI reporting) Chemical name CAS number % by wt. 1,2,4-Trimethyl Benzene 95-63-6 0.1 - 1 Diethanolamine 111-42-2 0.1 - 1 Ethyl Benzene 100-41-4 0.01 - 0.1 Other federal regulations: Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List: Diethanolamine (CAS 111-42-2) Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.130): Propane (CAS 74-98-6) Safe Drinking Water Act (SDWA): Not regulated. SARA Section 311/312 Hazard Classes |Immediate Hazard - Yes |Delayed Hazard - Yes |Fire Hazard - Yes |Pressure Hazard - No |Reactivity Hazard - No Toxic Substances Control Act (TSCA) |All components are on the U.S. EPA TSCA |Inventory List. 15.2 US State Regulations <COMPONENT> US. Massachusetts RTK - Substance List: Diethanolamine (CAS 111-42-2) Mineral Spirits (CAS 8052-41-3) Propane (CAS 74-98-6) US. New Jersey Worker and Community Right-to-Know Act: Diethanolamine (CAS 111-42-2) Mineral Spirits (CAS 8052-41-3) Propane (CAS 74-98-6) US. Pennsylvania Worker and Community Right-to-Know Law: Diethanolamine (CAS 111-42-2) Mineral Spirits (CAS 8052-41-3) Propane (CAS 74-98-6) US. Rhode Island RTK: Diethanolamine (CAS 111-42-2) Propane (CAS 74-98-6) US. California Proposition 65: WARNING: This product contains a chemical known to the State of California to cause cancer. US - California Proposition 65 - CRT: Listed date/Carcinogenic substance: Cocoyl Diethanolamide (CAS 68603-42-9) Listed: June 22, 2012 Diethanolamine (CAS 111-42-2) Listed: June 22, 2012 Ethyl Benzene (CAS 100-41-4) Listed: June 11, 2004 SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date | Other |This document has been prepared in accordance with the SDS Information |requirements of the OSHA Hazard Communication Standard 29 CFR |1910.1200. GHS Full Text Phrases: ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | Grainger disclaimer.
The information contained in this SDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this 'SDS' shall be created or inferred by any statement in this 'SDS'. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this 'SDS'. The user is responsible for full compliance.