Product Categories See All
Track Order Status
SDS Sheet 0055300Printer Friendly View
SECTION 1: IDENTIFICATION 1.1. Product Identifier Product Form: Product Name: FIC Fuel Injector Cleaner CAS No: Synonyms: 1.2. Intended Use of the Product Use of the substance/mixture: Gasoline additive 1.3. Name, Address, and Telephone of the Responsible Party Company : The Blaster Corporation 8500 Sweet Valley Drive Valley View, Ohio 44125 - USA Telephone: (216) 901-5800 1.4. Emergency Telephone Number Emergency | Chemtrec (800) 424-9300 number | SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) Flammable |3 liquid | Eye irritation|2A Carcinogenicit|2 y | Specific |3 target organ | toxicity - | Single | exposure | Aspiration |1 toxicity | 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) |Flame |Exclamation Mark |Health Hazard Signal Word (GHS-US) |Danger Hazard Statements (GHS-US) |Flammable liquid and vapor. Causes serious eye |irritation. Suspected of causing cancer. May cause |drowsiness or dizziness. May be fatal if swallowed |and enters airways. Precautionary Statements |Keep away from heat/sparks/open flames/hot (GHS-US) |surfaces.- No smoking. Keep container tightly |closed. Ground/Bond container and receiving |equipment. Use explosion-proof |electrical/ventilating/lighting equipment. Use only |non-sparking tools. Take precautionary measures |against static discharge. Wash hands thoroughly |after handling. Obtain special instructions before |use. Do not handle until all safety precautions have |been read and understood. Wear protective |gloves/protective clothing/ eye protection/face |protection. Avoid breathing dust/fume/ |gas/mist/vapors/spray. Use only outdoors or in a |well-ventilated area. If exposed or concerned: Get |medical advice/attention. If on skin (or hair): Take |off immediately all contaminated clothing. Rinse |skin with water/shower. If in eyes: Rinse cautiously |with water for several minutes. Remove contact |lenses, if present and easy to do. Continue rinsing. |If eye irritation persists: Get medical |advice/attention. If inhaled: Remove person to fresh |air and keep comfortable for breathing. Call a |poison center/doctor if you feel unwell. If |swallowed: Immediately call a poison center/doctor. |Do NOT induce vomiting. Store in a well-ventilated |place. Keep cool. Store locked up. Dispose of |contents/container in accordance with |local/regional/national/international regulations. 2.3. Other Hazards Other Hazards Not Contributing to the Classification: No additional information available. 2.4. Unknown Acute Toxicity (GHS-US) SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name |Product identifier |% |Classification | | |(GHS-US) Petroleum distillates, |64742-47-8 |60 - 100|Flam. Liq. 3 hydrotreated light | | |Asp. Tox. 1 Isopropyl alcohol |67-63-0 |7 - 13 |Flam. Liq. 2 | | |Eye Irrit. 2A | | |STOT SE 3 Solvent naphtha, petroleum, |64742-95-6 |1 - 5 |Flam. Liq. 3 light aromatic | | |Skin Irrit. 2 | | |Eye Irrit. 2A | | |Asp. Tox. 1 Cumene |98-82-8 |0.1 - 1 |Flam. Liq. 3 | | |Carc. 2 | | |STOT SE3 | | |Asp. Tox. 1 | | | SECTION 4: FIRST AID MEASURES 4.1. Description of First Aid Measures First-aid Measures General: First-aid Measures After Inhalation: If inhaled, remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. Get medical advice/attention if you feel unwell. First-aid Measures After Skin Contact: In case of contact, immediately flush skin with plenty of water. Remove contaminated clothing and shoes. Wash clothing before reuse. Call a physician if irritation develops and persists. First-aid Measures After Eye Contact: In case of contact, immediately flush eyes with plenty of water for at least 15 minutes. If easy to do, remove contact lenses, if worn. If irritation persists, get medical attention. First-aid Measures After Ingestion: Do NOT induce vomiting. Never give anything by mouth to an unconscious person. Get immediate medical advice/attention. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: Symptoms/Injuries After Inhalation: May cause drowsiness, dizziness and central nervous system depression. May cause respiratory tract irritation. Symptoms/Injuries After Skin Contact: May cause skin irritation. Symptoms may include redness, drying, defatting and cracking of the skin. Symptoms/Injuries After Eye Contact: Causes serious eye irritation. Symptoms may include discomfort or pain, excess blinking and tear production, with marked redness and swelling of the conjunctiva. Symptoms/Injuries After Ingestion: May be fatal if swallowed and enters airways. This product may be aspirated into the lungs and cause chemical pneumonitis. May cause stomach distress, nausea or vomiting. Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed Symptoms may not appear immediately. In case of accident or if you feel unwell, seek medical advice immediately (show the label or SDS where possible). SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: Dry chemical, foam, carbon dioxide. Unsuitable Extinguishing Media: Do not use a heavy water stream. 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: Products of combustion may include, and are not limited to: oxides of carbon, oxides of nitrogen. Explosion Hazard: Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Firefighting Instructions: Protection During Firefighting: Keep upwind of fire. Wear full fire fighting turn-out gear (full Bunker gear) and respiratory protection (SCBA). Use water spray to keep fire-exposed containers cool. SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: Use personal protection recommended in Section 8. Isolate the hazard area and deny entry to unnecessary and unprotected personnel. Eliminate sources of ignition. 6.1.1. For Non-emergency Personnel Protective Equipment: Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: Emergency Procedures: 6.2. Environmental Precautions 6.3. Methods and Material for Containment and Cleaning Up For Containment: Contain and/or absorb spill with inert material (e.g. sand, vermiculite), then place in a suitable container. Do not flush to sewer or allow to enter waterways. Use appropriate Personal Protective Equipment (PPE). Methods for Cleaning Up: Scoop up material and place in a disposal container. Provide ventilation. 6.4. Reference to Other Sections See section 8 for further information on protective clothing and equipment and section 13 for advice on waste disposal. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: Keep away from sources of ignition - No smoking. Avoid contact with skin and eyes. Avoid breathing gas/mist/vapours/spray. Do not swallow. Handle and open container with care. Use only non-sparking tools. When using do not eat, drink or smoke. Use only outdoors or in a well-ventilated area. Hygiene Measures: Launder contaminated clothing before reuse. Wash hands before eating, drinking, or smoking. 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Storage Conditions: Keep out of the reach of children. Keep container tightly closed and in a well-ventilated place. Store locked up. Keep cool. Keep away from heat, sparks, and flame. 7.3. Specific End Use(s) Not available. SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters Petroleum distillates, hydrotreated light (64742-47-8) USA ACGIH ACGIH TWA Not applicable USA OSHA OSHA PEL (TWA) Not applicable Isopropyl alcohol (67-63-0) USA ACGIH ACGIH TWA (ppm) 200 ppm USA ACGIH ACGIH STEL (ppm) 400 ppm USA OSHA OSHA PEL (TWA) (mg/mÂ³) 980 mg/mÂ³ USA OSHA OSHA PEL (TWA) (ppm) 400 ppm Solvent naphtha, petroleum, light aromatic (64742-95-6) USA ACGIH ACGIH TWA Not applicable USA OSHA OSHA PEL (TWA) Not applicable Cumene (98-82-8) USA ACGIH ACGIH TWA (ppm) 50 ppm USA OSHA OSHA PEL (TWA) (mg/mÂ³) 245 mg/mÂ³ USA OSHA OSHA PEL (TWA) (ppm) 50 ppm 8.2. Exposure Controls Appropriate Engineering |Use ventilation adequate to keep exposures (airborne Controls |levels of dust, fume, vapor, etc.) below recommended |exposure limits. Personal Protective Equipment| Materials for Protective | Clothing | Hand Protection |Wear chemically resistant protective gloves. Eye Protection |Wear eye protection. Skin and Body Protection |Wear suitable protective clothing. Respiratory Protection |In case of insufficient ventilation, wear suitable |respiratory equipment;Respirator selection must be |based on known or anticipated exposure levels, the |hazards of the product and the safe working limits |of the selected respirator. Thermal Hazard Protection | SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State |Liquid. Appearance |Clear. Odor |Aromatic Odor Threshold |No data available. pH |No data available. Relative Evaporation Rate |>1 (butylacetate=1) | Melting Point |No data available. Freezing Point |No data available. Boiling Point |76 Â°C (168.8 Â°F) Flash Point |25 Â°C (77 Â°F) [TCC] Auto-ignition Temperature |No data available. Decomposition Temperature |No data available. Flammability (solid, gas) |Flammable. Vapor Pressure |No data available. Relative Vapor Density at 20 Â°C |>1 (Air = 1) Relative Density |0.815 Specific Gravity | Solubility |Slight. Partition coefficient: | n-octanol/water | Viscosity |No data available. Lower Flammable Limit | Upper Flammable Limit | 9.2. Other Information No additional information available. SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity No dangerous reaction known under conditions of normal use. 10.2 Chemical Stability Stable under normal storage conditions. May form flammable/explosive vapour-air mixture. 10.3 Possibility of Hazardous Reactions No dangerous reaction known under conditions of normal use. 10.4 Conditions to Avoid Heat. Excessive water. Incompatible materials. 10.5 Incompatible Materials Strong oxidizing agents. 10.6 Hazardous Decomposition Products May include, and are not limited to: oxides of carbon, oxides of nitrogen. SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: Not classified Skin Corrosion/Irritation: Based on available data, the classification criteria are not met. Serious Eye Damage/Irritation: Causes serious eye irritation. Respiratory or Skin Sensitization: Based on available data, the classification criteria are not met Germ Cell Mutagenicity: Based on available data, the classification criteria are not met. Carcinogenicity: Suspected of causing cancer. Reproductive Toxicity: Based on available data, the classification criteria are not met. Specific Target Organ Toxicity (Single Exposure): May cause drowsiness or dizziness. Specific Target Organ Toxicity (Repeated Exposure): Based on available data, the classification criteria are not met. Aspiration Hazard: May be fatal if swallowed and enters airways. Symptoms/Injuries After Inhalation: May cause drowsiness, dizziness and central nervous system depression. May cause respiratory tract irritation. Symptoms/Injuries After Skin Contact: May cause skin irritation. Symptoms may include redness, drying, defatting and cracking of the skin. Symptoms/Injuries After Eye Contact: Causes serious eye irritation. Symptoms may include discomfort or pain, excess blinking and tear production, with marked redness and swelling of the conjunctiva. Symptoms/Injuries After Ingestion: May be fatal if swallowed and enters airways. This product may be aspirated into the lungs and cause chemical pneumonitis. May cause stomach distress, nausea or vomiting. Chronic Symptoms: SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity Ecology - general : May cause long-term adverse effects in the aquatic environment. 12.2. Persistence and Degradability Fuel Injector Cleaner Persistence and degradability Not established. 12.3. Bioaccumulative Potential Fuel Injector Cleaner Bioaccumulative potential Not established. 12.4. Mobility in Soil No additional information available.. 12.5. Other Adverse Effects Effect on ozone layer: No additional information available. Effect on the global warming: No known ecological damage caused by this product. SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: This material must be disposed of in accordance with all local, state, provincial, and federal regulations. The generation of waste should be avoided or minimized wherever possible. Additional Information: Handle empty containers with care because residual vapours are flammable. SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name |Flammable liquids, n.o.s. (Petroleum distillates, |Isopropanol) Hazard Class |3 |<PICTOGRAM PHRASE>[pic] Identification Number|UN1993 | Label Codes | | ERG Number | 14.2 In Accordance with IMDG Proper Shipping Name | Hazard Class | Identification Number| Label Codes | |<PICTOGRAM PHRASE> ntification Of The | | Substance/m | | EmS-No. (Fire) | | EmS-No. (Spillage) | | 14.3 In Accordance with IATA Proper Shipping Name | Identification Number| |<PICTOGRAM PHRASE> Hazard Class | | Label Codes | | ntification Of The | | Substance/m | | ERG Code (IATA) | SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations <COMPONENT> Isopropyl alcohol (67-63-0) Listed on the United States TSCA (Toxic Substances Control Act) inventory Listed on United States SARA Section 313 EPA TSCA Regulatory Flag T - T - indicates a substance that is the subject of a Section 4 test rule under TSCA. SARA Section 313 - Emission Reporting 1.0 % (only if manufactured by the strong acid process, no supplier notification) Cumene (98-82-8) Listed on the United States TSCA (Toxic Substances Control Act) inventory Listed on United States SARA Section 313 EPA TSCA Regulatory Flag T - T - indicates a substance that is the subject of a Section 4 test rule under TSCA. SARA Section 313 - Emission Reporting 1.0 % SARA Section 311/312 Hazard Classes | Toxic Substances Control Act (TSCA) | 15.2 US State Regulations <COMPONENT> Fuel Injector Cleaner State or local regulations This product contains a chemical known to the State of California to cause cancer. SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date |09/17/2014 Other |This document has been prepared in accordance with the SDS Information |requirements of the OSHA Hazard Communication Standard 29 CFR |1910.1200. GHS Full Text Phrases: ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | Grainger disclaimer.
The information contained in this SDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this 'SDS' shall be created or inferred by any statement in this 'SDS'. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this 'SDS'. The user is responsible for full compliance.