Product Categories See All
Track Order Status
SDS Sheet 0065120Printer Friendly View
SECTION 1: IDENTIFICATION | |1.1. Product Identifier Product Form: Mixture Product Name: Silicone Spray Lubricant CAS No: Synonyms: 1.2. Intended Use of the Product Use of the substance/mixture: Multi-Purpose Lubricant. 1.3. Name, Address, and Telephone of the Responsible Party Company The Blaster Corporation 8500 Sweet Valley Drive Valley View, Ohio 44125 - USA Phone: (216) 901-5800 1.4. Emergency Telephone Number Emergency | Chemtrec (800) 424-9300 number | SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) Flammable |1 Aerosol | Gases Under | Pressure | (Dissolved | Gas) | Specific |Single target organ |exposure 3 toxicity | Aspiration |1 Hazard | 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) |Flame |Gas Cylinder |Exclamation Mark |Health Hazard Signal Word (GHS-US) |Danger Hazard Statements (GHS-US) |Extremely flammable aerosol. Contains gas under |pressure; may explode if heated. May cause |drowsiness or dizziness. May be fatal if swallowed |and enters airways. Precautionary Statements |Keep away from heat/sparks/open flames/hot surfaces. (GHS-US) |- No smoking. Do not spray on an open flame or other |ignition source. Pressurized container: Do not |pierce or burn, even after use. Avoid breathing |dust/fume/gas/mist/vapours/spray. Use only outdoors |or in a well-ventilated area. If swallowed: |immediately call a poison center or |doctor/physician. Do NOT induce vomiting. If |inhaled: Remove person to fresh air and keep |comfortable for breathing. Call a poison center or |doctor if you feel unwell. Store in a |well-ventilated place. Store locked up. Do not |expose to temperatures exceeding 50 ÂºC/122 ÂºF. |Dispose of contents and container in accordance with |all local, regional, national and international |regulations. 2.3. Other Hazards Other Hazards Not Contributing to the Classification: No additional information available 2.4. Unknown Acute Toxicity (GHS-US) SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) Not applicable | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name |Product identifier |% |Classification | | |(GHS-US) Petroleum distillates, |64742-47-8 |30 - 60 |Flam. Liq. 3 hydrotreated light | | |Asp. Tox. 1 Alkanes, C9-11-iso- |68551-16-6 |30 - 60 |Flam. Liq. 1 | | |STOT SE 3 | | |Asp. Tox. 1 | | | | | | | | | SECTION 4: FIRST AID MEASURES 4.1. Description of First Aid Measures First-aid Measures General: First-aid Measures After Inhalation: If breathing is difficult, remove victim to fresh air and keep at rest in a position comfortable for breathing. Get medical advice/attention if you feel unwell. First-aid Measures After Skin Contact: In case of contact, immediately flush skin with plenty of water. Call a physician if irritation develops and persists. First-aid Measures After Eye Contact: In case of contact, immediately flush eyes with plenty of water for at least 15 minutes. If easy to do, remove contact lenses, if worn. If irritation persists, get medical attention. First-aid Measures After Ingestion: If swallowed, do NOT induce vomiting unless directed to do so by medical personnel. Never give anything by mouth to an unconscious person. Get immediate medical advice/attention. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: Symptoms/Injuries After Inhalation: Vapours may cause drowsiness and dizziness. May cause respiratory tract irritation. Symptoms/Injuries After Skin Contact: May cause skin irritation. Symptoms may include redness, drying, defatting and cracking of the skin. Symptoms/Injuries After Eye Contact: May cause eye irritation. Symptoms may include discomfort or pain, excess blinking and tear production, with possible redness and swelling. Symptoms/Injuries After Ingestion: May be fatal if swallowed and enters airways. May cause stomach distress, nausea or vomiting. This product may be aspirated into the lungs and cause chemical pneumonitis. Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed Symptoms may not appear immediately. In case of accident or if you feel unwell, seek medical advice immediately (show the label or SDS where possible). SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: Carbon dioxide, dry chemical, halons, foam. Unsuitable Extinguishing Media: None known. 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: Products of combustion may include, and are not limited to: oxides of carbon. Extremely flammable aerosol. Explosion Hazard: Heat may build pressure, rupturing closed containers, spreading fire and increasing risk of burns and injuries. Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Firefighting Instructions: Cool closed containers exposed to fire with water. Protection During Firefighting: Keep upwind of fire. Wear full fire fighting turn-out gear (full Bunker gear) and respiratory protection (SCBA). SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: 6.1.1. For Non-emergency Personnel Protective Equipment: Use personal protection recommended in Section 8. Isolate the hazard area and deny entry to unnecessary and unprotected personnel. Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: No additional information available Emergency Procedures: 6.2. Environmental Precautions 6.3. Methods and Material for Containment and Cleaning Up For Containment: Eliminate sources of ignition. Contain and/or absorb spill with inert material (e.g. sand, vermiculite), then place in a suitable container. Do not flush to sewer or allow to enter waterways. Use appropriate Personal Protective Equipment (PPE). Methods for Cleaning Up: Scoop up material and place in a disposal container. Vapours may be heavier than air and may travel along the ground to a distant ignition source and flash back. Provide ventilation. 6.4. Reference to Other Sections See heading 8, Exposure Controls and Personal Protection. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: Avoid contact with skin and eyes. Do not swallow. Avoid breathing gas, fumes, vapour or spray. When using do not eat, drink or smoke. Do not spray on an open flame or other ignition source. Obtain special instructions before use. Do not handle until all safety precautions have been read and understood. Use only outdoors or in a well-ventilated area. Keep away from sources of ignition. - No smoking. Pressurized container: Do not pierce or burn, even after use. Hygiene Measures: Wash hands before eating, drinking, or smoking. Launder contaminated clothing before reuse. 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Proper grounding procedures to avoid static electricity should be followed. Storage Conditions: Keep locked up and out of reach of children. Do not expose to temperatures exceeding 50Â°C/ 122Â°F. Store away from direct sunlight or other heat sources. Store in a dry place. Storage area: Store in a well-ventilated place. 7.3. Specific End Use(s) Not available. SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters Petroleum distillates, hydrotreated light (64742-47-8) USA ACGIH ACGIH TWA (mg/mÂ³) 200 mg/mÂ³ USA OSHA OSHA PEL (TWA) (ppm) 100 ppm 8.2. Exposure Controls Appropriate Engineering |Use ventilation adequate to keep exposures (airborne Controls |levels of dust, fume, vapor, etc.) below recommended |exposure limits. Personal Protective Equipment| Materials for Protective | Clothing | Hand Protection |Wear chemically resistant protective gloves. Eye Protection |Safety glasses or goggles are recommended when using |product. Skin and Body Protection |Wear suitable protective clothing. Respiratory Protection |A NIOSH approved respirator is recommended in poorly |ventilated areas or when permissible exposure limits |may be exceeded. Respirator selection must be based |on known or anticipated exposure levels, the hazards |of the product and the safe working limits of the |selected respirator. Thermal Hazard Protection | SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State |Gas/Pressurized Liquid. Appearance |Clear liquid. Odor |Mild aliphatic. Odor Threshold |No data available. pH |No data available. Relative Evaporation Rate |>1(NBA=1) (butylacetate=1) | Melting Point |No data available Freezing Point |No data available Boiling Point |182 Â°C / 360 Â°F Flash Point |54 Â°C / 130 Â°F TCC Auto-ignition Temperature |No data available Decomposition Temperature |No data available Flammability (solid, gas) |Flammable Aerosol. Vapor Pressure |No data available Relative Vapor Density at 20 Â°C |No data available Relative Density |0.81 Specific Gravity | Solubility |Negligible. Partition coefficient: |No data available n-octanol/water | Viscosity |No data available Lower Flammable Limit | Upper Flammable Limit | 9.2. Other Information Flame Projection = none; Heat of Combustion = 43.5 kJ/g SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity No dangerous reaction known under conditions of normal use. 10.2 Chemical Stability Stable under normal storage conditions. Extremely flammable aerosol. Contents under pressure. Container may explode if heated. Do not puncture. Do not burn. 10.3 Possibility of Hazardous Reactions No dangerous reaction known under conditions of normal use. 10.4 Conditions to Avoid Heat. Incompatible materials. Sources of ignition. 10.5 Incompatible Materials Strong oxidizing agents. Strong reducing agents. Water. 10.6 Hazardous Decomposition Products May include, and are not limited to: oxides of carbon, hydrocarbons. SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: Based on available data, the classification criteria are not met. Petroleum distillates, hydrotreated light (64742-47-8) LD50 oral rat > 5000 mg/kg LD50 dermal rabbit > 2000 mg/kg LC50 inhalation rat (mg/l) > 5.2 mg/l/4h Alkanes, C9-11-iso- (68551-16-6) LD50 oral rat 34600 mg/kg LD50 dermal rat 15400 mg/kg LC50 inhalation rat (mg/l) > 12.4 mg/l/4h Silicone Spray Lubricant ATE (oral) >2000 mg/kg, rat ATE (dermal) >2000 mg/kg, rabbit ATE (inhalation) >5 mg/l/4h, rat Skin Corrosion/Irritation: Based on available data, the classification criteria are not met. Serious Eye Damage/Irritation: Based on available data, the classification criteria are not met. Respiratory or Skin Sensitization: Based on available data, the classification criteria are not met. Germ Cell Mutagenicity: Based on available data, the classification criteria are not met. Carcinogenicity: Based on available data, the classification criteria are not met. Reproductive Toxicity: Based on available data, the classification criteria are not met. Specific Target Organ Toxicity (Single Exposure): May cause drowsiness or dizziness. Specific Target Organ Toxicity (Repeated Exposure): Based on available data, the classification criteria are not met. Aspiration Hazard: May be fatal if swallowed and enters airways. Symptoms/Injuries After Inhalation: Vapours may cause drowsiness and dizziness. May cause respiratory tract irritation. Symptoms/Injuries After Skin Contact: May cause skin irritation. Symptoms may include redness, drying, defatting and cracking of the skin. Symptoms/Injuries After Eye Contact: May cause eye irritation. Symptoms may include discomfort or pain, excess blinking and tear production, with possible redness and swelling. Symptoms/Injuries After Ingestion: May be fatal if swallowed and enters airways. May cause stomach distress, nausea or vomiting. This product may be aspirated into the lungs and cause chemical pneumonitis. Chronic Symptoms: SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity May cause long-term adverse effects in the aquatic environment. 12.2. Persistence and Degradability Silicone Spray Lubricant Persistence and degradability: Not established. 12.3. Bioaccumulative Potential Silicone Spray Lubricant Bioaccumulative potential: Not established. 12.4. Mobility in Soil No additional information available 12.5. Other Adverse Effects No additional information available SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: This material must be disposed of in accordance with all local, state, provincial, and federal regulations. The generation of waste should be avoided or minimized wherever possible. Additional Information: Flammable vapours may accumulate in the container. SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name |AEROSOLS, flammable, limited quantities Hazard Class |2.1 |[pic] Identification Number|UN1950 | Label Codes |Not applicable. | ERG Number | 14.2 In Accordance with IMDG Proper Shipping Name | Hazard Class | Identification Number| Label Codes | |<PICTOGRAM PHRASE> ntification Of The | | Substance/m | | EmS-No. (Fire) | | EmS-No. (Spillage) | | 14.3 In Accordance with IATA Proper Shipping Name | Identification Number| |<PICTOGRAM PHRASE> Hazard Class | | Label Codes | | ntification Of The | | Substance/m | | ERG Code (IATA) | SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations <COMPONENT> Petroleum distillates, hydrotreated light (64742-47-8): Listed on the United States TSCA (Toxic Substances Control Act) inventory Alkanes, C9-11-iso- (68551-16-6): Listed on the United States TSCA (Toxic Substances Control Act) inventory SARA Section 311/312 Hazard Classes | Toxic Substances Control Act (TSCA) | 15.2 US State Regulations <COMPONENT> Silicone Spray Lubricant() State or local regulations: This product does not contain a chemical known to the State of California to cause cancer, birth defects or other reproductive harm. SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date |11/26/2013 Other |This document has been prepared in accordance with the SDS Information |requirements of the OSHA Hazard Communication Standard 29 CFR |1910.1200. GHS Full Text Phrases: ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | Grainger disclaimer.
The information contained in this SDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this 'SDS' shall be created or inferred by any statement in this 'SDS'. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this 'SDS'. The user is responsible for full compliance.