Product Categories See All
Track Order Status
SDS Sheet 0075940Printer Friendly View
SECTION 1: IDENTIFICATION 1.1. Product Identifier Product Form: Product Name: DynatexÂ¨ 49429 Black Super Weatherstrip Adhesive CAS No: Synonyms: 49429BK04 1.2. Intended Use of the Product Use of the substance/mixture: Refer to Technical Data 1.3. Name, Address, and Telephone of the Responsible Party Company: Dynatex Inc. 350 Ring Road Elizabethtown, KY, 42701 USA Phone: (270) 769-3385 1.4. Emergency Telephone Number Emergency | (800) 424-9300 Chemtrec number | SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) ASPIRATION |Category 1 HAZARD | EYE |Category 2A DAMAGE/IRRITAT| ION | FLAMMABLE |Category 2 LIQUIDS | SPECIFIC |Category 2 TARGET ORGAN | TOXICITY | (Repeated | Exposure) | SPECIFIC |Category 3 TARGET ORGAN | TOXICITY | (Single | Exposure) | TOXIC TO |Category 2 REPRODUCTION | SKIN |Category 2 CORROSION/IRRI| TATION | 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) |Health Hazard |Flame |Exclamation Mark Signal Word (GHS-US) |Danger Hazard Statements (GHS-US) |Causes serious eye irritation |Causes skin irritation |Highly flammable liquid and vapor |May be fatal if swallowed and enters airways |May cause damage to organs through prolonged or |repeated exposure. |May cause drowsiness or dizziness |Suspected of damaging fertility or the unborn child. Precautionary Statements |Response: (GHS-US) |Call a poison center/doctor if you feel unwell. |Do NOT induce vomiting. |Get medical advice/attention if you feel unwell. |If exposed or concerned: Get medical |advice/attention. |If eye irritation persists: Get medical |advice/attention. |If in eyes: Rinse cautiously with water for several |minutes. Remove contact lenses, if present and easy |to do. Continue Rinsing. |If inhaled: Remove person to fresh air and keep |comfortable for Breathing. |If medical advice is needed, have product container |or label at Hand. |If on skin (or hair): Take off immediately all |contaminated clothing. Rinse skin with water/shower. | |If on skin: Wash with plenty of soap and water. |If skin irritation occurs: Get medical |advice/attention. |If swallowed: Immediately call a poison center or |doctor. |In case of fire: Use CO2, sand, extinguishing powder |to extinguish. Do not use water. |Take off contaminated clothing and wash it before |reuse. |Prevention: |Avoid breathing dust/fume/gas/mist/ vapors/spray. |Do not breathe dust/fume/gas/mist/ vapors/spray. |Do not handle until all safety precautions have been |read and Understood. Ground/bond container and |receiving equipment. |Keep away from heat. |Keep container tightly closed. |Obtain special instructions before use. |Take precautionary measures against static |discharge. |Use explosion-proof electrical/ventilating/lighting |equipment. |Use only non-sparking tools. Use only outdoors or in |a well-ventilated area. |Wash hands thoroughly after handling. |Wear eye protection/face protection. |Wear protective gloves. |Wear protective gloves/eye protection/face |protection Wear protective gloves/protective |clothing/eye protection/face protection. |Storage: |Store in a well-ventilated place. Keep container |tightly closed. Store in well-ventilated place. Keep |cool. Store locked up. |Disposal: |Dispose of contents/container in accordance with |local/regional/national/international regulations. 2.3. Other Hazards Other Hazards Not Contributing to the Classification: None known 2.4. Unknown Acute Toxicity (GHS-US) 0% SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name |Product identifier |% |Classification | | |(GHS-US) Toluene |108-88-3 |10% - | | |25% | Methyl Ethyl Ketone (MEK) |78-93-3 |5% - 20%| 2-Propanone |67-64-1 |5% - 20%| Hexane |110-54-3 |5% - 20%| | | | SECTION 4: FIRST AID MEASURES 4.1. Description of First Aid Measures First-aid Measures General: First-aid Measures After Inhalation: Remove individual to fresh air. Give oxygen if breathing is labored. If breathing has stopped give artificial respiration. Keep person warm, quiet and seek medical attention. First-aid Measures After Skin Contact: Remove contaminated clothing and wash skin with soap and water. Get medical attention if irritation persists. Launder clothing before reuse. First-aid Measures After Eye Contact: Immediately flush eyes with water for at least 15 minutes. Get medical attention if irritation develops. First-aid Measures After Ingestion: DO NOT INDUCE VOMITING. Seek immediate medical attention. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: N/A Unsuitable Extinguishing Media: Water and water with full jet. 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: Explosion Hazard: Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Firefighting Instructions: Fire fighters should wear full protective clothing including self contained breathing apparatus. Protection During Firefighting: SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: 6.1.1. For Non-emergency Personnel Protective Equipment: Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: Emergency Procedures: 6.2. Environmental Precautions 6.3. Methods and Material for Containment and Cleaning Up For Containment: Methods for Cleaning Up: Wear protective clothing. Keep unprotected persons away. Do not allow to reach sewage system or any water course. Inform respective authorities in case of seepage into water course or sewage system. Absorb with liquid-binding material (sand, diatomite, acid binders, universal binders, sawdust). Dispose of contaminated material as waste in accordance with federal, state and local regulations. Ensure adequate ventilation. Do not flush with water or aqueous cleansing agents. 6.4. Reference to Other Sections See heading 8, Exposure Controls and Personal Protection. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: Prevent formation of aerosols. Keep ignition sources away - Do not smoke. Protect against electrostatic charges. Hygiene Measures: Keep away from foodstuffs, beverages and feed. Immediately remove all soiled and contaminated clothing. Wash hands before breaks and at the end of work. Avoid contact with eyes and skin. 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Storage Conditions: Store in a cool location away from direct heat. Store as a flammable liquid. Keep receptacle tightly sealed. Store in a cool, dry conditions in well sealed receptacles. 7.3. Specific End Use(s) SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters Occupational Exposure Limits Ingredient Name ACGIH TLV OSHA PEL STEL Toluene N/A N/A N/A Methyl Ethyl Ketone (MEK) 500 ppm 1000 ppm 750 ppm 2-Propanone 50 ppm skin 100 ppm skin 150 ppm skin Hexane 50 ppm 500 ppm 1000 ppm Component Exposure Limits: Toluene (108-88-3) PEL - Short term value: 500 ppm (10-min peak/8-hr shift) Long term value: 200 ppm REL - Short term value: 150 ppm Long term value: 100 ppm TLV - 50 ppm Skin; BEI Methyl ethyl ketone (78-93-3) PEL - 200 ppm REL - Short term value: 300 ppm Long term value: 200 ppm TLV - Short term value: 300 ppm Long term value: 200 ppm BEI Acetone (67-64-1) PEL - 1,000 ppm REL - 250 ppm TLV - Short term value: 750 ppm Long term value: 500 ppm BEI Hexane (110-54-3) PEL - 500 ppm REL - 50 ppm TLV - 50 ppm Skin; BEI 8.2. Exposure Controls Appropriate Engineering | Controls | Personal Protective Equipment|Goggles, Gloves Materials for Protective | Clothing | Hand Protection | Eye Protection |Safety goggles or glasses with side shields are |recommended. Skin and Body Protection |Chemical protective gloves are recommended. Wash at |mealtimes and end of shift. Respiratory Protection |In the absence of adequate ventilation, |NIOSH-certified respiratory protection for organic |vapor should be used as necessary. In case of |intensive or prolonged exposure, use respiratory |protective device that is independent of circulating |air. Thermal Hazard Protection | SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State |Liquid Appearance | Odor |Characteristic Odor Threshold |Not determined pH |Not determined Relative Evaporation Rate |Not determined (butylacetate=1) | Melting Point |Undetermined Freezing Point | Boiling Point |55C 131F Flash Point |-26C -15F Auto-ignition Temperature |Product is Not selfigniting Decomposition Temperature |Not determined Flammability (solid, gas) |Not applicable Vapor Pressure |233 hPa (175 mm Hg) @20C Relative Vapor Density at 20 Â°C | Relative Density | Specific Gravity |0.879 Solubility |Not miscible or difficult to m Partition coefficient: |Not determined n-octanol/water | Viscosity |Not determined Lower Flammable Limit |1.2 Upper Flammable Limit |13 9.2. Other Information SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity 10.2 Chemical Stability 10.3 Possibility of Hazardous Reactions Strong oxidizers, acids and bases 10.4 Conditions to Avoid Keep away from extreme heat, sparks, and open flames. 10.5 Incompatible Materials 10.6 Hazardous Decomposition Products Oxides of carbon, nitrogen and hydrocarbons, hydrogen chloride (thermal degradation products) SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: Skin Corrosion/Irritation: Irritant to skin and mucous membranes Serious Eye Damage/Irritation: Irritating effect Respiratory or Skin Sensitization: Sensitizing effect through inhalation is possible with prolonged exposure. Germ Cell Mutagenicity: Carcinogenicity: Reproductive Toxicity: Specific Target Organ Toxicity (Single Exposure): Specific Target Organ Toxicity (Repeated Exposure): Aspiration Hazard: Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Chronic Symptoms: SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity Ecotoxicity Effects: Harmful to fish Environmental Effects: Water Hazard Class 2: Hazardous to water Do not allow product to reach ground water, water course or sewage system. Danger to drinking water if even small amounts leak into the ground. 12.2. Persistence and Degradability 12.3. Bioaccumulative Potential 12.4. Mobility in Soil 12.5. Other Adverse Effects SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: Must not be disposed of together with household garbage. Do not allow product to reach sewage system. Disposal, including empty/used containers, must be made according to local, state and federal regulations. Additional Information: SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name |N/A Hazard Class |N/A |<PICTOGRAM PHRASE> Identification Number|N/A | Label Codes | | ERG Number | 14.2 In Accordance with IMDG Proper Shipping Name | Hazard Class | Identification Number| Label Codes | |<PICTOGRAM PHRASE> ntification Of The | | Substance/m | | EmS-No. (Fire) | | EmS-No. (Spillage) | | 14.3 In Accordance with IATA Proper Shipping Name | Identification Number| |<PICTOGRAM PHRASE> Hazard Class | | Label Codes | | ntification Of The | | Substance/m | | ERG Code (IATA) | SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations <COMPONENT> SARA Title III Section 302 Extremely Hazardous Substances: None SARA Title III Section 304 CERCLA Hazardous Substances: Acetone (67-64-1) Hexane (110-54-3) Methyl ethyl ketone (78-93-3) Toluene (108-88-3) SARA Title III Section 313 Toxic Chemicals: Hexane (110-54-3) Methyl ethyl ketone (78-93-3) Toluene (108-88-3) SARA Section 311/312 Hazard Classes | Toxic Substances Control Act (TSCA) |All chemical substances found in this product |comply with the Toxic Substances Control Act |inventory reporting requirements. 15.2 US State Regulations <COMPONENT> California Proposition 65: This product contains the following chemical(s) listed by the State of California under the Safe Drinking Water and Toxic Enforcement Act of 1986 (Proposition 65) as being known to cause cancer, birth defects or other reproductive harm: Toluene (108-88-3) Teratogen New Jersey: Acetone (67-64-1) Hexane (110-54-3) Methyl ethyl ketone (78-93-3) Toluene (108-88-3) Pennsylvania: Acetone (67-64-1) Hexane (110-54-3) Methyl ethyl ketone (78-93-3) Toluene (108-88-3) SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date |6/1/2015 Other |This document has been prepared in accordance with the SDS Information |requirements of the OSHA Hazard Communication Standard 29 CFR |1910.1200. GHS Full Text Phrases: ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | Grainger disclaimer.
The information contained in this SDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this 'SDS' shall be created or inferred by any statement in this 'SDS'. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this 'SDS'. The user is responsible for full compliance.