Product Categories See All
Track Order Status
SDS Sheet 0046010Printer Friendly View
SECTION 1: IDENTIFICATION 1.1. Product Identifier Product Form: Product Name: 4601-0 GALLON 4-WAY LUBE CAS No: Synonyms: None 1.2. Intended Use of the Product Use of the substance/mixture: Penetrating lubricant. 1.3. Name, Address, and Telephone of the Responsible Party Company Imperial Supplies LLC 789 Armed Forces Drive P.O. Box 11008 Green Bay, WI 53407-1038 Phone 1.4. Emergency Telephone Number Emergency | Chemtrec 1-800-262-8200 ID 1195 number | SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) Skin |Category 2 corrosion/irri| tation | Serious eye |Category 2B damage/eye | irritation | Specific |Category 3 target organ | toxicity | (single | exposure) | Aspiration |Category 1 toxicity | Flammable |Category 3 Liquids | 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) |Exclamation Mark |Health Hazard |Flame Signal Word (GHS-US) |DANGER Hazard Statements (GHS-US) |Causes skin irritation |Causes eye irritation |May cause respiratory irritation. May cause |drowsiness or dizziness |May be fatal if swallowed and enters airways |Flammable liquid and vapor Precautionary Statements |Prevention (GHS-US) |Wash face, hands and any exposed skin thoroughly |after handling |Wear protective gloves/protective clothing/eye |protection/face protection |Avoid breathing dust/fume/gas/mist/vapors/spray |Use only outdoors or in a well-ventilated area |Keep away from heat/sparks/open flames/hot surfaces. |- No smoking |Keep container tightly closed |Ground/Bond container and receiving equipment |Use explosion-proof electrial/ventilating/lighting |/equipment. |Use only non-sparking tools |Take precautionary measures against static discharge | |Response |Specific treatment (see first aid on this label) |IF IN EYES: Rinse cautiously with water for several |minutes. Remove contact lenses, if present and easy |to do. Continue rinsing. |If eye irritation persists: Get medical |advice/attention |IF ON SKIN (or hair): Remove/Take off immediately |all contaminated clothing. Rinse skin with |water/shower |Wash contaminated clothing before reuse |If skin irritation occurs: Get medical |advice/attention |IF INHALED: Remove person to fresh air and keep |comfortable for breathing. |Call a POISON CENTER or doctor/physician if you feel |unwell |IF SWALLOWED: Immediately call a POISON CENTER or |doctor/physician |Do NOT induce vomiting |In case of fire: Use CO2, dry chemical, or foam for |extinction |Storage |Store locked up |Store in a well-ventilated place. Keep container |tightly closed |Keep cool. |Disposal |Dispose of contents/container to an approved waste |disposal plant 2.3. Other Hazards Other Hazards Not Contributing to the Classification: Toxic to aquatic life with long lasting effects 0.001% of the mixture consists of ingredient(s) of unknown toxicity. 2.4. Unknown Acute Toxicity (GHS-US) SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name |Product identifier |% |Classification | | |(GHS-US) HYDROTREATED LIGHT DISTALLATES |64742-47-8 |30-40 | NAPHTHENIC OIL, SEVERLY HYDROT |64742-52-5 |10-20 | KEROSENE |8008-20-6 |10-20 | PETROLEUM DISTILLATES |64742-47-8 |10-20 | MINERAL OIL, DEWAXED |64742-65-0 |1-10 | SECTION 4: FIRST AID MEASURES 4.1. Description of First Aid Measures First-aid Measures General: If symptoms persist, call a physician. First-aid Measures After Inhalation: Immediate medical attention is not required. If symptoms persist, call a physician. Move to fresh air in case of accidental inhalation of vapors or decomposition products. First-aid Measures After Skin Contact: Immediate medical attention is not required. Wash off immediately with soap and plenty of water while removing all contaminated clothes and shoes. If skin irritation persists, call a physician. First-aid Measures After Eye Contact: Immediately flush with plenty of water. After initial flushing, remove any contact lenses and continue flushing for at least 15 minutes. Keep eye wide open while rinsing. If symptoms persist, call a physician. First-aid Measures After Ingestion: Clean mouth with water and drink afterwards plenty of water. Never give anything by mouth to an unconscious person. Consult a physician. Do NOT induce vomiting. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: Symptoms/Injuries After Inhalation: Inhalation causing Central Nervous System effects. Symptoms/Injuries After Skin Contact: Causes skin irritation. Symptoms/Injuries After Eye Contact: Causes eye irritation. Symptoms/Injuries After Ingestion: Ingestion causing lung damage. Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed Protection of First-aiders: Absorb with sand ,clay, or other suitable material. Hard surfaces may be mopped with water. Notes to physician: Treat symptomatically. SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: Use:. Dry chemical. Carbon dioxide (CO 2). Water spray. Alcohol-resistant foam. Unsuitable Extinguishing Media: Decomposition by contact with water may generate vapors which can be ignited by heat or open flame. 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: Keep product and empty container away from heat and sources of ignition. Risk of ignition. Explosion Hazard: Sensitivity to Mechanical Impact: none. Sensitivity to Static Discharge: Yes. Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Firefighting Instructions: Protection During Firefighting: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: Evacuate personnel to safe areas. Keep people away from and upwind of spill/leak. Remove all sources of ignition. Pay attention to flashback. Take precautionary measures against static discharges. Absorb with sand ,clay, or other suitable material. Hard surfaces may be mopped with water. 6.1.1. For Non-emergency Personnel Protective Equipment: Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: Emergency Procedures: 6.2. Environmental Precautions Prevent further leakage or spillage if safe to do so. Prevent product from entering drains. Beware of vapors accumulating to form explosive concentrations. Vapors can accumulate in low areas. 6.3. Methods and Material for Containment and Cleaning Up For Containment: Prevent further leakage or spillage if safe to do so. Methods for Cleaning Up: Dam up. Soak up with inert absorbent material. Pick up and transfer to properly labeled containers. Take precautionary measures against static discharges. 6.4. Reference to Other Sections See heading 8, Exposure Controls and Personal Protection. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: Use only in area provided with appropriate exhaust ventilation. To avoid ignition of vapors by static electricity discharge, all metal parts of the equipment must be grounded. Keep away from heat, sparks and open flame. No smoking. Wear personal protective equipment. Do not breathe vapors or spray mist. Take necessary action to avoid static electricity discharge (which might cause ignition of organic vapors). Hygiene Measures: When using, do not eat, drink or smoke. Provide regular cleaning of equipment, work area and clothing. 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Storage Conditions: Keep containers tightly closed in a cool, well-ventilated place. Keep away from heat. Keep in properly labeled containers. Incompatible products: None known based on information supplied. 7.3. Specific End Use(s) SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters Exposure Guidelines Chemical Name ACGIH TLV OSHA PEL NIOSH IDLH HYDROTREATED LIGHT DISTALLATES 64742-47-8 TWA: 200 PPM 8 hours - - KEROSENE 8008-20-6 TWA: 200 mg/m3 total hydrocarbon vapor application restricted to conditions in which there are negligible aerosol Exposures Skin - potential significant contribution to overall exposure by the cutaneous route - TWA: 100 mg/m3 MINERAL OIL, DEWAXED 64742-65-0 ACGIH TLV: 5 mg/m3 (oil mist) OSHA PEL: 5 mg/m3 (oil mist) - Other Exposure Guidelines: Vacated limits revoked by the Court of Appeals decision in AFL-CIO v. OSHA, 965 F.2d 962 (11th Cir., 1992). 8.2. Exposure Controls Appropriate Engineering |Showers, Eyewash stations, Ventilation systems. Controls | Personal Protective Equipment| Materials for Protective | Clothing | Hand Protection | Eye Protection |Tightly fitting safety goggles. Skin and Body Protection |Chemical resistant apron. Protective gloves. Respiratory Protection |If exposure limits are exceeded or irritation is |experienced, NIOSH/MSHA approved respiratory |protection should be worn. Positive-pressure |supplied air respirators may be required for high |airborne contaminant concentrations. Respiratory |protection must be provided in accordance with |current local regulations. Thermal Hazard Protection | SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State |Liquid Appearance |Opaque Odor |Solvent Odor Threshold |No information available pH |No information available Relative Evaporation Rate |No information available (butylacetate=1) | Melting Point |No information available Freezing Point |No information available Boiling Point |No information available Flash Point |41 Â°C / 106 Â°F (based on components) Auto-ignition Temperature |No information available Decomposition Temperature |No information available Flammability (solid, gas) |No information available Vapor Pressure |No information available Relative Vapor Density at 20 Â°C | Relative Density | Specific Gravity |0.84 Solubility |Practically insoluble Partition coefficient: |No information available n-octanol/water | Viscosity |No information available Lower Flammable Limit |No information available Upper Flammable Limit |No information available 9.2. Other Information VOC Content(%): 35.45 SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity No data available. 10.2 Chemical Stability Stable under recommended storage conditions. 10.3 Possibility of Hazardous Reactions None under normal processing. 10.4 Conditions to Avoid Heat, flames and sparks. 10.5 Incompatible Materials None known based on information supplied. 10.6 Hazardous Decomposition Products None known based on information supplied. SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: Skin Corrosion/Irritation: Irritating to skin. Repeated exposure may cause skin dryness or cracking. Prolonged skin contact may defat the skin and produce dermatitis. Avoid contact with skin. Serious Eye Damage/Irritation: Irritating to eyes. Avoid contact with eyes. Respiratory or Skin Sensitization: None known. Irritating to respiratory system. Germ Cell Mutagenicity: None known. Carcinogenicity: There are no known carcinogenic chemicals in this product. Reproductive Toxicity: Product is or contains a chemical which is a known or suspected reproductive hazard. Specific Target Organ Toxicity (Single Exposure): May cause respiratory irritation. May cause drowsiness and dizziness. Specific Target Organ Toxicity (Repeated Exposure): None under normal use conditions. Aspiration Hazard: May be fatal if swallowed and enters airways. Symptoms/Injuries After Inhalation: Vapors may irritate throat and respiratory system. May cause drownsiness and dizziness based on components. May cause irritation of respiratory tract. Avoid breathing vapors or mists. May be fatal if swallowed and enters airways. Symptoms/Injuries After Skin Contact: Skin corrosion/irritation: Irritating to skin. Symptoms of overexposure may be headache, dizziness, tiredness, nausea and vomiting. Irritating to skin. Symptoms/Injuries After Eye Contact: Eye damage/irritation: Irritating to eyes. Symptoms/Injuries After Ingestion: Aspiration into the lungs during swallowing may cause serious lung damage which may be fatal. Causes respiratory system irritation. Chronic Symptoms: SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity Chemical Name Toxicity to algae Toxicity to fish Toxicity to microorganisms Toxicity to daphnia and other aquatic invertebrates HYDROTREATED LIGHT DISTALLATES 64742-47-8 - 2.2 mg/L LC50 Lepomis macrochirus 96h static 2.4 mg/L LC50 Oncorhynchus mykiss 96h static 45 mg/L LC50 Pimephales promelas 96h flow-through - - NAPHTHENIC OIL, SEVERLY HYDROT 64742-52-5 - 5000 mg/L LC50 Oncorhynchus mykiss 96h - 1000 mg/L EC50 Daphnia magna 48h PETROLEUM DISTILLATES 64742-47-8 - 2.2 mg/L LC50 Lepomis macrochirus 96h static 2.4 mg/L LC50 Oncorhynchus mykiss 96h static 45 mg/L LC50 Pimephales promelas 96h flow-through - - MINERAL OIL, DEWAXED 64742-65-0 - 5000 mg/L LC50 Oncorhynchus mykiss 96h - 1000 mg/L EC50 Daphnia magna 48h 12.2. Persistence and Degradability No information available. 12.3. Bioaccumulative Potential No information available. 12.4. Mobility in Soil 12.5. Other Adverse Effects No information available. SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: This material, as supplied, is a hazardous waste according to federal regulations (40 CFR 261). Additional Information: Contaminated packaging: Do not re-use empty containers. SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name |CONSUMER COMMODITY ORM-D |or LIMITED QUANTITY Hazard Class | |<PICTOGRAM PHRASE> Identification Number| | Label Codes | | ERG Number | 14.2 In Accordance with IMDG Proper Shipping Name |KEROSENE SOLUTION Hazard Class |3 Identification Number|UN1223 Label Codes | |<PICTOGRAM PHRASE> ntification Of The | | Substance/m | | EmS-No. (Fire) | | EmS-No. (Spillage) | | 14.3 In Accordance with IATA Proper Shipping Name |KEROSENE SOLUTION Identification Number|UN1223 |<PICTOGRAM PHRASE> Hazard Class |3 | Label Codes | | ntification Of The | | Substance/m | | ERG Code (IATA) | SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations <COMPONENT> SARA 313: Section 313 of Title III of the Superfund Amendments and Re-authorization Act of 1986 (SARA). This product does not contain any chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372. Clean Water Act: This product contains the following substances which are regulated pollutants pursuant to the Clean Water Act (40 CFR 122.21 and 40 CFR 122.42): CERCLA: This material, as supplied, contains one or more substances regulated as a hazardous substance under the Comprehensive Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302) SARA Section 311/312 Hazard Classes |Acute Health Hazard |Yes |Chronic Health Hazard |Yes |Fire Hazard |Yes |Sudden Release of Pressure Hazard no |Reactive Hazard |no Toxic Substances Control Act (TSCA) |Chemical Name TSCA |HYDROTREATED X |LIGHT DISTALLATES | |NAPHTHENIC OIL, X |SEVERLY HYDROT | |KEROSENE X | |PETROLEUM X |DISTILLATES | |MINERAL OIL, X |DEWAXED 15.2 US State Regulations California Proposition 65: This product contains the following Proposition 65 chemicals: Chemical Name California Prop. 65 NAPHTHALENE - 91-20-3 X U.S. State Right-to-Know Regulations Chemical Name New Jersey Massachusetts Pennsylvania KEROSENE 8008-20-6 X X X EPA Pesticide Registration Number: Not applicable. SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date |21-May-2015 Other |This document has been prepared in accordance with the SDS Information |requirements of the OSHA Hazard Communication Standard 29 CFR |1910.1200. GHS Full Text Phrases: ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | Grainger disclaimer.
The information contained in this SDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this 'SDS' shall be created or inferred by any statement in this 'SDS'. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this 'SDS'. The user is responsible for full compliance.