Product Categories See All
Track Order Status
SDS Sheet 0065680Printer Friendly View
SECTION 1: IDENTIFICATION | |1.1. Product Identifier Product Form: Product Name: 6568 PENETRATING OIL-12 PK CAS No: Synonyms: None 1.2. Intended Use of the Product Use of the substance/mixture: Penetrating Oil. 1.3. Name, Address, and Telephone of the Responsible Party Company: American Jetway Corporation 34136 Myrtle Street Wayne, MI 48184-0126 Phone: 734-721-5930 1.4. Emergency Telephone Number Emergency | Chemtrec 1-800-424-9300 number | SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) Skin |Category 2 corrosion/irri| tation | Aspiration |Category 1 toxicity | Flammable |Category 1 aerosols | Gases under |Compressed Gas pressure | 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) |Exclamation Mark |Health Hazard |Flame |Gas Cylinder Signal Word (GHS-US) |DANGER Hazard Statements (GHS-US) |Causes skin irritation |May be fatal if swallowed and enters airways |Extremely flammable aerosol |Contains gas under pressure; may explode if heated Precautionary Statements |Prevention: (GHS-US) |Wash face, hands and any exposed skin thoroughly |after handling |Wear protective gloves/eye protection/face |protection. |Keep away from heat/sparks/open flames/hot surfaces. |- No smoking |Do not spray on an open flame or other ignition |source |Pressurized container: Do not pierce or burn, even |after use | |Response: |Specific treatment (see first aid on this label) |IF ON SKIN: Wash with plenty of soap and water. |If skin irritation occurs: Get medical |advice/attention |Take off contaminated clothing and wash before reuse | |IF SWALLOWED: Immediately call a POISON CENTER or |doctor/physician |Do NOT induce vomiting | |Storage: |Store locked up |Protect from sunlight. Store in a well-ventilated |place |Do not expose to temperatures exceeding 122Â°F (50Â°C) | |Disposal: |Dispose of contents/container to an approved waste |disposal plant 2.3. Other Hazards Other Hazards Not Contributing to the Classification: None 2.4. Unknown Acute Toxicity (GHS-US) Harmful to aquatic life with long lasting effects. 0% of the mixture consists of ingredient(s) of unknown toxicity. SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name |Product identifier |% |Classification | | |(GHS-US) NAPHTHENIC OIL, SEVERLY HYDROT |64742-52-5 |40-50 | PROPANE/ISOBUTANE/N-BUTANE |68476-86-8 |20-30 | HYDROCARBON SOLVENT |64742-96-7 |20-30 | KEROSENE |8008-20-6 |1-10 | HYDROTREATED LIGHT DISTILLATES |64742-47-8 |1-10 | SECTION 4: FIRST AID MEASURES 4.1. Description of First Aid Measures First-aid Measures General: First-aid Measures After Inhalation: Move to fresh air. If breathing is difficult, give oxygen. Artificial respiration and/or oxygen may be necessary. If breathing has stopped, contact emergency medical services immediately. First-aid Measures After Skin Contact: Wash off immediately with soap and plenty of water while removing all contaminated clothes and shoes. If skin irritation persists, call a physician. First-aid Measures After Eye Contact: Rinse immediately with plenty of water, also under the eyelids, for at least 15 minutes. Keep eye wide open while rinsing. If symptoms persist, call a physician. First-aid Measures After Ingestion: Rinse mouth. Do NOT induce vomiting. Never give anything by mouth to an unconscious person. Drink plenty of water. Call a physician or Poison Control Center immediately. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Ingestion causing lung damage. May cause skin and eye irritation. Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed Notes to physician: Treat symptomatically. SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: Water fog.Dry chemical. Carbon dioxide (CO2). Cool containers/tanks with water spray. Unsuitable Extinguishing Media: Keep away from heat and sources of ignition. Do not smoke. Cool containers / tanks with water spray. 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: Extremely flammable. Keep product and empty container away from heat and sources of ignition. Risk of ignition. In the event of fire and/or explosion do not breathe fumes. In the event of fire, cool tanks with water spray. Explosion Hazard: Sensitivity to Mechanical Impact: none. Sensitivity to Static Discharge: Yes. Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Firefighting Instructions: Protection During Firefighting: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: Use with adequate ventiliation to keep the exposure levels below the OELS. Avoid contact with eyes. Avoid breathing vapors or mists. Contents under pressure. Do not puncture or incinerate cans.Do no stick pin or any other sharp object into opening on top of can. Avoid skin contact. Use with adequate ventilation. Keep container away from heat,flames, and all other sources of ignition. Keep can away from all sources of electricity such as electric motors and batteries. Do not spray on hot surfaces. 6.1.1. For Non-emergency Personnel Protective Equipment: Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: Emergency Procedures: 6.2. Environmental Precautions Beware of vapors accumulating to form explosive concentrations. Vapors can accumulate in low areas. Prevent further leakage or spillage if safe to do so. Do not allow material to contaminate ground water system. Prevent product from entering drains. 6.3. Methods and Material for Containment and Cleaning Up For Containment: Absorb with earth, sand or other non-combustible material and transfer to containers for later disposal. Prevent further leakage or spillage if safe to do so. Methods for Cleaning Up: Pick up and transfer to properly labeled containers. Soak up with inert absorbent material. Clean contaminated surface thoroughly. After cleaning, flush away traces with water. Take precautionary measures against static discharges. 6.4. Reference to Other Sections See heading 8, Exposure Controls and Personal Protection. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: Avoid contact with skin, eyes and clothing. Handle in accordance with good industrial hygiene and safety practice. Remove and wash contaminated clothing before re-use. Keep away from open flames, hot surfaces and sources of ignition. Take precautionary measures against static discharges. Avoid breathing vapors or mists. Contents under pressure. Do not puncture or incinerate cans. Do not stick pin or any other sharp object into opening on top of can. Hygiene Measures: Handle in accordance with good industrial hygiene and safety practice. 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Storage Conditions: Keep container tightly closed in a dry and well-ventilated place. Keep away from open flames, hot surfaces and sources of ignition. Keep in properly labeled containers. Keep out of the reach of children. Store locked up. Incompatible products: Strong acids, alkalis, or oxidizing agents. 7.3. Specific End Use(s) SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters Exposure Guidelines Chemical Name ACGIH TLV OSHA PEL NIOSH IDLH PROPANE/ISOBUTANE/N-BUTANE 68476-86-8 74-98-6: TWA: 1000 ppm 106-97-8: STEL: 1000 ppm 75-28-5: STEL: 1000 ppm 74-98-6:TWA: 1000 ppm TWA: 1800 mg/m3 (vacated) TWA: 1000 ppm (vacated) TWA: 1800 mg/m3 106-97-8: (vacated) TWA: 800 ppm (vacated) TWA: 1900 mg/m3 74-98-6:IDLH: 2100 ppm TWA: 1000 ppm TWA: 1800 mg/m3 106-97-8:TWA: 800 ppm TWA: 1900 mg/m3 75-28-5:TWA: 800 ppm TWA: 1900 mg/m3 KEROSENE 8008-20-6 TWA: 200 mg/m3 total hydrocarbon vapor application restricted to conditions in which there are negligible aerosol exposures Skin - potential significant contribution to overall exposure by the cutaneous route - TWA: 100 mg/m3 HYDROTREATED LIGHT DISTILLATES 64742-47-8 TWA: 200 PPM 8 hours - - 8.2. Exposure Controls Appropriate Engineering |Showers Controls |Eyewash stations |Ventilation systems. Personal Protective Equipment| Materials for Protective | Clothing | Hand Protection | Eye Protection |Safety glasses with side-shields. Skin and Body Protection |Chemical resistant apron. Protective gloves. Respiratory Protection |If exposure limits are exceeded or irritation is |experienced, NIOSH/MSHA approved respiratory |protection should be worn. Positive-pressure |supplied air respirators may be required for high |airborne contaminant concentrations. Respiratory |protection must be provided in accordance with |current local regulations. Thermal Hazard Protection | SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State |Aerosol Appearance |Clear Odor |Solvent Odor Threshold |No information available pH |No information available Relative Evaporation Rate |No information available (butylacetate=1) | Melting Point |No information available Freezing Point |No information available Boiling Point |No information available Flash Point |-97 Â°C / -142 Â°F, Based on propellant Auto-ignition Temperature |No information available Decomposition Temperature |No information available Flammability (solid, gas) |No information available Vapor Pressure |No information available Relative Vapor Density at 20 Â°C |No information available Relative Density | Specific Gravity |.810 Solubility |Practically insoluble Partition coefficient: |No information available n-octanol/water | Viscosity |No information available Lower Flammable Limit |No information available Upper Flammable Limit |No information available 9.2. Other Information VOC Content(%): 24.4 SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity No data available 10.2 Chemical Stability Stable under recommended storage conditions. 10.3 Possibility of Hazardous Reactions None under normal processing. 10.4 Conditions to Avoid Extremes of temperature and direct sunlight. 10.5 Incompatible Materials Strong acids, alkalis, or oxidizing agents. 10.6 Hazardous Decomposition Products None known based on information supplied. SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: Numerical measures of toxicity - Product Information Unknown Acute Toxicity 0% of the mixture consists of ingredient(s) of unknown toxicity The following values are calculated based on chapter 3.1 of the GHS document . ATEmix (oral) 69444 mg/kg ATEmix (dermal) 55611 mg/kg Skin Corrosion/Irritation: Irritating to skin. Serious Eye Damage/Irritation: Respiratory or Skin Sensitization: None known. Germ Cell Mutagenicity: None known. Carcinogenicity: The table below indicates whether each agency has evaluated a listed ingredient as a carcinogen. Reproductive Toxicity: This product does not contain any known or suspected reproductive hazards. Specific Target Organ Toxicity (Single Exposure): None under normal use conditions. Specific Target Organ Toxicity (Repeated Exposure): None under normal use conditions. Aspiration Hazard: May be fatal if swallowed and enters airways. Symptoms/Injuries After Inhalation: Avoid breathing vapors or mists. Symptoms/Injuries After Skin Contact: Irritating to skin. Repeated exposure may cause skin dryness or cracking. Prolonged skin contact may defat the skin and produce dermatitis. Avoid contact with skin. Symptoms/Injuries After Eye Contact: Avoid contact with eyes. Symptoms/Injuries After Ingestion: May be harmful if swallowed. Aspiration into the lungs during swallowing may cause serious lung damage which may be fatal. Chronic Symptoms: Harmful if swallowed. May be fatal if swallowed and enters airways. SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity Chemical Name Toxicity to algae Toxicity to fish Toxicity to microorganisms Toxicity to daphnia and other aquatic invertebrates NAPHTHENIC OIL, SEVERLY HYDROT 64742-52-5 - 5000 mg/L LC50 Oncorhynchus mykiss 96h - 1000 mg/L EC50 Daphnia magna 48h PROPANE/ISOBUTANE/NBUTANE 68476-86-8 - - - HYDROTREATED LIGHT DISTILLATES 64742-47-8 - 2.2 mg/L LC50 Lepomis macrochirus 96h static 2.4 mg/L LC50 Oncorhynchus mykiss 96h static 45 mg/L LC50 Pimephales promelas 96h flow-through - - 12.2. Persistence and Degradability No information available. 12.3. Bioaccumulative Potential No information available 12.4. Mobility in Soil 12.5. Other Adverse Effects No information available SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: This material, as supplied, is a hazardous waste according to federal regulations (40 CFR 261). Additional Information: Contaminated packaging Do not re-use empty containers. SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name |CONSUMER COMMODITY ORM-D or LIMITED QUANTITY Hazard Class | |<PICTOGRAM PHRASE> Identification Number| | Label Codes | | ERG Number | 14.2 In Accordance with IMDG Proper Shipping Name |AEROSOLS, FLAMMABLE Hazard Class |2.1 Identification Number|UN1950 Label Codes | |<PICTOGRAM PHRASE> ntification Of The | | Substance/m | | EmS-No. (Fire) | | EmS-No. (Spillage) | | 14.3 In Accordance with IATA Proper Shipping Name |AEROSOLS, FLAMMABLE Identification Number|UN1950 |<PICTOGRAM PHRASE> Hazard Class |2.1 | Label Codes | | ntification Of The | | Substance/m | | ERG Code (IATA) | SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations <COMPONENT> SARA 313 Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product does not contain any chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372. Clean Water Act: This product contains the following substances which are regulated pollutants pursuant to the Clean Water Act (40 CFR 122.21 and 40 CFR 122.42): CERCLA: This material, as supplied, contains one or more substances regulated as a hazardous substance under the Comprehensive Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302): SARA Section 311/312 Hazard Classes |Acute Health Hazard Yes |Chronic Health Hazard Yes |Fire Hazard Yes |Sudden Release of Pressure Hazard Yes |Reactive Hazard no Toxic Substances Control Act (TSCA) |Chemical Name TSCA |NAPHTHENIC OIL, |SEVERLY HYDROT X | |PROPANE/ISOBUTA |NE/N-BUTANE X | |HYDROCARBON |SOLVENT X | |KEROSENE X | |HYDROTREATED |LIGHT DISTILLATES X 15.2 US State Regulations <COMPONENT> California Proposition 65: This product does not contain any known Proposition 65 chemicals. U.S. State Right-to-Know Regulations Chemical Name New Jersey Massachusetts Pennsylvania KEROSENE 8008-20-6 X X X SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date |06-May-2015 Other |This document has been prepared in accordance with the SDS Information |requirements of the OSHA Hazard Communication Standard 29 CFR |1910.1200. GHS Full Text Phrases: ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | Grainger disclaimer.
The information contained in this SDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this 'SDS' shall be created or inferred by any statement in this 'SDS'. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this 'SDS'. The user is responsible for full compliance.