Product Categories See All
Track Order Status
SDS Sheet 0065851Printer Friendly View
Safety Data Sheet Date of Issue: 13-Feb-2015 |Revision Date: 13-Feb-2015 |Revision Number: 1.02 Imperial Supplies Part Number: 0065850 SECTION 1: IDENTIFICATION 1.1. Product Identifier Product Form: Product Name: 6585 WEB TRIM ADHESIVE-12 PK CAS No: Synonyms: None 1.2. Intended Use of the Product Use of the substance/mixture: Multi-Purpose adhesive. 1.3. Name, Address, and Telephone of the Responsible Party Company Name: American Jetway Corporation 34136 Myrtle Street Wayne, MI 48184-0126 Phone: 1.4. Emergency Telephone Number Emergency |Chemical Emergency Phone Chemtrec: number |1-800-424-9300 for US/ 1-703-527-3887 outside US |Number |Company Emergency Phone 1-800-558-2808 |Number SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) Skin |Category 2 corrosion/irri| tation | Serious eye |Category 2A damage/eye | irritation | Reproductive |Category 2 Toxicity | Specific |Category 3 target organ | toxicity | (single | exposure) | Specific |Category 2 target organ | toxicity | (repeated | exposure) | Flammable |Category 1 aerosols | Gases under |Compressed Gas pressure | 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) |Exclamat|Health |Flame |Gas | | |ion Mark|Hazard | |Cylinder| | Signal Word (GHS-US) | Hazard Statements (GHS-US) |Causes skin irritation |Causes serious eye irritation |Suspected of damaging fertility or the unborn child |May cause drowsiness or dizziness |May cause damage to organs (central nervous system |and respiratory system) through prolonged or |repeated exposure. |May be fatal if swallowed and enters airways |Extremely flammable aerosol |Contains gas under pressure; may explode if heated Precautionary Statements |Precautionary Statements - Prevention (GHS-US) |Obtain special instructions before use |Do not handle until all safety precautions have been |read and understood |Wear protective gloves/protective clothing/eye |protection/face protection |Wash face, hands and any exposed skin thoroughly |after handling |Do not breathe dust/fume/gas/mist/vapors/spray |Use only outdoors or in a well-ventilated area |Keep away from heat/sparks/open flames/hot surfaces. |- No smoking |Do not spray on an open flame or other ignition |source |Pressurized container: Do not pierce or burn, even |after use | |Precautionary Statements - Response |If exposed or concerned: Get medical |advice/attention |IF IN EYES: Rinse cautiously with water for several |minutes. Remove contact lenses, if present and easy |to do. Continue rinsing. |If eye irritation persists: Get medical |advice/attention |IF ON SKIN: Wash with plenty of soap and water. |If skin irritation occurs: Get medical |advice/attention |Take off contaminated clothing and wash before reuse | |IF INHALED: Remove person to fresh air and keep |comfortable for breathing. |Call a POISON CENTER or doctor/physician if you feel |unwell |IF SWALLOWED: Immediately call a POISON CENTER or |doctor/physician |Do NOT induce vomiting | |Precautionary Statements - Storage |Store locked up |Store in a well-ventilated place. Keep container |tightly closed |Protect from sunlight. Do not expose to temperatures |exceeding 50 Â°C/122 Â°F | |Precautionary Statements - Disposal |Dispose of contents/container to an approved waste |disposal plant 2.3. Other Hazards Other Hazards Not Contributing to the Classification: None 2.4. Unknown Acute Toxicity (GHS-US) Other information . Toxic to aquatic life with long lasting effects 0% of the mixture consists of ingredient(s) of unknown toxicity SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name |Product identifier |%* |Classification | | |(GHS-US) PROPANE/ISOBUTANE/N-BUTANE |68476-86-8 |30-40 | ACETONE |67-64-1 |30-40 | METHYL ACETATE |79-20-9 |10-20 | PETROLEUM DISTILLATE |8030-30-6 |1-10 | TOLUENE |108-88-3 |1-10 | *The exact percentage (concentration) of composition has been withheld as a trade secret. SECTION 4: FIRST AID MEASURES 4.1. Description of First Aid Measures First-aid Measures General: Avoid contact with eyes, and clothing.Avoid breathing, vapors,mist,or gas. First-aid Measures After Inhalation: Move to fresh air. If not breathing, give artificial respiration. If breathing has stopped, contact emergency medical services immediately. First-aid Measures After Skin Contact: Wash skin with soap and water. If skin irritation persists, call a physician. First-aid Measures After Eye Contact: Rinse immediately with plenty of water, also under the eyelids, for at least 15 minutes. Seek immediate medical attention/advice. First-aid Measures After Ingestion: Do NOT induce vomiting. Call a physician immediately. Never give anything by mouth to an unconscious person. Risk of product entering the lungs on vomiting after ingestion. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: Symptoms/Injuries After Inhalation: May cause skin irritation. Drowsiness. Dizziness. Difficulty breathing. Symptoms/Injuries After Skin Contact: May cause skin irritation. Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed Notes to physician: Treat symptomatically. SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: water fog. Dry chemical. Carbon dioxide (CO2). Cool containers / tanks with water spray. Unsuitable Extinguishing Media: Do not use a solid water stream as it may scatter and spread fire. 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: Explosion Hazard: Sensitivity to Mechanical Impact none. Sensitivity to Static Discharge Yes. Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Firefighting Instructions: Protection During Firefighting: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. Use shielding to protect fire-fighters from bursting containers. SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: Ensure adequate ventilation. 6.1.1. For Non-emergency Personnel Protective Equipment: Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: Emergency Procedures: 6.2. Environmental Precautions Report spills as required by local and federal regulations. 6.3. Methods and Material for Containment and Cleaning Up For Containment: Prevent further leakage or spillage if safe to do so. Methods for Cleaning Up: Contain liquid and collect with an inter,non-combustible material. 6.4. Reference to Other Sections See heading 8, Exposure Controls and Personal Protection. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: Avoid contact with eyes. Avoid breathing vapors or mists. Contents under pressure. Do not puncture or incinerate cans. Do not stick pin or any other sharp object into opening on top of can. Avoid skin contact. Use with adequate ventiliation. Keep container away from heat, flames, and all other sources of ignition. Keep can away from all sources of electricity such as electric motors and batteries. Do not spray on hot surfaces. Hygiene Measures: Handle in accordance with good industrial hygiene and safety practice. 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Keep containers tightly closed in a dry, cool and well-ventilated place. Storage Conditions: Keep containers tightly closed in a dry, cool and well-ventilated place. 7.3. Specific End Use(s) SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters Exposure Guidelines Chemical Name |ACGIH TLV |OSHA PEL |NIOSH IDLH PROPANE/ISOBUTANE/N-|74-98-6: TWA: 1000 |74-98-6:TWA: 1000 |74-98-6:IDLH: 2100 BUTANE 68476-86-8 |ppm |ppm |ppm |106-97-8: STEL: 1000|TWA: 1800 mg/m3 |TWA: 1000 ppm |ppm |(vacated) TWA: 1000 |TWA: 1800 mg/m3 |75-28-5: STEL: 1000 |ppm |106-97-8:TWA: 800 |ppm |(vacated) TWA: 1800 |ppm | |mg/m3 |TWA: 1900 mg/m3 | |106-97-8: (vacated) |75-28-5:TWA: 800 ppm | |TWA: 800 | | |ppm |TWA: 1900 mg/m3 | |(vacated) TWA: 1900 | | |mg/m3 | ACETONE 67-64-1 |STEL: 750 ppm |TWA: 1000 ppm |IDLH: 2500 ppm |TWA: 500 ppm |TWA: 2400 mg/m3 |TWA: 250 ppm | |(vacated) TWA: 750 |TWA: 590 mg/m3 | |ppm | | |(vacated) TWA: 1800 | | |mg/m3 | | |(vacated) STEL: 2400| | |mg/m3 | | |The acetone STEL | | |does not | | |apply to the | | |cellulose acetate | | |fiber industry. It | | |is in effect for all| | | | | |other sectors | | |(vacated) STEL: 1000| | |ppm | METHYL ACETATE |STEL: 250 ppm |TWA: 200 ppm |IDLH: 3100 ppm 79-20-9 |TWA: 200 ppm |TWA: 610 mg/m3 |TWA: 200 ppm | |(vacated) TWA: 200 |TWA: 610 mg/m3 | |ppm |STEL: 250 ppm | |(vacated) TWA: 610 |STEL: 760 mg/m3 | |mg/m3 | | |(vacated) STEL: 250 | | |ppm | | |(vacated) STEL: 760 | | |mg/m3 | PETROLEUM DISTILLATE|- |TWA: 100 ppm |IDLH: 1000 ppm | |TWA: 400 mg/m3 |TWA: 100 ppm 8030-30-6 | |(vacated) TWA: 100 |TWA: 400 mg/m3 | |ppm | | |(vacated) TWA: 400 | | |mg/m3 | TOLUENE |TWA: 20 ppm |TWA: 200 ppm |IDLH: 500 ppm 108-88-3 | |(vacated) TWA: 100 |TWA: 100 ppm | |ppm |TWA: 375 mg/m3 | |(vacated) TWA: 375 |STEL: 150 ppm | |mg/m3 |STEL: 560 mg/m3 | |(vacated) STEL: 150 | | |ppm | | |(vacated) STEL: 560 | | |mg/m3 | | |Ceiling: 300 ppm | 8.2. Exposure Controls Appropriate Engineering |Ventilation systems. Use adequate ventilation to Controls |keep the exposure levels below the OELs. Personal Protective Equipment| Materials for Protective | Clothing | Hand Protection | Eye Protection |Safety glasses with side-shields. Skin and Body Protection |Chemical resistant apron. Protective gloves. Respiratory Protection |If exposure limits are exceeded or irritation is |experienced, NIOSH/MSHA approved respiratory |protection should be worn. Positive-pressure |supplied air respirators may be required for high |airborne contaminant concentrations. Respiratory |protection must be provided in accordance with |current local regulations. Thermal Hazard Protection | SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State |Aerosol Appearance |opaque Odor |Solvent Odor Threshold |No information available pH |No information available Relative Evaporation Rate |No information available (butylacetate=1) | Melting Point |No information available Freezing Point |No information available Boiling Point |No information available Flash Point |-96.4 Â°C / -141 Â°F Auto-ignition Temperature |No information available Decomposition Temperature |No information available Flammability (solid, gas) |No information available Vapor Pressure |No information available Relative Vapor Density at 20 Â°C |No information available Relative Density | Specific Gravity |0.886 Solubility |Practically insoluble in Water Partition coefficient: |No information available n-octanol/water | Viscosity |No information available Lower Flammable Limit |No information available Upper Flammable Limit |No information available 9.2. Other Information VOC Content(%) 36.16 SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity No data available 10.2 Chemical Stability Stable under recommended storage conditions. 10.3 Possibility of Hazardous Reactions None under normal processing. 10.4 Conditions to Avoid Extremes of temperature and direct sunlight. 10.5 Incompatible Materials Store away from strong oxidizers and acids. 10.6 Hazardous Decomposition Products Carbon oxides. SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: 0% of the mixture consists of ingredient(s) of unknown toxicity Skin Corrosion/Irritation: Irritating to skin. Serious Eye Damage/Irritation: May cause slight irritation. Respiratory or Skin Sensitization: No information available. Germ Cell Mutagenicity: No information available. Carcinogenicity: The table below indicates whether each agency has evaluated a listed ingredient as a carcinogen. There are no known carcinogenic chemicals in this product. Chemical Name |ACGIH |IARC |NTP |OSHA TOLUENE 108-88-3|- |- |- |- Reproductive Toxicity: Suspected of damaging fertility or the unborn child. Specific Target Organ Toxicity (Single Exposure): May cause drowsiness and dizziness. Specific Target Organ Toxicity (Repeated Exposure): Causes damage to organs through prolonged or repeated exposure. Aspiration Hazard: May be fatal if swallowed and enters airways. Symptoms/Injuries After Inhalation: Exposure to high vapour concentrations may cause nervous systems effects such as headache, nausea, and dizziness. Symptoms/Injuries After Skin Contact: Irritating to skin. Prolonged skin contact may defat the skin and produce dermatitis. Symptoms/Injuries After Eye Contact: May cause slight irritation. Symptoms/Injuries After Ingestion: Not acutely toxic. Aspiration into the lungs during swallowing may cause serious lung damage which may be fatal. Chronic Symptoms: May cause adverse liver effects. Intentional misuse by deliberately concentrating and inhaling contents may be harmful or fatal. Chronic hydrocarbon abuse has been associated with irregular heart rhythms and potential cardiac arrest. Prolonged skin contact may defat the skin and produce dermatitis. SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity Chemical Name Toxicity to algae Toxicity to fish Toxicity to Microorganisms Toxicity to daphnia and other aquatic invertebrates PROPANE/ISOBUTANE/N-BUTANE 68476-86-8 - - - - ACETONE 67-64-1 - 4.74 - 6.33 mL/L LC50 Oncorhynchus mykiss 96h 6210 - 8120 mg/L LC50 Pimephales promelas 96h static 8300 mg/L LC50 Lepomis macrochirus 96h - 10294 - 17704 mg/L EC50 Daphnia magna 48h Static 12600 - 12700 mg/L EC50 Daphnia magna 48h METHYL ACETATE 79-20-9 120 mg/L EC50 Desmodesmus subspicatus 72h 250 - 350 mg/L LC50 Brachydanio rerio 96h static 295 - 348 mg/L LC50 Pimephales promelas 96h flow-through - 1026.7 mg/L EC50 Daphnia magna 48h PETROLEUM DISTILLATE 8030-30-6 4700 mg/L EC50 Pseudokirchneriella subcapitata 72h 9.2 mg/L LC50 Lepomis macrochirus 96h static - - TOLUENE 108-88-3 433 mg/L EC50 Pseudokirchneriella subcapitata 96h 12.5 mg/L EC50 Pseudokirchneriella subcapitata 72h static 11.0 - 15.0 mg/L LC50 Lepomis macrochirus 96h static 14.1 - 17.16 mg/L LC50 Oncorhynchus mykiss 96h static 15.22 - 19.05 mg/L LC50 Pimephales promelas 96h flow-through 5.89 - 7.81 mg/L LC50 Oncorhynchus mykiss 96h flow-through 50.87 - 70.34 mg/L LC50 Poecilia reticulata 96h static 12.6 mg/L LC50 Pimephales promelas 96h static 28.2 mg/L LC50 Poecilia reticulata 96h semi-static 5.8 mg/L LC50 Oncorhynchus mykiss 96h semi-static 54 mg/L LC50 Oryzias latipes 96h static - 5.46 - 9.83 mg/L EC50 Daphnia magna 48h Static 11.5 mg/L EC50 Daphnia magna 48h 12.2. Persistence and Degradability No information available. 12.3. Bioaccumulative Potential No information available. Chemical Name |log Pow PROPANE/ISOBUTANE/N-BUTANE 68476-86-8 |2.8 ACETONE 67-64-1 |-0.24 METHYL ACETATE 79-20-9 |0.18 TOLUENE 108-88-3 |2.65 12.4. Mobility in Soil 12.5. Other Adverse Effects No information available SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: Dispose of in accordance with federal, state, and local regulations. Additional Information: SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name |CONSUMER COMMODITY ORM-D |or |LIMITED QUANTITY Hazard Class | |<PICTOGRAM PHRASE> Identification Number| | Label Codes | | ERG Number | 14.2 In Accordance with IMDG Proper Shipping Name |AEROSOLS Hazard Class |2.1 Identification Number|UN1950 Label Codes | |<PICTOGRAM PHRASE> ntification Of The | | Substance/m | | EmS-No. (Fire) | | EmS-No. (Spillage) | | 14.3 In Accordance with IATA Proper Shipping Name |AEROSOLS Identification Number|UN1950 |<PICTOGRAM PHRASE> Hazard Class |2.1 | Label Codes | | ntification Of The | | Substance/m | | ERG Code (IATA) | SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations <COMPONENT> SARA Section 311/312 Hazard Classes | Acute Health Hazard |Yes |Chronic Health Hazard |Yes |Fire Hazard |Yes |Sudden Release of Pressure Hazard Yes |Reactive Hazard |no Toxic Substances Control Act (TSCA) |Chemical Name |TSCA | |PROPANE/ISOBUTANE/N-BUTANE |X | |ACETONE |X | |METHYL ACETATE |X | |PETROLEUM DISTILLATE |X | |TOLUENE |X | 15.2 US State Regulations California Proposition 65 This product contains the following Proposition 65 chemicals: Chemical Name California Prop. 65 TOLUENE - 108-88-3 Developmental Female Reproductive U.S. State Right-to-Know Regulations: Chemical Name |New Jersey |Massachusetts |Pennsylvania ACETONE 67-64-1 |X |X |X METHYL ACETATE |X |X |X 79-20-9 | | | PETROLEUM DISTILLATE|X |X |X 8030-30-6 | | | TOLUENE 108-88-3 |X |X |X SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date |13-Feb-2015 Other |This document has been prepared in accordance with the SDS Information |requirements of the OSHA Hazard Communication Standard 29 CFR |1910.1200. GHS Full Text Phrases: ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | Grainger disclaimer.
The information contained in this SDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this 'SDS' shall be created or inferred by any statement in this 'SDS'. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this 'SDS'. The user is responsible for full compliance.