Product Categories See All
Track Order Status
SDS Sheet 0065780Printer Friendly View
SECTION 1: IDENTIFICATION 1.1. Product Identifier Product Form: Product Name: CLEAN UP AEROSOL CAS No: Synonyms: JET-LUBEÂ® CLEAN UP 1.2. Intended Use of the Product Use of the substance/mixture: 1.3. Name, Address, and Telephone of the Responsible Party Company Name: Jet-Lube, Inc. 4849 Homestead Rd. Suite 232 Houston, Texas 77028 Phone: 713-670-5700 1.4. Emergency Telephone Number Emergency |CHEMTREC: +1-703-527-3887 (INTERNATIONAL) number |1-800-424-9300 (NORTH AMERICA) SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) Skin |Category 2 Corrosion/Irri| tation | Serious Eye |Category 2 Damage/Eye | Irritation | Specific |Category 3 Target Organ | Systemic | Toxicity | (Single | Exposure) | Carcinogenicit|Category 1B y | Gases under |Compressed gas pressure | 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) |Exclamation Mark |Health Hazard |Gas Cylinder Signal Word (GHS-US) |Danger Hazard Statements (GHS-US) |. Causes skin irritation |. May cause drowsiness or dizziness |. May cause cancer |. Toxic to aquatic life with long lasting effects |. Contains gas under pressure; may explode if heated Precautionary Statements |Prevention (GHS-US) |. Obtain special instructions before use. |. Do not handle until all safety precautions have |been read and understood. |. Do not puncture or incinerate container. |. Do not expose to heat or store at temperatures |above 49Â°C/120Â°F. |. Use with adequate ventilation. |. Open doors and windows or use other means to |ensure a fresh air supply during use and while |product is drying. |. If you experience any symptoms listed on this |label, increase ventilation or leave the area. |. Avoid breathing mist or vapor. |. Avoid breathing gas. |. Wash thoroughly after handling. |. Wear protective gloves/protective clothing/eye |protection/face protection. |. Avoid release to the environment. |Eyes |. IF IN EYES: Rinse cautiously with water for |several minutes. Remove contact lenses, if present |and easy to do. Continue rinsing. |. If eye irritation persists: Get medical |advice/attention. |Skin |. IF ON SKIN: Wash with plenty of water. |. Take off contaminated clothing and wash before |reuse. |. If skin irritation or rash occurs: Get medical |advice/attention. |Inhalation |. IF INHALED: Remove person to fresh air and keep |comfortable for breathing. |. Call a poison center/doctor if you feel unwell. |. If exposed or concerned: Get medical attention. |Storage |. Store locked up. |. Protect from sunlight. Store in a well-ventilated |place |. Exposure to high temperature may cause can to |burst. |Disposal |. Dispose of contents/container in accordance with |local/regional/national regulations. |. Collect spillage. 2.3. Other Hazards Other Hazards Not Contributing to the Classification: Not applicable. 2.4. Unknown Acute Toxicity (GHS-US) Other information Toxic to aquatic life with long lasting effects. When exposed to extreme heat or hot surfaces, vapors may decompose to harmful or fatal corrosive gases such as hydrogen chloride and possibly phosgene. SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name 4.1. Description of First Aid Measures First-aid Measures General: Show this safety data sheet to the doctor in attendance. First-aid Measures After Inhalation: Remove victim to fresh air and keep at rest in a position comfortable for breathing. Call a POISON CENTER or doctor/physician if you feel unwell. First-aid Measures After Skin Contact: Remove contaminated clothing. Rinse skin with water/shower. If skin irritation occurs: Get medical advice/attention. Wash contaminated clothing before reuse. First-aid Measures After Eye Contact: Rinse with water. Get medical attention if irritation develops and persists. First-aid Measures After Ingestion: In the unlikely event of swallowing contact a physician or poison control center. Rinse mouth. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: May cause drowsiness and dizziness. Headache. Nausea, vomiting. Irritation of eyes and mucous membranes. Irritation of nose and throat. Skin irritation. May cause redness and pain. Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed Provide general supportive measures and treat symptomatically. Keep victim under observation. Symptoms may be delayed. Notes to Physician Treat symptomatically. SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: Dry chemical, CO2, or water spray. Unsuitable Extinguishing Media: Do not use water jet as an extinguisher, as this will spread the fire. 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: Contents under pressure. Exposure to high temperature may cause can to burst. When exposed to extreme heat or hot surfaces, vapors may decompose to harmful or fatal corrosive gases such as hydrogen chloride and possibly phosgene. Explosion Hazard: Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Firefighting Instructions: Protection During Firefighting: Firefighters must use standard protective equipment including flame retardant coat, helmet with face shield, gloves, rubber boots, and in enclosed spaces, SCBA. In case of fire: Stop leak if safe to do so. Move containers from fire area if you can do so without risk. Containers should be cooled with water to prevent vapor pressure build up. SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: Keep unnecessary personnel away. Keep people away from and upwind of spill/leak. Keep out of low areas. Wear appropriate protective equipment and clothing during clean-up. Avoid breathing mist or vapor. Avoid breathing gas. Do not touch damaged containers or spilled material unless wearing appropriate protective clothing. Ensure adequate ventilation. 6.1.1. For Non-emergency Personnel Protective Equipment: Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: Emergency Procedures: 6.2. Environmental Precautions Local authorities should be advised if significant spillages cannot be contained. Avoid release to the environment. Do not contaminate water. Avoid discharge into drains, water courses or onto the ground. See Section 12 for additional Ecological Information. 6.3. Methods and Material for Containment and Cleaning Up For Containment: Eliminate all ignition sources (no smoking, flares, sparks, or flames in immediate area). Keep combustibles (wood, paper, oil, etc.) away from spilled material. This material is classified as a water pollutant under the Clean Water Act and should be prevented from contaminating soil or from entering sewage and drainage systems which lead to waterways. Methods for Cleaning Up: Stop the flow of material, if this is without risk. Collect spillage. Wipe up with absorbent material (e.g. cloth, fleece). Clean surface thoroughly to remove residual contamination. For waste disposal, see section 13 of the SDS. 6.4. Reference to Other Sections See heading 8, Exposure Controls and Personal Protection. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: Obtain special instructions before use. Do not handle until all safety precautions have been read and understood. Pressurized container: Do not pierce or burn, even after use. Do not use if spray button is missing or defective. Do not spray on a naked flame or any other incandescent material. Do not smoke while using or until sprayed surface is thoroughly dry. Use with adequate ventilation. Open doors and windows or use other means to ensure a fresh air supply during use and while product is drying. If you experience any symptoms listed on this label, increase ventilation or leave the area. Do not cut, weld, solder, drill, grind, or expose containers to heat, flame, sparks, or other sources of ignition. Use caution around energized equipment. The metal container will conduct electricity if it contacts a live source. This may result in injury to the user from electrical shock and/or flash fire. Avoid breathing mist or vapor. Avoid breathing gas. Avoid contact with eyes, skin, and clothing. Avoid prolonged exposure. Use only in well-ventilated areas. Should be handled in closed systems, if possible. Wear appropriate personal protective equipment. Observe good industrial hygiene practices. Avoid release to the environment. Do not empty into drains. For product usage instructions, please see the product label. Hygiene Measures: When using do not smoke. Always observe good personal hygiene measures, such as washing after handling the material and before eating, drinking, and/or smoking. Routinely wash work clothing and protective equipment to remove contaminants. 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Storage Conditions: Contents under pressure. Do not puncture or incinerate container. Do not expose to heat or store at temperatures above 49 Â°C/120 Â°F. Do not handle or store near an open flame, heat or other sources of ignition. Exposure to high temperature may cause can to burst. Store in a well-ventilated place. 7.3. Specific End Use(s) SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters Exposure Guidelines Chemical Name ACGIH TLV OSHA PEL NIOSH IDLH Tetrachloroethylene (CAS 127-18-4) Ceiling: 200 ppm TWA: 100 ppm - STEL: 100 ppm TWA: 25 ppm Carbon dioxide 124-38-9 STEL = 30000 ppm TWA: 5000 ppm TWA: 5000 ppm TWA: 9000 mg/m3 (vacated) TWA: 10000 ppm (vacated) TWA: 18000 mg/m3 (vacated) STEL: 30000 ppm (vacated) STEL: 54000 mg/m3 IDLH: 40000 ppm TWA: 5000 ppm TWA: 9000 mg/m3 STEL: 30000 ppm STEL: 54000 mg/m3 Other Exposure Guidelines: US - Minnesota Haz Subs: Skin designation applies. Tetrachloroethylene (CAS 127-18-4) Skin designation applies. 8.2. Exposure Controls Appropriate Engineering |Good general ventilation (typically 10 air changes Controls |per hour) should be used. Ventilation rates should |be matched to conditions. If applicable, use process |enclosures, local exhaust ventilation, or other |engineering controls to maintain airborne levels |below recommended exposure limits. If exposure |limits have not been established, maintain airborne |levels to an acceptable level. Eye wash facilities |and emergency shower must be available when handling |this product. Personal Protective Equipment| Materials for Protective | Clothing | Hand Protection | Eye Protection |Wear safety glasses with side shields (or goggles). Skin and Body Protection |Wear protective gloves such as: VitonÂ®. Polyvinyl |alcohol (PVA). Nitrile. Silver ShieldÂ®. Wear |appropriate chemical resistant clothing. Respiratory Protection |If engineering controls are not feasible or if |exposure exceeds the applicable exposure limits, use |a NIOSH-approved cartridge respirator with an |organic vapor cartridge. Use a self-contained |breathing apparatus in confined spaces and for |emergencies. Air monitoring is needed to determine |actual employee exposure levels. Thermal Hazard Protection |Wear appropriate thermal protective clothing, when |necessary. SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State |Aerosol Appearance |Clear water white Odor |Irritating Odor Threshold |50 ppm pH |Not available Relative Evaporation Rate |Very fast. (butylacetate=1) | Melting Point |-8.1 Â°F (-22.3 Â°C) Freezing Point | Boiling Point |250.3 Â°F (121.3 Â°C) Flash Point |None (Tag Closed Cup) Auto-ignition Temperature |No data available Decomposition Temperature |No data available Flammability (solid, gas) |No data available Vapor Pressure |1352.4 hPa estimated Relative Vapor Density at 20 Â°C |5.76 (air = 1) Relative Density |1.62 Specific Gravity | Solubility |0.02 % (77 Â°F (25 Â°C)) Partition coefficient: |No data available n-octanol/water | Viscosity |No data available Lower Flammable Limit |No data available Upper Flammable Limit |No data available 9.2. Other Information Partition coefficient (oil/water) 2.88 SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity The product is stable and non-reactive under normal conditions of use, storage and transport. 10.2 Chemical Stability Material is stable under normal conditions. 10.3 Possibility of Hazardous Reactions No dangerous reaction known under conditions of normal use. 10.4 Conditions to Avoid Heat, flames and sparks. Contact with incompatible materials. When exposed to extreme heat or hot surfaces, vapors may decompose to harmful or fatal corrosive gases such as hydrogen chloride and possibly phosgene. 10.5 Incompatible Materials Strong oxidizing agents. Strong acids. Strong bases. 10.6 Hazardous Decomposition Products Hydrogen chloride. Trace amounts of chlorine and phosgene. Carbon oxides. Halogenated materials. Carbonyl halides. SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: Skin Corrosion/Irritation: Serious Eye Damage/Irritation: Respiratory or Skin Sensitization: This product is not expected to cause skin sensitization. Germ Cell Mutagenicity: No information available. Carcinogenicity: May cause cancer. Reproductive Toxicity: This product is not expected to cause reproductive or developmental effects. Specific Target Organ Toxicity (Single Exposure): May cause drowsiness and dizziness. Specific Target Organ Toxicity (Repeated Exposure): No information available. Aspiration Hazard: May be an aspiration hazard. Symptoms/Injuries After Inhalation: Prolonged inhalation may be harmful. May cause drowsiness and dizziness. Headache. Nausea, vomiting. Symptoms/Injuries After Skin Contact: Causes skin irritation. Symptoms/Injuries After Eye Contact: Direct contact with eyes may cause temporary irritation. Symptoms/Injuries After Ingestion: Ingestion of large amounts may produce gastrointestinal disturbances including irritation, nausea, and diarrhea. Chemical Name LD50 Oral LD50 Dermal LC50 Inhalation Tetrachloroethylene > 2000 mg/kg ( Rat ) > 3000 mg/kg ( Rabbit ) > 20.4 mg/L ( Rat ) 4 h Carbon dioxide - - 470000 ppm (Rat) Chronic Symptoms: May cause drowsiness and dizziness. Headache. Nausea, vomiting. Irritation of nose and throat. Irritation of eyes and mucous membranes. Skin irritation. May cause redness and pain. SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity Toxic to aquatic life with long lasting effects. Accumulation in aquatic organisms is expected. Chemical Name Toxicity to Algae Toxicity to Fish Toxicity to Microorganisms Daphnia Magna (Water Flea) Tetrachloroethylene 127-18-4 LC50 96 h: = 19.1805 mg/L LC50 96 h: = 4.73 - 5.27 mg/L (Oncorhynchus mykiss) 12.2. Persistence and Degradability No information available. 12.3. Bioaccumulative Potential Partition coefficient n-octanol / water (log Kow) Tetrachloroethylene 2.88 12.4. Mobility in Soil 12.5. Other Adverse Effects No other adverse environmental effects (e.g. ozone depletion, photochemical ozone creation potential, endocrine disruption, global warming potential) are expected from this component. SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: This material and its container must be disposed of as hazardous waste. Consult authorities before disposal. Contents under pressure. Do not puncture, incinerate or crush. Do not allow this material to drain into sewers/water supplies. Do not contaminate ponds, waterways or ditches with chemical or used container. Dispose in accordance with all applicable regulations. Additional Information: SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name |Aerosols Hazard Class |2.2 |<PICTOGRAM PHRASE> Identification Number|UN1950 | Label Codes | | ERG Number |126 14.2 In Accordance with IMDG Proper Shipping Name |AEROSOLS, MARINE POLLUTANT Hazard Class |2.2 Identification Number|UN1950 Label Codes | |<PICTOGRAM PHRASE> ntification Of The | | Substance/m | | EmS-No. (Fire) |Not available. | EmS-No. (Spillage) |Not available. | 14.3 In Accordance with IATA Proper Shipping Name |Aerosols Identification Number|UN1950 |<PICTOGRAM PHRASE> Hazard Class |2.2 | Label Codes | | ntification Of The | | Substance/m | | ERG Code (IATA) |2P SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations This product is a "Hazardous Chemical" as defined by the OSHA Hazard Communication Standard, 29 CFR 1910.1200. SARA Section 311/312 Hazard Classes |Acute Health Hazard |Yes |Chronic Health Hazard |No |Fire Hazard |No |Sudden Release of Pressure Hazard Yes |Reactive Hazard |No Toxic Substances Control Act (TSCA) | 15.2 US State Regulations California Proposition 65: WARNING: This product contains a chemical known to the State of California to cause cancer. US - California Proposition 65 - CRT: Listed date/Carcinogenic substance Tetrachloroethylene (CAS 127-18-4) Listed: April 1, 1988 U.S. State Right-to-Know Regulations: "X" designates that the ingredients are listed on the state right to know list. Chemical Name New Jersey Massachusetts Pennsylvania Illinois Rhode Island Carbon dioxide X X X - X SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date |09-May-2015 Other |This document has been prepared in accordance with the SDS Information |requirements of the OSHA Hazard Communication Standard 29 CFR |1910.1200. GHS Full Text Phrases: ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | Grainger disclaimer.
The information contained in this SDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this 'SDS' shall be created or inferred by any statement in this 'SDS'. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this 'SDS'. The user is responsible for full compliance.