Product Categories See All
Track Order Status
SDS Sheet 0046490Printer Friendly View
Safety Data Sheet Date of Issue: 19-May-2015 |Revision Date: 06-Jun-2015|Revision Number: 1.01 Imperial Supplies Part Number: 0046490 SECTION 1: IDENTIFICATION 1.1. Product Identifier Product Form: Product Name: 4649 NC BRAKE CLEANER CAS No: Synonyms: 1.2. Intended Use of the Product Use of the substance/mixture: Brake Cleaner. 1.3. Name, Address, and Telephone of the Responsible Party Company Imperial Supplies LLC 789 Armed Forces Drive P.O. Box 11008 Green Bay, WI 53407-1008 Phone 1.4. Emergency Telephone Number Emergency | Chemtrec 1-800-424-9300 number | SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) Skin |Category 2 corrosion/irri| tation | Serious eye |Category 2A damage/eye | irritation | Carcinogenicit|Category 2 y | Specific |Category 3 target organ | toxicity | (single | exposure) | Aspiration |Category 1 toxicity | Flammable |Category 1 Liquids | 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) |Exclamat|Health |Flame | | | |ion Mark|Hazard | | | | Signal Word (GHS-US) |DANGER Hazard Statements (GHS-US) |Causes skin irritation |Causes serious eye irritation |Suspected of causing cancer |May cause drowsiness or dizziness |May be fatal if swallowed and enters airways |Extremely flammable liquid and vapor Precautionary Statements |Prevention: (GHS-US) |Obtain special instructions before use |Do not handle until all safety precautions have been |read and understood |Wear protective gloves/protective clothing/eye |protection/face protection |Wash face, hands and any exposed skin thoroughly |after handling |Avoid breathing dust/fume/gas/mist/vapors/spray |Use only outdoors or in a well-ventilated area |Keep away from heat/sparks/open flames/hot surfaces. |- No smoking |Keep container tightly closed |Ground/Bond container and receiving equipment |Use explosion-proof electrial/ventilating/lighting |/equipment. |Use only non-sparking tools |Take precautionary measures against static discharge | |Response: |If exposed or concerned: Get medical |advice/attention |Specific treatment (see first aid on this label) |IF IN EYES: Rinse cautiously with water for several |minutes. Remove contact lenses, if present and easy |to do. Continue rinsing. |If eye irritation persists: Get medical |advice/attention |IF ON SKIN (or hair): Remove/Take off immediately |all contaminated clothing. Rinse skin with |water/shower |Wash contaminated clothing before reuse |If skin irritation occurs: Get medical |advice/attention |IF INHALED: Remove person to fresh air and keep |comfortable for breathing. |Call a POISON CENTER or doctor/physician if you feel |unwell |IF SWALLOWED: Immediately call a POISON CENTER or |doctor/physician |Do NOT induce vomiting |In case of fire: Use CO2, dry chemical, or foam for |extinction |Storage: |Store locked up |Store in a well-ventilated place. Keep container |tightly closed |Keep cool. |Disposal: |Dispose of contents/container to an approved waste |disposal plant 2.3. Other Hazards Other Hazards Not Contributing to the Classification: None 2.4. Unknown Acute Toxicity (GHS-US) Toxic to aquatic life with long lasting effects 0% of the mixture consists of ingredient(s) of unknown toxicity SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name |Product identifier |% |Classification | | |(GHS-US) ACETONE |67-64-1 |70-80 | METHYL ACETATE |79-20-9 |1-10 | XYLENE |1330-20-7 |1-10 | ETHYL BENZENE |100-41-4 |1-10 | HYDROTREATED LIGHT DISTILLATES |64742-47-8 |1-10 | SECTION 4: FIRST AID MEASURES 4.1. Description of First Aid Measures First-aid Measures General: First-aid Measures After Inhalation: Move to fresh air. If breathing is difficult, give oxygen. Artificial respiration and/or oxygen may be necessary. If breathing has stopped, contact emergency medical services immediately. First-aid Measures After Skin Contact: Wash off immediately with soap and plenty of water while removing all contaminated clothes and shoes. If skin irritation persists, call a physician. First-aid Measures After Eye Contact: Rinse immediately with plenty of water, also under the eyelids, for at least 15 minutes. Keep eye wide open while rinsing. If symptoms persist, call a physician. First-aid Measures After Ingestion: Rinse mouth. Do NOT induce vomiting. Never give anything by mouth to an unconscious person. Call a physician or Poison Control Center immediately. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: Causes skin irritation. Symptoms/Injuries After Eye Contact: Causes eye irritation. Symptoms/Injuries After Ingestion: May be harmful if swallowed. Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed Notes to physician: Treat symptomatically. SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: Water fog.Dry chemical. Carbon dioxide (CO2). Cool containers/tanks with water spray. Unsuitable Extinguishing Media: Keep away from heat and sources of ignition. Do not smoke. Cool containers / tanks with water spray. 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: Extremely flammable. Keep product and empty container away from heat and sources of ignition. Risk of ignition. In the event of fire and/or explosion do not breathe fumes. In the event of fire, cool tanks with water spray. Explosion Hazard: Sensitivity to Mechanical Impact: none. Sensitivity to Static Discharge: none. Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Firefighting Instructions: Protection During Firefighting: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: Evacuate personnel to safe areas. Absorb with sand ,clay, or other suitable material. Hard surfaces may be mopped with water. Avoid contact with skin, eyes and clothing. Ensure adequate ventilation. Avoid dust formation. Remove all sources of ignition. Keep people away from and upwind of spill/leak. Take precautionary measures against static discharges. 6.1.1. For Non-emergency Personnel Protective Equipment: Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: Emergency Procedures: 6.2. Environmental Precautions Prevent further leakage or spillage if safe to do so. Do not allow material to contaminate ground water system. Prevent product from entering drains. Do not flush into surface water or sanitary sewer system. Should not be released into the environment. 6.3. Methods and Material for Containment and Cleaning Up For Containment: Prevent further leakage or spillage if safe to do so. Absorb spill with inert material (e.g. Dry sand or earth), then place in a chemical waste container. Methods for Cleaning Up: Pick up and transfer to properly labeled containers. Soak up with inert absorbent material. Clean contaminated surface thoroughly. After cleaning, flush away traces with water. Take precautionary measures against static discharges. 6.4. Reference to Other Sections See heading 8, Exposure Controls and Personal Protection. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: Avoid contact with skin, eyes and clothing. Handle in accordance with good industrial hygiene and safety practice. Remove and wash contaminated clothing before re-use. Keep away from open flames, hot surfaces and sources of ignition. Take precautionary measures against static discharges. Hygiene Measures: Handle in accordance with good industrial hygiene and safety practice. 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Storage Conditions: Keep container tightly closed in a dry and well-ventilated place. Keep away from open flames, hot surfaces and sources of ignition. Keep in properly labeled containers. Keep out of the reach of children. Store locked up. Incompatible products: Strong acids, alkalis, or oxidizing agents. 7.3. Specific End Use(s) SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters Exposure Guidelines Chemical Name ACGIH TLV OSHA PEL NIOSH IDLH ACETONE 67-64-1 STEL: 750 ppm TWA: 500 ppm TWA: 1000 ppm TWA: 2400 mg/m3 (vacated) TWA: 750 ppm (vacated) TWA: 1800 mg/m3 (vacated) STEL: 2400 mg/m3 The acetone STEL does not apply to the cellulose acetate fiber industry. It is in effect for all other sectors (vacated) STEL: 1000 ppm IDLH: 2500 ppm TWA: 250 ppm TWA: 590 mg/m3 METHYL ACETATE 79-20-9 STEL: 250 ppm TWA: 200 ppm TWA: 200 ppm TWA: 610 mg/m3 (vacated) TWA: 200 ppm (vacated) TWA: 610 mg/m3 (vacated) STEL: 250 ppm (vacated) STEL: 760 mg/m3 IDLH: 3100 ppm TWA: 200 ppm TWA: 610 mg/m3 STEL: 250 ppm STEL: 760 mg/m3 XYLENE 1330-20-7 STEL: 150 ppm TWA: 100 ppm TWA: 100 ppm TWA: 435 mg/m3 (vacated) TWA: 100 ppm (vacated) TWA: 435 mg/m3 (vacated) STEL: 150 ppm (vacated) STEL: 655 mg/m3 - ETHYL BENZENE 100-41-4 TWA: 20 ppm TWA: 100 ppm TWA: 435 mg/m3 (vacated) TWA: 100 ppm (vacated) TWA: 435 mg/m3 (vacated) STEL: 125 ppm (vacated) STEL: 545 mg/m3 IDLH: 800 ppm TWA: 100 ppm TWA: 435 mg/m3 STEL: 125 ppm STEL: 545 mg/m3 HYDROTREATED LIGHT DISTILLATES 64742-47-8 TWA: 200 PPM 8 hours - - 8.2. Exposure Controls Appropriate Engineering |Showers Controls |Eyewash stations |Ventilation systems. Personal Protective Equipment| Materials for Protective | Clothing | Hand Protection | Eye Protection |Safety glasses with side-shields. Skin and Body Protection |Chemical resistant apron. Protective gloves. Respiratory Protection |If exposure limits are exceeded or irritation is |experienced, NIOSH/MSHA approved respiratory |protection should be worn. Positive-pressure |supplied air respirators may be required for high |airborne contaminant concentrations. Respiratory |protection must be provided in accordance with |current local regulations. Thermal Hazard Protection | SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State |Liquid Appearance |Clear Odor |Solvent Odor Threshold |No information available pH |No information available Relative Evaporation Rate |No information available (butylacetate=1) | Melting Point |No information available Freezing Point |No information available Boiling Point |No information available Flash Point |-20 Â°C / -4 Â°F Auto-ignition Temperature |No information available Decomposition Temperature |No information available Flammability (solid, gas) |No information available Vapor Pressure |No information available Relative Vapor Density at 20 Â°C |No information available Relative Density | Specific Gravity |.796 Solubility |Practically insoluble Partition coefficient: |No information available n-octanol/water | Viscosity |No information available Lower Flammable Limit |No information available Upper Flammable Limit |No information available 9.2. Other Information VOC Content(%) : 9.8 SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity No data available 10.2 Chemical Stability Stable under recommended storage conditions. 10.3 Possibility of Hazardous Reactions None under normal processing. 10.4 Conditions to Avoid Extremes of temperature and direct sunlight. 10.5 Incompatible Materials Strong acids, alkalis, or oxidizing agents. 10.6 Hazardous Decomposition Products None known based on information supplied. SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: Skin Corrosion/Irritation: Irritating to skin. Repeated exposure may cause skin dryness or cracking. Prolonged skin contact may defat the skin and produce dermatitis. Avoid contact with skin. Serious Eye Damage/Irritation: Irritating to eyes. Avoid contact with eyes. Respiratory or Skin Sensitization: Vapors may irritate throat and respiratory system. May cause drownsiness and dizziness based on components. May cause irritation of respiratory tract. Avoid breathing vapors or mists. Germ Cell Mutagenicity: None known. Carcinogenicity: The table below indicates whether each agency has evaluated a listed ingredient as a carcinogen. Chemical Name ACGIH IARC NTP OSHA XYLENE 1330-20-7 - Group 3 - - ETHYL BENZENE 100-41-4 A3 Group 2B - - Reproductive Toxicity: Product is or contains a chemical which is a known or suspected reproductive hazard. Specific Target Organ Toxicity (Single Exposure): May cause respiratory irritation. May cause drowsiness and dizziness. Specific Target Organ Toxicity (Repeated Exposure): None under normal use conditions. Aspiration Hazard: May be fatal if swallowed and enters airways. Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: Irritating to skin. Symptoms/Injuries After Eye Contact: Irritating to eyes. Symptoms/Injuries After Ingestion: Chronic Symptoms: SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity Chemical Name Toxicity to algae Toxicity to fish Toxicity to microorganisms Toxicity to daphnia and other aquatic invertebrates ACETONE 67-64-1 4.74 - 6.33 mL/L LC50 Oncorhynchus mykiss 96h 6210 - 8120 mg/L LC50 Pimephales promelas 96h static 8300 mg/L LC50 Lepomis macrochirus 96h 10294 - 17704 mg/L EC50 Daphnia magna 48h Static 12600 - 12700 mg/L EC50 Daphnia magna 48h METHYL ACETATE 79-20-9 120 mg/L EC50 Desmodesmus subspicatus 72h 250 - 350 mg/L LC50 Brachydanio rerio 96h static 295 - 348 mg/L LC50 Pimephales promelas 96h flow-through 1026.7 mg/L EC50 Daphnia magna 48h XYLENE 1330-20-7 13.1 - 16.5 mg/L LC50 Lepomis macrochirus 96h flow-through 13.5 - 17.3 mg/L LC50 Oncorhynchus mykiss 96h 2.661 - 4.093 mg/L LC50 Oncorhynchus mykiss 96h static 23.53 - 29.97 mg/L LC50 Pimephales promelas 96h static 30.26 - 40.75 mg/L LC50 Poecilia reticulata 96h static 7.711 - 9.591 mg/L LC50 Lepomis macrochirus 96h static 13.4 mg/L LC50 Pimephales promelas 96h flow-through 19 mg/L LC50 Lepomis macrochirus 96h 780 mg/L LC50 Cyprinus carpio 96h semi-static 780 mg/L LC50 Cyprinus carpio 96h 0.6 mg/L LC50 Gammarus lacustris 48h 3.82 mg/L EC50 water flea 48h ETHYL BENZENE 100-41-4 4.6 mg/L EC50 Pseudokirchneriella subcapitata 72h 438 mg/L EC50 Pseudokirchneriella subcapitata 96h 2.6 - 11.3 mg/L EC50 Pseudokirchneriella subcapitata 72h static 1.7 - 7.6 mg/L EC50 Pseudokirchneriella subcapitata 96h static 11.0 - 18.0 mg/L LC50 Oncorhynchus mykiss 96h static 7.55 - 11 mg/L LC50 Pimephales promelas 96h flow-through 9.1 - 15.6 mg/L LC50 Pimephales promelas 96h static 32 mg/L LC50 Lepomis macrochirus 96h static 4.2 mg/L LC50 Oncorhynchus mykiss 96h semi-static 9.6 mg/L LC50 Poecilia reticulata 96h static 1.8 - 2.4 mg/L EC50 Daphnia magna 48h HYDROTREATED LIGHT DISTILLATES 64742-47-8 2.2 mg/L LC50 Lepomis macrochirus 96h static 2.4mg/L LC50 Oncorhynchus mykiss 96h static 45 mg/L LC50 Pimephales promelas 96h flow-through 12.2. Persistence and Degradability No information available. 12.3. Bioaccumulative Potential No information available. Chemical Name log Pow ACETONE 67-64-1 -0.24 METHYL ACETATE 79-20-9 0.18 XYLENE 1330-20-7 3.15 ETHYL BENZENE 100-41-4 3.118 12.4. Mobility in Soil 12.5. Other Adverse Effects No information available. SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: This material, as supplied, is a hazardous waste according to federal regulations (40 CFR 261). Additional Information: Do not re-use empty containers. SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name | CONSUMER COMMODITY ORM-D or LIMITED QUANTITY Hazard Class | |<PICTOGRAM PHRASE> Identification Number| | Label Codes | | ERG Number | 14.2 In Accordance with IMDG Proper Shipping Name |FLAMMABLE LIQUIDS, N.O.S. (ACETONE, XYLENE) Hazard Class |3 Identification Number|UN1993 Label Codes | |<PICTOGRAM PHRASE> ntification Of The | | Substance/m | | EmS-No. (Fire) | | EmS-No. (Spillage) | | 14.3 In Accordance with IATA Proper Shipping Name |FLAMMABLE LIQUIDS, N.O.S. (ACETONE, XYLENE) Identification Number|UN1993 |<PICTOGRAM PHRASE> Hazard Class |3 | Label Codes | | ntification Of The | | Substance/m | | ERG Code (IATA) | SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations <COMPONENT> SARA 313: Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product contains a chemical or chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372: Chemical Name CAS-No Weight %* SARA 313 - Threshold Values % XYLENE - 1330-20-7 1330-20-7 1-10 1.0 ETHYL BENZENE - 100-41-4 100-41-4 1-10 0.1 Clean Water Act: This product contains the following substances which are regulated pollutants pursuant to the Clean Water Act (40 CFR 122.21 and 40 CFR 122.42): Chemical Name CWA - Reportable Quantities CWA - Toxic Pollutants Extremely Hazardous Substances RQs RQ XYLENE 1330-20-7 100 lb X ETHYL BENZENE 100-41-4 1000 lb X X X CERCLA: This material, as supplied, contains one or more substances regulated as a hazardous substance under the Comprehensive Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302): Chemical Name Hazardous Substances RQs Extremely Hazardous Substances RQs RQ ACETONE 67-64-1 5000 lb RQ 5000 lb final RQ RQ 2270 kg final RQ XYLENE 1330-20-7 100 lb RQ 100 lb final RQ RQ 45.4 kg final RQ ETHYL BENZENE 100-41-4 1000 lb RQ 1000 lb final RQ RQ 454 kg final RQ SARA Section 311/312 Hazard Classes |Acute Health Hazard: Yes |Chronic Health Hazard: Yes |Fire Hazard: Yes |Sudden Release of Pressure Hazard: no |Reactive Hazard: no Toxic Substances Control Act (TSCA) |Chemical Name |TSCA | |ACETONE |X | |METHYL ACETATE |X | |XYLENE |X | |ETHYL BENZENE |X | |HYDROTREATED |LIGHT DISTILLATES |X | 15.2 US State Regulations <COMPONENT> California Proposition 65: This product contains the following Proposition 65 chemicals: Chemical Name California Prop. 65 ETHYL BENZENE - 100-41-4 Carcinogen U.S. State Right-to-Know Regulations Chemical Name New Jersey Massachusetts Pennsylvania ACETONE 67-64-1 X X X METHYL ACETATE 79-20-9 X X X XYLENE 1330-20-7 X X X ETHYL BENZENE 100-41-4 X X X SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date |06-Jun-2015 Other |This document has been prepared in accordance with the SDS Information |requirements of the OSHA Hazard Communication Standard 29 CFR |1910.1200. GHS Full Text Phrases: ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | Grainger disclaimer.
The information contained in this SDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this 'SDS' shall be created or inferred by any statement in this 'SDS'. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this 'SDS'. The user is responsible for full compliance.