Product Categories See All
Track Order Status
SDS Sheet 0047140Printer Friendly View
SECTION 1: IDENTIFICATION 1.1. Product Identifier Product Form: Product Name: Fluid FilmÂ® Non-Aerosol (NAS) CAS No: Synonyms: 1.2. Intended Use of the Product Use of the substance/mixture: Corrosion inhibitor, lubricant 1.3. Name, Address, and Telephone of the Responsible Party Company Eureka Chemical Company 234 Lawrence Ave South San Francisco, CA 94080 US Phone: 650-761-3536 1.4. Emergency Telephone Number Emergency | Chemtrec (800) 424-9300 number | SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) Ex. Compressed|H280 gas | | | 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) |None Signal Word (GHS-US) |None Hazard Statements (GHS-US) |None Precautionary Statements |Prevention: (GHS-US) |Obtain special instructions before use |Do not handle until all safety precautions have been |read and understood |Use personal protective equipment as required | |Response: |IF exposed or concerned: Get medical |advice/attention | |Storage: |No special requirements. Keep in closed containers |at 0-49Â°C. | |Disposal: |Product should be disposed of via authorized waste |disposal contractors in accordance with all local |and national regulations. 2.3. Other Hazards Other Hazards Not Contributing to the Classification: Not applicable. 2.4. Unknown Acute Toxicity (GHS-US) No information available. SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name |Product identifier |% |Classification | | |(GHS-US) Refined petroleum oil, |64742-54-7 |50-90 | hydrotreated heavy paraffinic | | | Calcium petroleum sulfonate |61789-86-4 |1-10 | | | | | | | | | | SECTION 4: FIRST AID MEASURES 4.1. Description of First Aid Measures First-aid Measures General: Immediate medical attention is required. First-aid Measures After Inhalation: Remove to fresh air. If symptoms persist, call a physician. First-aid Measures After Skin Contact: Wash skin with soap and water. In the case of skin irritation or allergic reactions see a physician. First-aid Measures After Eye Contact: Rinse thoroughly with plenty of water, also under the eyelids. If symptoms persist, call a physician. First-aid Measures After Ingestion: Do NOT induce vomiting. Drink plenty of water. If symptoms persist, call a physician. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: No information available. Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed Notes to Physician: Treat symptomatically. SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: CO2, Dry Chemical, Foam Unsuitable Extinguishing Media: CAUTION: Use of water spray when fighting fire may be inefficient. 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: Explosion Hazard: Sensitivity to Mechanical Impact No. Sensitivity to Static Discharge No. Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Firefighting Instructions: Protection During Firefighting: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: Avoid contact with eyes. Refer to protective measures listed in Sections 7 and 8. 6.1.1. For Non-emergency Personnel Protective Equipment: Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: Emergency Procedures: 6.2. Environmental Precautions Refer to protective measures listed in Sections 7 and 8. 6.3. Methods and Material for Containment and Cleaning Up For Containment: Prevent further leakage or spillage if safe to do so. Methods for Cleaning Up: Soak up with inert absorbent material. Pick up and transfer to properly labeled containers. 6.4. Reference to Other Sections See heading 8, Exposure Controls and Personal Protection. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: Handle in accordance with good industrial hygiene and safety practice. Avoid contact with skin, eyes or clothing. Do not eat, drink or smoke when using this product. Take off contaminated clothing and wash before reuse. Hygiene Measures: Handle in accordance with good industrial hygiene and safety practice. Do not eat, drink or smoke when using this product. Wash hands before breaks and immediately after handling the product. 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: None known based on information supplied. Storage Conditions: Keep container tightly closed. 7.3. Specific End Use(s) SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters Exposure Guidelines Chemical Name ACGIH TLV OSHA PEL NIOSH IDLH Refined petroleum oil, hydrotreated heavy paraffinic 64742-54-7 TWA: 5 mg/m3, as oil mist, mineral STEL: TWA: 10 mg/m3, as oil mist, mineral STEL: TWA: 10 mg/m3, as oil mist, mineral ACGIH TLV: American Conference of Governmental Industrial Hygienists - Threshold Limit Value OSHA PEL: Occupational Safety and Health Administration - Permissible Exposure Limits NIOSH IDLH Immediately Dangerous to Life or Health Other Exposure Guidelines: Vacated limits revoked by the Court of Appeals decision in AFL-CIO v. OSHA, 965 F.2d 962 (11th Cir., 1992) 8.2. Exposure Controls Appropriate Engineering |Showers Controls |Eyewash stations |Ventilation systems Personal Protective Equipment| Materials for Protective | Clothing | Hand Protection | Eye Protection |No special protective equipment required. Use |chemical eye goggles in tanks and confined spaces. Skin and Body Protection |Wear protective gloves and protective clothing. Respiratory Protection |No protective equipment is needed under normal use |conditions. Use approved respirator with organic |vapor cartridges in tanks and confined spaces. If |exposure limits are exceeded or irritation is |experienced, ventilation and evacuation may be |required. Thermal Hazard Protection | SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State |Liquid Appearance |Amber Odor |Mild piney odor Odor Threshold |No information available pH |7.8 Relative Evaporation Rate |No data available (butylacetate=1) | Melting Point |No data available Freezing Point |No data available Boiling Point |No data available Flash Point |207 C / 405 F Auto-ignition Temperature |No data available Decomposition Temperature |No data available Flammability (solid, gas) |No data available Vapor Pressure |No data available Relative Vapor Density at 20 Â°C |No data available Relative Density | Specific Gravity |0.880 Solubility |Insoluble in water Partition coefficient: |No data available n-octanol/water | Viscosity | Lower Flammable Limit |No data available Upper Flammable Limit |No data available 9.2. Other Information Softening Point No data available VOC Content (%) < 1% (CARB 310) Particle Size No data available Particle Size Distribution SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity No data available. 10.2 Chemical Stability Stable under recommended storage conditions. 10.3 Possibility of Hazardous Reactions None under normal processing. 10.4 Conditions to Avoid None known based on information supplied 10.5 Incompatible Materials None known based on information supplied. 10.6 Hazardous Decomposition Products Carbon oxides. SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: Skin Corrosion/Irritation: Serious Eye Damage/Irritation: Respiratory or Skin Sensitization: No information available. Germ Cell Mutagenicity: No information available. Carcinogenicity: Contains no known carcinogens. Reproductive Toxicity: No information available. Specific Target Organ Toxicity (Single Exposure): No information available. Specific Target Organ Toxicity (Repeated Exposure): No information available. Aspiration Hazard: No information available. Symptoms/Injuries After Inhalation: Specific test data for the substance or mixture is not available. Symptoms/Injuries After Skin Contact: Non-irritating. Symptoms/Injuries After Eye Contact: Non-irritating. Symptoms/Injuries After Ingestion: > 5000 mg/kg (Rat) Chronic Symptoms: No information available. SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity No information available. 12.2. Persistence and Degradability No information available. 12.3. Bioaccumulative Potential No information available 12.4. Mobility in Soil 12.5. Other Adverse Effects No information available. SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: Product should be disposed of via authorized waste disposal contractors in accordance with all local and national regulations. Consult the appropriate state, regional, or local regulations for additional requirements. Additional Information: Contaminated Packaging: Dispose of contents/containers in accordance with local regulations. California Hazardous Waste Codes: Not applicable. SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name |NOT REGULATED Hazard Class |N/A |<PICTOGRAM PHRASE> Identification Number| | Label Codes | | ERG Number | 14.2 In Accordance with IMDG Proper Shipping Name |Not regulated Hazard Class |N/A Identification Number| Label Codes | |<PICTOGRAM PHRASE> ntification Of The | | Substance/m | | EmS-No. (Fire) | | EmS-No. (Spillage) | | 14.3 In Accordance with IATA Proper Shipping Name |NON REGULATED Identification Number|N/A |<PICTOGRAM PHRASE> Hazard Class | | Label Codes | | ntification Of The | | Substance/m | | ERG Code (IATA) | SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations SARA 313 Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product does not contain any chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372. SARA Section 311/312 Hazard Classes |Acute Health Hazard |No |Chronic Health Hazard |No |Fire Hazard |No |Sudden release of pressure hazard No |Reactive Hazard |No Toxic Substances Control Act (TSCA) |Complies 15.2 US State Regulations <COMPONENT> California Proposition 65 This product does not contain any Proposition 65 chemicals. U.S. State Right-to-Know Regulations Chemical Name New Jersey Massachusetts Pennsylvania Rhode Island Illinois Sodium nitrite 7632-00-0 X X X X SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date |01/20/2015 Other |This document has been prepared in accordance with the SDS Information |requirements of the OSHA Hazard Communication Standard 29 CFR |1910.1200. GHS Full Text Phrases: ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | Grainger disclaimer.
The information contained in this SDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this 'SDS' shall be created or inferred by any statement in this 'SDS'. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this 'SDS'. The user is responsible for full compliance.