Product Categories See All
Track Order Status
Sheet 0071420Printer Friendly View
SECTION 1: IDENTIFICATION 1.1. Product Identifier Product Form: Product Name: A07282 ZEP PRO ZWRK DRY FLM R21701 20N13 CAS No: Synonyms: 1.2. Intended Use of the Product Use of the substance/mixture: 1.3. Name, Address, and Telephone of the Responsible Party Company: Zep Inc. 1310 Seaboard Industrial Blvd., NW Atlanta, GA 30318 Phone: 404-352-1680 1.4. Emergency Telephone Number Emergency |For SDS Information: Compliance Services 1-877-428-9937 number |For a Medical Emergency: 877-541-2016 Toll Free - All Calls |Recorded |For a Transportation Emergency: CHEMTREC: 800-424-9300 - All Calls |Recorded. In the District of Columbia 202-483-7616 SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) Flammable |Category 1 aerosols | Gases under |Liquefied gas pressure | Skin |Category 2 irritation | Specific |Category 3 target organ |(Central toxicity - |nervous single |system) exposure | 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) |Flame |Gas Cylinder |Exclamation Mark Signal Word (GHS-US) |Danger Hazard Statements (GHS-US) |H222 Extremely flammable aerosol. |H280 Contains gas under pressure; may explode if |heated. |H315 Causes skin irritation. |H336 May cause drowsiness or dizziness. Precautionary Statements |Prevention: (GHS-US) |P210 Keep away from heat, hot surfaces, sparks, open |flames and other ignition sources. No smoking. |P211 Do not spray on an open flame or other ignition |source. |P251 Pressurized container: Do not pierce or burn, |even after use. |P261 Avoid breathing dust/ fume/ gas/ mist/ vapours/ |spray. |P264 Wash skin thoroughly after handling. |P271 Use only outdoors or in a well-ventilated area. | |P280 Wear protective gloves. | |Response: |P302 + P352 IF ON SKIN: Wash with plenty of soap and |water. |P304 + P340 + P312 IF INHALED: Remove victim to |fresh air and keep at rest in a position comfortable |for breathing. Call a POISON CENTER or doctor/ |physician if you feel unwell. |P332 + P313 If skin irritation occurs: Get medical |advice/ attention. |P362 Take off contaminated clothing and wash before |reuse. | |Storage: |P403 + P233 Store in a well-ventilated place. Keep |container tightly closed. |P405 Store locked up. |P410 + P412 Protect from sunlight. Do not expose to |temperatures exceeding 50 �C/ 122 �F. | |Disposal: |P501 Dispose of contents/container in accordance |with local regulation. 2.3. Other Hazards Other Hazards Not Contributing to the Classification: 2.4. Unknown Acute Toxicity (GHS-US) SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name |Product identifier |% |Classification | | |(GHS-US) Heptane, branched, cyclic and |426260-76-6 |>= 50 - | linear | |< 70 | Propane |74-98-6 |>= 10 - | | |< 20 | Butane |106-97-8 |>= 10 - | | |< 20 | propan-2-ol |67-63-0 |>= 1 - <| | |5 | Heptane |142-82-5 |>= 1 - <| | |5 | SECTION 4: FIRST AID MEASURES 4.1. Description of First Aid Measures First-aid Measures General: Move out of dangerous area. Show this safety data sheet to the doctor in attendance. Do not leave the victim unattended. First-aid Measures After Inhalation: Consult a physician after significant exposure. If unconscious place in recovery position and seek medical advice. First-aid Measures After Skin Contact: If skin irritation persists, call a physician. Wash off immediately with plenty of water for at least 15 minutes. If on clothes, remove clothes. First-aid Measures After Eye Contact: Remove contact lenses. Protect unharmed eye. Keep eye wide open while rinsing. If eye irritation persists, consult a specialist. Rinse immediately with plenty of water for at least 15 minutes. First-aid Measures After Ingestion: Keep respiratory tract clear. Never give anything by mouth to an unconscious person. If symptoms persist, call a physician. DO NOT induce vomiting unless directed to do so by a physician or poison control center. Take victim immediately to hospital. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: Alcohol-resistant foam Carbon dioxide (CO2) Dry chemical Water spray jet Unsuitable Extinguishing Media: High volume water jet 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: Do not allow run-off from fire fighting to enter drains or water courses. Explosion Hazard: Carbon dioxide (CO2) Carbon monoxide Smoke Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Collect contaminated fire extinguishing water separately. This must not be discharged into drains. Fire residues and contaminated fire extinguishing water must be disposed of in accordance with local regulations. For safety reasons in case of fire, cans should be stored separately in closed containments. Use a water spray to cool fully closed containers. Firefighting Instructions: Use extinguishing measures that are appropriate to local circumstances and the surrounding environment. Protection During Firefighting: Wear self-contained breathing apparatus for firefighting if necessary. SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: Use personal protective equipment. Ensure adequate ventilation. Remove all sources of ignition. Evacuate personnel to safe areas. Beware of vapours accumulating to form explosive concentrations. Vapours can accumulate in low areas. 6.1.1. For Non-emergency Personnel Protective Equipment: Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: Emergency Procedures: 6.2. Environmental Precautions Prevent product from entering drains. Prevent further leakage or spillage if safe to do so. If the product contaminates rivers and lakes or drains inform respective authorities. 6.3. Methods and Material for Containment and Cleaning Up For Containment: Soak up with inert absorbent material (e.g. sand, silica gel, acid binder, universal binder, sawdust). Methods for Cleaning Up: Sweep up or vacuum up spillage and collect in suitable container for disposal. 6.4. Reference to Other Sections See heading 8, Exposure Controls and Personal Protection. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: Avoid exposure - obtain special instructions before use. Avoid contact with skin and eyes. For personal protection see section 8. Smoking, eating and drinking should be prohibited in the application area. Do not breathe vapours or spray mist. Take precautionary measures against static discharges. Provide sufficient air exchange and/or exhaust in work rooms. Dispose of rinse water in accordance with local and national regulations. Always replace cap after use. Hygiene Measures: When using do not eat or drink. When using do not smoke. Wash hands before breaks and at the end of workday. 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Storage Conditions: BEWARE: Aerosol is pressurized. Keep away from direct sun exposure and temperatures over 50 �C. Do not open by force or throw into fire even after use. Do not spray on flames or red-hot objects. No smoking. Keep in a dry, cool and well-ventilated place. Observe label precautions. Electrical installations / working materials must comply with the technological safety standards. Materials to avoid: Oxidizing agents 7.3. Specific End Use(s) SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters Components with workplace control parameters Components CAS-No. Value type (Form of exposure) Control parameters / Permissible concentration Basis Heptane, branched, cyclic and linear 426260-76-6 TWA C TWA TWA STEL 85 ppm 350 mg/m3 440 ppm 1,800 mg/m3 500 ppm 2,000 mg/m3 400 ppm 1,600 mg/m3 500 ppm 2,000 mg/m3 NIOSH REL NIOSH REL OSHA Z-1 OSHA P0 OSHA P0 Propane 74-98-6 TWA TWA TWA TWA 1,000 ppm 1,000 ppm 1,800 mg/m3 1,000 ppm 1,800 mg/m3 1,000 ppm 1,800 mg/m3 ACGIH NIOSH REL OSHA Z-1 OSHA P0 Butane 106-97-8 TWA TWA 800 ppm 1,900 mg/m3 800 ppm 1,900 mg/m3 NIOSH REL OSHA P0 propan-2-ol 67-63-0 TWA STEL TWA ST TWA TWA STEL 200 ppm 400 ppm 400 ppm 980 mg/m3 500 ppm 1,225 mg/m3 400 ppm 980 mg/m3 400 ppm 980 mg/m3 500 ppm 1,225 mg/m3 ACGIH ACGIH NIOSH REL NIOSH REL OSHA Z-1 OSHA P0 OSHA P0 Heptane 142-82-5 TWA C TWA TWA STEL 85 ppm 350 mg/m3 440 ppm 1,800 mg/m3 500 ppm 2,000 mg/m3 400 ppm 1,600 mg/m3 500 ppm 2,000 mg/m3 NIOSH REL NIOSH REL OSHA Z-1 OSHA P0 OSHA P0 Biological occupational exposure limits Component CAS-No. Control parameters Biological specimen Sampling time Permissible concentration Basis PROPAN-2-OL 67-63-0 Acetone Urine End of shift at end of workweek 40 mg/l ACGIH BEI 8.2. Exposure Controls Appropriate Engineering | Controls | Personal Protective Equipment| Materials for Protective | Clothing | Hand Protection |Remarks: The suitability for a specific workplace |should be discussed with the producers of the |protective gloves. Eye Protection |Ensure that eyewash stations and safety showers are |close to the workstation location. Safety glasses Skin and Body Protection |impervious clothing Choose body protection according |to the amount and concentration of the dangerous |substance at the work place. Respiratory Protection |Use respiratory protection unless adequate local |exhaust ventilation is provided or exposure |assessment demonstrates that exposures are within |recommended exposure guidelines. Thermal Hazard Protection | SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State | Appearance |Aerosol containing a liquefied gas Odor |mild, solvent-like Odor Threshold |no data available pH |not applicable Relative Evaporation Rate |not determined (butylacetate=1) | Melting Point |no data available Freezing Point |no data available Boiling Point |no data available Flash Point |not applicable Auto-ignition Temperature |not determined Decomposition Temperature |no data available Flammability (solid, gas) |Extremely flammable aerosol. Vapor Pressure |not determined Relative Vapor Density at 20 �C |no data available Relative Density | Specific Gravity | Solubility |Insoluble Partition coefficient: |no data available n-octanol/water | Viscosity |no data available Lower Flammable Limit |1.2 %(V) Upper Flammable Limit |6.7 %(V) 9.2. Other Information SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity Stable 10.2 Chemical Stability Stable under normal conditions. 10.3 Possibility of Hazardous Reactions No decomposition if stored and applied as directed. Vapours may form explosive mixture with air. 10.4 Conditions to Avoid Heat, flames and sparks. Extremes of temperature and direct sunlight. 10.5 Incompatible Materials Oxidizing agents 10.6 Hazardous Decomposition Products Carbon oxides SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: Product: Acute oral toxicity : Acute toxicity estimate : > 5,000 mg/kg Method: Calculation method Components: propane: Acute inhalation toxicity: LC50 mouse: 1,237 mg/l Exposure time: 2 h LC50 rat: 658 mg/l Exposure time: 4 h LC50 rat: 1,355 mg/l butane: Acute inhalation toxicity: LC50 mouse: 1,237 mg/l Exposure time: 2 h LC50 rat: 1,355 mg/l propan-2-ol: Acute oral toxicity: LD50 Oral rat: 4,396 mg/kg Method: Calculation method heptane: Acute inhalation toxicity: LC50 rat: 103,000 mg/l Exposure time: 4 h Skin Corrosion/Irritation: Remarks: May irritate skin. Serious Eye Damage/Irritation: Remarks: Vapours may cause irritation to the eyes, respiratory system and the skin. Respiratory or Skin Sensitization: no data available Germ Cell Mutagenicity: no data available Carcinogenicity: no data available Reproductive Toxicity: no data available Specific Target Organ Toxicity (Single Exposure): no data available Specific Target Organ Toxicity (Repeated Exposure): no data available Aspiration Hazard: no data available Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Chronic Symptoms: Symptoms of overexposure may be headache, dizziness, tiredness, nausea and vomiting., Concentrations substantially above the TLV value may cause narcotic effects., Solvents may degrease the skin. SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity no data available 12.2. Persistence and Degradability no data available 12.3. Bioaccumulative Potential Product: Partition coefficient: n-octanol/water: Remarks: no data available Components: butane : Partition coefficient: n-octanol/water: Pow: 2.89 heptane : Partition coefficient: n-octanol/water: log Pow: > 3.0 log Pow: 5 12.4. Mobility in Soil no data available 12.5. Other Adverse Effects no data available SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: The product should not be allowed to enter drains, water courses or the soil. Do not contaminate ponds, waterways or ditches with chemical or used container. Send to a licensed waste management company. Additional Information: Contaminated packaging: Empty remaining contents. Dispose of as unused product. Do not re-use empty containers. Do not burn, or use a cutting torch on, the empty drum. SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name | Hazard Class | |<PICTOGRAM PHRASE> Identification Number| | Label Codes | | ERG Number | 14.2 In Accordance with IMDG Proper Shipping Name |AEROSOLS Hazard Class |2.1 Identification Number|UN1950 Label Codes | |<PICTOGRAM PHRASE> ntification Of The | | Substance/m | | EmS-No. (Fire) | | EmS-No. (Spillage) | | 14.3 In Accordance with IATA Proper Shipping Name |Aerosols, flammable Identification Number|UN1950 |<PICTOGRAM PHRASE> Hazard Class |2.1 | Label Codes | | ntification Of The | | Substance/m | | ERG Code (IATA) | SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations <COMPONENT> CERCLA Reportable Quantity This material does not contain any components with a CERCLA RQ. SARA 304 Extremely Hazardous Substances Reportable Quantity This material does not contain any components with a section 304 EHS RQ. SARA 302: SARA 302: No chemicals in this material are subject to the reporting requirements of SARA Title III, Section 302. SARA 313: SARA 313: This material does not contain any chemical components with known CAS numbers that exceed the threshold (De Minimis) reporting levels established by SARA Title III, Section 313. SARA Section 311/312 Hazard Classes |Fire Hazard |Sudden Release of Pressure Hazard |Acute Health Hazard Toxic Substances Control Act (TSCA) |On TSCA Inventory 15.2 US State Regulations <COMPONENT> California Prop 65 This product does not contain any chemicals known to State of California to cause cancer, birth defects, or any other reproductive harm. SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date |05/14/2015 Other |This document has been prepared in accordance with the SDS Information |requirements of the OSHA Hazard Communication Standard 29 CFR |1910.1200. GHS Full Text Phrases: ----|Hazard statements |Extremely flammable aerosol. -- | | ----| |Contains gas under pressure; may explode if -- | |heated. ----| |Causes skin irritation. -- | | ----| |May cause drowsiness or dizziness. -- | | ----|Precautionary statements |Prevention: Keep away from heat, hot -- | |surfaces, sparks, open flames and other | |ignition sources. No smoking. | |Do not spray on an open flame or other | |ignition source. | |Pressurized container: Do not pierce or burn, | |even after use. | |Avoid breathing dust/ fume/ gas/ mist/ | |vapours/ spray. | |Wash skin thoroughly after handling. | |Use only outdoors or in a well-ventilated | |area. | |Wear protective gloves. | |Response: IF ON SKIN: Wash with plenty of | |soap and water. | |IF INHALED: Remove victim to fresh air and | |keep at rest in a position comfortable for | |breathing. | |Call a POISON CENTER or doctor/ physician if | |you feel unwell. | |If skin irritation occurs: Get medical | |advice/ attention. | |Take off contaminated clothing and wash | |before reuse. | |Storage: Store in a well-ventilated place. | |Keep container tightly closed. Store locked | |up. | |Protect from sunlight. | |Do not expose to temperatures exceeding 50 | |�C/ 122 �F. | |Disposal: Dispose of contents/container in | |accordance with local regulation. Grainger disclaimer.
The information contained in this was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this '' shall be created or inferred by any statement in this ''. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this ''. The user is responsible for full compliance.