Product Categories See All
Track Order Status
SDS Sheet 0055891Printer Friendly View
SECTION 1: IDENTIFICATION 1.1. Product Identifier Product Form: Product Name: Universal Mounting Paste CAS No: Synonyms: 1.2. Intended Use of the Product Use of the substance/mixture: Tire Mounting 1.3. Name, Address, and Telephone of the Responsible Party Company Rema Tip Top - North America 119 Rockland Ave. Northvale, NJ 07647 Phone: 201 256-8200 1.4. Emergency Telephone Number Emergency | North America: 800-424-9300 (CHEMTREC) International: 703-527-3887 number |(CHEMTREC) Collect Calls Accepted SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) Eye Irritation|Category 2B Germ Cell |Category 1A Mutagenicity | Reproductive |Category 1B Toxicity | Specific |Category 1 Target Organ | Systemic | Toxicity, | Repeated | Exposure | Specific |Category 2 Target Organ | Systemic | Toxicity, | Repeated | Exposure | 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) |Health Hazard Signal Word (GHS-US) |Danger! Hazard Statements (GHS-US) |H320: Causes eye irritation |H340: May cause genetic defects |H360: May damage fertility or the unborn child |H372: Causes damage to organs through prolonged or |repeated exposure |H373: May cause damage to organs through prolonged |or repeated exposure Precautionary Statements |Prevention: (GHS-US) |P201: Obtain special instructions before use. |P202: Do not handle until all safety precautions |have been read and understood. |P260: Do not breathe vapours. |P263: Avoid contact during pregnancy/while nursing. |P264: Wash hands and exposed skin thoroughly after |handling. |P270: Do not eat, drink or smoke when using this |product. |P280: Wear eye protection / face protection. |P281: Use personal protective equipment as required. | |Response: |P305 + P351 + P338: IF IN EYES: Rinse cautiously |with water for several minutes. Remove contact |lenses, if present and easy to do. Continue rinsing. | |P308 + P313: IF exposed or concerned: Get medical |advice/attention. |P314: Get medical advice/attention if you feel |unwell. |P337 + P313: If eye irritation persists: Get medical |advice/attention. |Storage: |P405: Store locked up. |Disposal: |P501: Dispose of contents/container in accordance |with local/regional/national regulations. 2.3. Other Hazards Other Hazards Not Contributing to the Classification: 2.4. Unknown Acute Toxicity (GHS-US) SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name |Product identifier |% |Classification | | |(GHS-US) Ethylene Glycol |107-21-1 |12 - 27 | | | | | | | | | | | | | SECTION 4: FIRST AID MEASURES 4.1. Description of First Aid Measures First-aid Measures General: First-aid Measures After Inhalation: Immediately move outdoors or to fresh air. If irritation occurs, seek medical attention. First-aid Measures After Skin Contact: Wash contaminated areas with mild soap and water after use. Wash contaminated clothing before reuse. If skin irritation occurs, seek medical attention. First-aid Measures After Eye Contact: Immediately flush eyes gently with plenty of water for at least 15 minutes. While washing, remove contact lenses if present and easy to do so and continue rinsing. Rinse beneath eyelids by holding eyelids apart with clean fingers while washing. If eye irritation persists, seek medical attention. First-aid Measures After Ingestion: Seek immediate medical attention. Do NOT induce vomiting. If awake and alert, rinse mouth and drink 1 glass of water to help dilute the material. Do not give liquids to a drowsy or unconscious person. If vomiting occurs, keep heads below hips to prevent aspiration. Transport to nearest medical facility for immediate treatment. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: Symptoms/Injuries After Inhalation: Nausea, irritation of the nose and airways, headache, coughing Symptoms/Injuries After Skin Contact: Slight skin irritation, burning sensation, redness, swelling, and blisters Symptoms/Injuries After Eye Contact: Eye irritation, stinging sensation, tearing, and redness, and swelling of the eyes. Symptoms/Injuries After Ingestion: Stomach or intestinal irritation, nausea, vomiting, abdominal cramps, diarrhea, lumbar pain, dizziness, drowsiness Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: Alcohol-resistant foam, Water spray, Fog Unsuitable Extinguishing Media: Dry chemicals, Carbon dioxide, & Water jets are to be used for small fires only. 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: Explosion Hazard: Hazardous Combustion Products: Alcohols, Aldehydes, Ethers, Carbon monoxide, Carbon dioxide Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Firefighting Instructions: Wear full firefighting turn-out gear (full Bunker gear), and respiratory protection (SCBA). Protection During Firefighting: Material will not burn unless preheated. Carbon monoxide may be evolved if incomplete combustion occurs. Containers exposed to intense heat from fires should be cooled with large quantities of water. Keep adjacent containers cool by spraying with water. SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: Persons not wearing proper PPE should be excluded from the area of contamination until clean-up has been completed. Ensure adequate ventilation. 6.1.1. For Non-emergency Personnel Protective Equipment: Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: Recommended to wear chemical splash goggles & gloves and discard of gloves that show tears, pinholes, or signs of wear. Wear proper garments to prevent skin exposure, such as long-sleeves and pants. Emergency Procedures: 6.2. Environmental Precautions Do not allow discharge into drains, surface waters, or sanitary sewer system. Local authorities should be advised if significant spillages cannot be contained or if material discharges into drains or ground water. 6.3. Methods and Material for Containment and Cleaning Up For Containment: Methods for Cleaning Up: Eliminate all sources of ignition and use non-sparking tools to collect absorbed material. Shovel or gather material and place in appropriate container for disposal. Wash spill area thoroughly. 6.4. Reference to Other Sections See heading 8, Exposure Controls and Personal Protection. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: Avoid open heating or agitation that may generate vapors or mists. Do not handle near heat, sparks, or other ignition sources. Use only with adequate ventilation and personal protection. Avoid contact with eyes, skin and clothing. Do not eat, drink or smoke when using this product. Hygiene Measures: Wash hands before breaks and after handling product. When using, do not eat, drink, or smoke. In case of clothes contamination, remove and wash contaminated clothing before re-use. 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Storage Conditions: Keep container tightly closed and in a dry, cool and well-ventilated area, away from direct sunlight. Keep away from food, drink, and animal foodstuffs. Incompatible Materials: Strong oxidizing agents, Strong acids, Strong bases, Permanganates, Peroxides, Dichromates, Reactive sodium compounds, Sulfur compounds, Alkali metals, Nitrates 7.3. Specific End Use(s) SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters Exposure Limits : Exposure Limits have not been established for this product. Ethylene Glycol: CAS # 107-21-1 OSHA: Ceiling Value (C) 50 ppm (125 mg/m3) ACGIH : Threshold Limiting Value (TLV) 100 mg/m3 NIOSH: Ceiling Value (C) 50 ppm (125 mg/m3) 8.2. Exposure Controls Appropriate Engineering |Use product in a well-ventilated area. Controls | Personal Protective Equipment| Materials for Protective | Clothing | Hand Protection |Recommended to wear gloves when using this product, |and to discard of gloves that show tears, pinholes, |or signs of wear. Eye Protection |Recommended to wear goggles when there is potential |for the exposure of the eyes to the product. Have a |suitable eye wash station or bottle nearby in case |of splashing into the eyes. Skin and Body Protection |Recommended to wear long-sleeved clothing, pants and |proper foot covering in order to minimize direct |skin contact with the product. If skin irritation |develops, contact your facility health and safety |professional or your local safety equipment supplier |to determine the proper personal protective |equipment for your use. Respiratory Protection |Although unlikely, a NIOSH-approved air-purifying |respirator with an appropriate cartridge and/or |filter may be appropriate under certain |circumstances where airborne concentrations are |expected to exceed exposure limits (if applicable) |or if overexposure has otherwise been determined. |Protection provided by air-purifying respirators is |limited. Use a positive pressure, air-supplied |respirator if there is any potential for |uncontrolled release, exposure levels are not known |or any other circumstances where an air-purifying |respirator may not provide adequate protection. Thermal Hazard Protection | SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State | Appearance |White paste Odor |Mild Odor Threshold |No data available pH |10.5 Relative Evaporation Rate |No data available (butylacetate=1) | Melting Point |No data available Freezing Point |No data available Boiling Point |> 126Â°F (52Â°C) Flash Point |> 241Â°F (> 116Â°C) Auto-ignition Temperature |No data available Decomposition Temperature |No data available Flammability (solid, gas) | Vapor Pressure |No data available Relative Vapor Density at 20 Â°C | Relative Density |1.02 g/cm3 (8.50 lb/gal) Specific Gravity | Solubility |Completely Soluble Partition coefficient: |No data available n-octanol/water | Viscosity |No data available Lower Flammable Limit |No data available Upper Flammable Limit |No data available 9.2. Other Information SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity No decomposition if stored and applied as directed. 10.2 Chemical Stability Stable under normal conditions. 10.3 Possibility of Hazardous Reactions Will not react under normal conditions. 10.4 Conditions to Avoid Excessive heat 10.5 Incompatible Materials Strong oxidizing agents, Strong acids, Strong bases, Permanganates, Peroxides, Dichromates, Reactive sodium compounds, Sulfur compounds, Alkali metals, Nitrates 10.6 Hazardous Decomposition Products Alcohols, Aldehydes, Ethers, Carbon monoxide, Carbon dioxide SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: This material contains ethylene glycol which is a teratogen or has germ cell mutagenic effects with long-term exposure and contact. Ethylene glycol has also been shown to cause harm to fertility or to the unborn child based on studies with laboratory animals. Repeated oral exposures of high doses may result in deposition of calcium oxalate crystals in the kidney, resulting in kidney failure. Measures of Toxicity: Acute toxicities are calculated based on component toxicities Mixture: Acute Oral Toxicity: No data available Acute Dermal Toxicity: No data available Acute Inhalation Toxicity: No data available Skin Corrosion/Irritation: Serious Eye Damage/Irritation: Respiratory or Skin Sensitization: Germ Cell Mutagenicity: Carcinogenicity: OSHA: No International Agency for Research on Cancer (IARC): No; 4 [Probably Not Carcinogenic] ACGIH: No; A5 [Not Suspected] National Toxicology Program (NTP) Report on Carcinogens: No Reproductive Toxicity: Specific Target Organ Toxicity (Single Exposure): Specific Target Organ Toxicity (Repeated Exposure): Aspiration Hazard: Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Chronic Symptoms: SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity Eco-toxicity: This substance may be harmful to aquatic organisms. It is strongly advised that this substance does not enter the environment. Ethylene Glycol: CAS # 107-21-1 Toxicity to Fish: LC50 - 18,500 mg/l (Rainbow Trout; 96 h) LC50 > 10,000 mg/l (Golden Orfe; 48 h) LC50 - 49,000 mg/l (Fathead Minnow; 96 h) Toxicity to Daphnia: EC50 - 41,000 mg/l (Daphnia; 48 h) 12.2. Persistence and Degradability Readily biodegradable 12.3. Bioaccumulative Potential Does not bioaccumulate significantly 12.4. Mobility in Soil Highly mobile 12.5. Other Adverse Effects No data available SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: Dispose of in accordance with Federal, State or Local regulations. Contaminated packaging should be emptied as far as possible before disposal. Additional Information: SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name |This product is not regulated as a hazardous material for |transport. Hazard Class | |<PICTOGRAM PHRASE> Identification Number| | Label Codes | | ERG Number | 14.2 In Accordance with IMDG Proper Shipping Name |This product is not regulated as a hazardous material for |transport. Hazard Class | Identification Number| Label Codes | |<PICTOGRAM PHRASE> ntification Of The | | Substance/m | | EmS-No. (Fire) | | EmS-No. (Spillage) | | 14.3 In Accordance with IATA Proper Shipping Name |This product is not regulated as a hazardous material for |transport. Identification Number| |<PICTOGRAM PHRASE> Hazard Class | | Label Codes | | ntification Of The | | Substance/m | | ERG Code (IATA) | SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations <COMPONENT> SARA Title III Section 302 - Extremely Hazardous Chemicals The following ingredients are subject to the supplier notification requirements of Section 302 of the Superfund Amendments and Reauthorization Act (SARA/EPCRA) and the requirements of 40 CFR Part 37 None Listed Section 313 - Toxic Chemicals The following ingredients are subject to the supplier notification requirements of Section 313 of the Superfund Amendments and Reauthorization Act (SARA/EPCRA) and the requirements of 40 CFR Part 37 Component CAS # Weight % CERCLA RQ Ethylene Glycol 107-21-1 12 - 27 5,000 SARA Section 311/312 Hazard Classes | Toxic Substances Control Act (TSCA) | 15.2 US State Regulations <COMPONENT> California Proposition 65 This product does not contain materials known to the state of California to cause cancer, birth defects, and other reproductive harm. California Hazardous Substances List Massachusetts Hazardous Substances List New Jersey RTK Hazardous Substances List New Jersey TCPA Extremely Hazardous Substances List Pennsylvania Hazardous Substances List SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date |1/29/2014 Other |This document has been prepared in accordance with the SDS Information |requirements of the OSHA Hazard Communication Standard 29 CFR |1910.1200. GHS Full Text Phrases: ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | Grainger disclaimer.
The information contained in this SDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this 'SDS' shall be created or inferred by any statement in this 'SDS'. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this 'SDS'. The user is responsible for full compliance.