Product Categories See All
Track Order Status
SDS Sheet 0055840Printer Friendly View
SECTION 1: IDENTIFICATION 1.1. Product Identifier Product Form: Product Name: Ru-Glyde CAS No: Synonyms: Tire Mounting Lubricant 1.2. Intended Use of the Product Use of the substance/mixture: Tire Mounting and Rubber Lubricant 1.3. Name, Address, and Telephone of the Responsible Party Company AGS Company P.O. Box 729 Muskegon, MI 49443 Phone: 800-253-0403 1.4. Emergency Telephone Number Emergency | 800-255-3924 number | SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) Acute Oral |Category 4 Toxicity | Acute |Category 4 Inhalation | Toxicity - | Dusts and | Mists | Skin |Category 2 Corrosion/Irri| tation | Serious Eye |Category 2 Damage/Eye | Irritation | Carcinogenicit|Category 1A y | Reproductive |Category 1A Toxicity | 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) |Exclamation Mark |Health Hazard Signal Word (GHS-US) |Danger Hazard Statements (GHS-US) |Harmful if swallowed |Harmful if inhaled |Causes skin irritation |Causes serious eye irritation |May cause cancer |May damage fertility or the unborn child Precautionary Statements |Prevention: (GHS-US) |Avoid breathing dust/fume/gas/mist/vapors/spray |Use only outdoors or in a well-ventilated area |Wash face, hands and any exposed skin thoroughly |after handling |Do not eat, drink or smoke when using this product |Obtain special instructions before use |Do not handle until all safety precautions have been |read and understood |Use personal protective equipment as required |Wear protective gloves/protective clothing/eye |protection/face protection |General Advice: |If exposed or concerned: Get medical |attention/advice |Eyes: |IF IN EYES: Rinse cautiously with water for several |minutes. Remove contact lenses, if present and easy |to do. Continue rinsing |If eye irritation persists: Get medical |advice/attention |Skin: |IF ON SKIN: Wash with plenty of soap and water |If skin irritation occurs: Get medical |advice/attention |Take off contaminated clothing and wash before reuse | |Inhalation: |IF INHALED: Remove victim to fresh air and keep at |rest in a position comfortable for breathing |Call a POISON CENTER or doctor/physician if you feel |unwell. |Ingestion: |IF SWALLOWED: Call a POISON CENTER or |doctor/physician if you feel unwell |Rinse mouth |Storage: |Store locked up. |Disposal: |Dispose of contents/container to an approved waste |disposal plan 2.3. Other Hazards Other Hazards Not Contributing to the Classification: Not applicable 2.4. Unknown Acute Toxicity (GHS-US) 0% of the mixture consists of ingredient(s) of unknown toxicity. SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name |Product identifier |% |Classification | | |(GHS-US) Potassium hydroxide |1310-58-3 |7.08 | Ethylene glycol |107-21-1 |2.28 | Petroleum distillates, solvent |64742-65-0 |0.16 | dewaxed heavy paraffinic | | | | | | | | | SECTION 4: FIRST AID MEASURES 4.1. Description of First Aid Measures First-aid Measures General: First-aid Measures After Inhalation: IF INHALED: Remove to fresh air and keep at rest in a position comfortable for breathing Call a POISON CENTER or doctor/physician if exposed or you feel unwell First-aid Measures After Skin Contact: Wash off immediately with soap and plenty of water. Get medical attention if irritation develops and persists. Remove and wash contaminated clothing before re-use. First-aid Measures After Eye Contact: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. First-aid Measures After Ingestion: IF SWALLOWED: Call a POISON CENTER or doctor/ physician if you feel unwell Rinse mouth. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: Irritation. Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed Notes to Physician Treat symptomatically. SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: Use extinguishing measures that are appropriate to local circumstances and the surrounding environment. Unsuitable Extinguishing Media: None 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: Containers may explode when heated. Explosion Hazard: Sensitivity to Mechanical Impact: None. Sensitivity to Static Discharge: None. Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Firefighting Instructions: Protection During Firefighting: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: Use personal protective equipment. Avoid contact with skin, eyes and clothing. Wash thoroughly after handling. 6.1.1. For Non-emergency Personnel Protective Equipment: Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: Emergency Procedures: 6.2. Environmental Precautions See Section 12 for additional Ecological Information Do not allow material to contaminate ground water system. Do not flush into surface water or sanitary sewer system. 6.3. Methods and Material for Containment and Cleaning Up For Containment: Dike far ahead of liquid spill for later disposal. Methods for Cleaning Up: Soak up with inert absorbent material (e.g. sand, silica gel, acid binder, universal binder, sawdust). Use personal protective equipment. Sweep up and shovel into suitable containers for disposal. Clean contaminated surface thoroughly. 6.4. Reference to Other Sections See heading 8, Exposure Controls and Personal Protection. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: Ensure adequate ventilation. Wear personal protective equipment. Avoid contact with skin, eyes and clothing. Remove and wash contaminated clothing before re-use. Avoid breathing vapors or mists. Wash thoroughly after handling. Hygiene Measures: Do not eat, drink or smoke when using this product. Remove and wash contaminated clothing before re-use. Provide regular cleaning of equipment, work area and clothing. 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Storage Conditions: Keep container tightly closed in a dry and well-ventilated place. Keep out of the reach of children. Incompatible Products: Hydrazine, Acids, Halogenated compounds, Strong oxidizing agents. 7.3. Specific End Use(s) SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters Exposure Guidelines: Chemical Name ACGIH TLV OSHA PEL NIOSH IDLH Potassium hydroxide 1310-58-3 Ceiling: 2 mg/m3 (vacated) Ceiling: 2 mg/m3 Ceiling: 2 mg/m3 Sodium dichromate, dihydrate 7789-12-0 TWA: 0.05 mg/m3 Cr (vacated) Ceiling: 0.1 mg/m3 Ceiling: 0.1 mg/m3 CrO3 applies to any operations or sectors for which the Hexavalent Chromium standard [29 CFR 1910.1026] is stayed or is otherwise not in effect IDLH: 15 mg/m3 Cr(VI) TWA: 0.001 mg/m3 Cr Ethylene glycol 107-21-1 Ceiling: 100 mg/m3 aerosol only (vacated) Ceiling: 50 ppm (vacated) Ceiling: 125 mg/m3 - Petroleum distillates, solvent dewaxed heavy paraffinic 64742-65-0 TWA: 5 mg/m3, as oil mist, Mineral STEL: TWA: 10 mg/m3, as oil mist, mineral TWA: 5 mg/m3, as oil mist, mineral - Triethanolamine 102-71-6 TWA: 5 mg/m3 - - 8.2. Exposure Controls Appropriate Engineering |Showers Controls |Eyewash stations |Ventilation systems Personal Protective Equipment| Materials for Protective | Clothing | Hand Protection | Eye Protection |Tightly fitting safety goggles. Skin and Body Protection |Protective gloves. Respiratory Protection |If exposure limits are exceeded or irritation is |experienced, NIOSH/MSHA approved respiratory |protection should be worn. Positive-pressure |supplied air respirators may be required for high |airborne contaminant concentrations. Respiratory |protection must be provided in accordance with |current local regulations. Thermal Hazard Protection | SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State |Liquid Appearance |Tea colored Odor |Odorless Odor Threshold |No information available pH |9.6 Relative Evaporation Rate |Slower than Butyl Acetate (butylacetate=1) | Melting Point |No data available Freezing Point | Boiling Point |100 Â°C / 212 Â°F Flash Point |No data available Auto-ignition Temperature |No data available Decomposition Temperature |No data available Flammability (solid, gas) |No data available Vapor Pressure |No data available Relative Vapor Density at 20 Â°C | Relative Density |No data available Specific Gravity |1.01 Solubility |Completely soluble Partition coefficient: |No data available n-octanol/water | Viscosity |No data available Lower Flammable Limit |No data available Upper Flammable Limit |No data available 9.2. Other Information VOC Content (%): No data available SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity No data available. 10.2 Chemical Stability Stable under recommended storage conditions. 10.3 Possibility of Hazardous Reactions None under normal processing. 10.4 Conditions to Avoid None known based on information supplied. 10.5 Incompatible Materials Hydrazine, Acids, Halogenated compounds, Strong oxidizing agents. 10.6 Hazardous Decomposition Products Sodium oxides. Potassium oxides. SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: Skin Corrosion/Irritation: Causes skin irritation. Serious Eye Damage/Irritation: Causes serious eye irritation. Respiratory or Skin Sensitization: No information available. Germ Cell Mutagenicity: No information available. Carcinogenicity: Petroleum products are known to cause cancer because of carcinogenic components (e.g. benzene, DMSO). These carcinogenic components are typically found in crude petroleum products and are removed through the refinement process. Reproductive Toxicity: No information available. Specific Target Organ Toxicity (Single Exposure): No information available. Specific Target Organ Toxicity (Repeated Exposure): No information available. Aspiration Hazard: No information available. Symptoms/Injuries After Inhalation: Harmful by inhalation. Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Harmful if swallowed Chronic Symptoms: Irritation SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity The environmental impact of this product has not been fully investigated. Chemical Name Toxicity to Algae Toxicity to Fish Toxicity to Microorganisms Daphnia Magna (Water Flea) Potassium hydroxide 1310-58-3 LC50 96 h: = 80 mg/L static (Gambusia affinis) Ethylene glycol 107-21-1 EC50 96 h: 6500 - 13000 mg/L (Pseudokirchneriella subcapitata) LC50 96 h: 14 - 18 mL/L static (Oncorhynchus mykiss) LC50 96 h: 40000 - 60000 mg/L static (Pimephales promelas) LC50 96 h: = 16000 mg/L static (Poecilia reticulata) LC50 96 h: = 27540 mg/L static (Lepomis macrochirus) LC50 96 h: = 40761 mg/L static (Oncorhynchus mykiss) LC50 96 h: = 41000 mg/L (Oncorhynchus mykiss) EC50 = 10000 mg/L 16 H EC50 = 620 mg/L 30 min EC50 = 620.0 mg/L 30 min EC50 48 h: = 46300 mg/L (Daphnia magna) Petroleum distillates, solvent dewaxed heavy paraffinic 64742-65-0 LC50 96 h: > 5000 mg/L (Oncorhynchus mykiss) EC50 48 h: > 1000 mg/L (Daphnia magna) Triethanolamine 102-71-6 EC50 72 h: = 216 mg/L (Desmodesmus subspicatus) EC50 96 h: = 169 mg/L (Desmodesmus subspicatus) LC50 96 h: 10600 - 13000 mg/L flow-through (Pimephales promelas) LC50 96 h: > 1000 mg/L static (Pimephales promelas) LC50 96 h: 450 - 1000 mg/L static (Lepomis macrochirus) EC50 24 h: = 1386 mg/L (Daphnia magna) 12.2. Persistence and Degradability No information available. 12.3. Bioaccumulative Potential No information available. Chemical Name Log Pow Potassium hydroxide 0.83 Ethylene glycol -1.93 12.4. Mobility in Soil 12.5. Other Adverse Effects No information available. SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: This material may be a hazardous waste under 40 CFR 261, when discarded. Additional Information: Contaminated Packaging: Do not re-use empty containers. SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name |Not regulated Hazard Class | |<PICTOGRAM PHRASE> Identification Number| | Label Codes | | ERG Number | 14.2 In Accordance with IMDG Proper Shipping Name |Not regulated Hazard Class | Identification Number| Label Codes | |<PICTOGRAM PHRASE> ntification Of The | | Substance/m | | EmS-No. (Fire) | | EmS-No. (Spillage) | | 14.3 In Accordance with IATA Proper Shipping Name |Not regulated. Identification Number| |<PICTOGRAM PHRASE> Hazard Class | | Label Codes | | ntification Of The | | Substance/m | | ERG Code (IATA) | SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations <COMPONENT> Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product contains a chemical or chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372: Chemical Name CAS-No Weight % SARA 313 - Threshold Values % Ethylene glycol 107-21-1 2.28 1.0 Clean Water Act: This product contains the following substances which are regulated pollutants pursuant to the Clean Water Act (40 CFR 122.21 and 40 CFR 122.42): Chemical Name CWA - Reportable Quantities CWA - Toxic Pollutants CWA - Priority Pollutants CWA - Hazardous Substances Potassium hydroxide 1000 lb X CERCLA This material, as supplied, contains one or more substances regulated as a hazardous substance under the Comprehensive Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302): Chemical Name Hazardous Substances RQs Extremely Hazardous Substances RQs RQ Potassium hydroxide 1000 lb RQ 1000 lb final RQ RQ 454 kg final RQ Ethylene glycol 5000 lb RQ 5000 lb final RQ RQ 2270 kg final RQ SARA Section 311/312 Hazard Classes |Acute Health Hazard: |Yes |Chronic Health Hazard: |Yes |Fire Hazard: |No |Sudden Release of Pressure Hazard: No |Reactive Hazard: |No Toxic Substances Control Act (TSCA) |Complies 15.2 US State Regulations <COMPONENT> California Proposition 65: This product contains the following Proposition 65 chemicals: Chemical Name CAS-No California Prop. 65 Sodium dichromate, dihydrate 7789-12-0 Carcinogen Developmental U.S. State Right-to-Know Regulations: Chemical Name New Jersey Massachusetts Pennsylvania Illinois Rhode Island Potassium hydroxide X X X X Sodium dichromate, dihydrate X X X Ethylene glycol X X X X X Petroleum distillates, solvent dewaxed heavy paraffinic X SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date |21-Nov-2013 Other |This document has been prepared in accordance with the SDS Information |requirements of the OSHA Hazard Communication Standard 29 CFR |1910.1200. GHS Full Text Phrases: ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | Grainger disclaimer.
The information contained in this SDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this 'SDS' shall be created or inferred by any statement in this 'SDS'. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this 'SDS'. The user is responsible for full compliance.