Product Categories See All
Track Order Status
SDS Sheet 0071310Printer Friendly View
SECTION 1: IDENTIFICATION | |1.1. Product Identifier Product Form: Product Name: A00734 ZEP PRO FAST EVAP R11901 20n14 CAS No: Synonyms: 1.2. Intended Use of the Product Use of the substance/mixture: 1.3. Name, Address, and Telephone of the Responsible Party Company Zep Inc 1310 Seaboard Industrial Blvd., NW Atlanta, GA 30318 Phone: 404-352-1680 1.4. Emergency Telephone Number Emergency |800-424-9300, 877-541-2016, 800-424-9300, 202-483-7616 number | SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) Flammable |Category 1 aerosols | Gases under |Compressed gas pressure | Skin |Category 2 irritation | Specific |Category 3 target organ |(Central toxicity - |nervous single |system) exposure | | 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) |Flame |Gas Cylinder |Exclamation Mark Signal Word (GHS-US) |Danger Hazard Statements (GHS-US) |H222 Extremely flammable aerosol. |H280 Contains gas under pressure; may explode if |heated. |H315 Causes skin irritation. |H336 May cause drowsiness or dizziness. Precautionary Statements |Prevention (GHS-US) |P210 Keep away from heat, hot surfaces, sparks, open |flames and other ignition sources. No smoking. |P211 Do not spray on an open flame or other ignition |source.P251 Pressurized container: Do not pierce or |burn, even after use. |P261 Avoid breathing dust/ fume/ gas/ mist/ vapours/ |spray. |P264 Wash skin thoroughly after handling. |P271 Use only outdoors or in a well-ventilated area. | |P280 Wear protective gloves. |Response |P302 + P352 IF ON SKIN: Wash with plenty of soap and |water. |P304 + P340 + P312 IF INHALED: Remove victim to |fresh air and keep at rest in a position comfortable |for breathing. Call a POISON CENTER or doctor/ |physician if you feel unwell. |P332 + P313 If skin irritation occurs: Get medical |advice/ attention. |P362 Take off contaminated clothing and wash before |reuse. |Storage |P403 + P233 Store in a well-ventilated place. Keep |container tightly closed. |P405 Store locked up. |P410 + P412 Protect from sunlight. Do not expose to |temperatures exceeding 50 Â°C/ 122 Â°F. |Disposal |P501 Dispose of contents/container in accordance |with local regulation. 2.3. Other Hazards Other Hazards Not Contributing to the Classification: 2.4. Unknown Acute Toxicity (GHS-US) SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name |Product identifier |% |Classification | | |(GHS-US) Heptane, branched, cyclic and |426260-76-6 |>= 70 - | linear | |< 90 | ethanol |64-17-5 |>= 5 - <| | |10 | carbon dioxide |124-38-9 |>= 5 - <| | |10 | heptane |142-82-5 |>= 1 - <| | |5 | | | | SECTION 4: FIRST AID MEASURES 4.1. Description of First Aid Measures First-aid Measures General: Show this safety data sheet to the doctor in attendance. First-aid Measures After Inhalation: Remove to fresh air. Call a physician or poison control centre immediately. First-aid Measures After Skin Contact: If skin irritation persists, call a physician. Wash off immediately with plenty of water for at least 15 minutes. First-aid Measures After Eye Contact: Flush eyes with water at least 15 minutes. Get medical attention if eye irritation develops or persists. First-aid Measures After Ingestion: DO NOT induce vomiting unless directed to do so by a physician or poison control center. Drink 1 or 2 glasses of water. Obtain medical attention. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: Foam Carbon dioxide (CO2) Dry chemical Unsuitable Extinguishing Media: 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: Carbon dioxide (CO2), Carbon monoxide, Smoke Explosion Hazard: Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Firefighting Instructions: Wear self-contained breathing apparatus for firefighting if necessary. Protection During Firefighting: Collect contaminated fire extinguishing water separately. This must not be discharged into drains. Fire residues and contaminated fire extinguishing water must be disposed of in accordance with local regulations. For safety reasons in case of fire, cans should be stored separately in closed containments. Use a water spray to cool fully closed containers. SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: Use personal protective equipment. Ensure adequate ventilation. Remove all sources of ignition. Evacuate personnel to safe areas. Beware of vapours accumulating to form explosive concentrations. Vapours can accumulate in low areas. 6.1.1. For Non-emergency Personnel Protective Equipment: Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: Emergency Procedures: 6.2. Environmental Precautions Prevent product from entering drains. Prevent further leakage or spillage if safe to do so. If the product contaminates rivers and lakes or drains inform respective authorities. 6.3. Methods and Material for Containment and Cleaning Up For Containment: Methods for Cleaning Up: Wipe up with absorbent material (e.g. cloth, fleece). 6.4. Reference to Other Sections See heading 8, Exposure Controls and Personal Protection. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: Do not breathe vapours/dust. Do not puncture. Avoid contact with skin and eyes. Smoking, eating and drinking should be prohibited in the application area. Hygiene Measures: When using do not eat or drink. When using do not smoke. Wash hands before breaks and at the end of workday. 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Storage Conditions: BEWARE: Aerosol is pressurized. Keep away from direct sun exposure and temperatures over 50 Â°C. Do not open by force or throw into fire even after use. Do not spray on flames or red-hot objects. No smoking. Keep container tightly closed in a dry and well-ventilated place. Containers which are opened must be carefully resealed and kept upright to prevent leakage. Observe label precautions. Electrical installations / working materials must comply with the technological safety standards. Materials to avoid: Do not store together with oxidizing and self-igniting products. 7.3. Specific End Use(s) SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters Components CAS-No. Value type (Form of exposure) Control parameters / Permissible concentration Basis Heptane, branched, cyclic and linear 426260-76-6 TWA 85 ppm 350 mg/m3 NIOSH REL C 440 ppm 1,800 mg/m3 NIOSH REL TWA 500 ppm 2,000 mg/m3 OSHA Z-1 TWA 400 ppm 1,600 mg/m3 OSHA P0 STEL 500 ppm 2,000 mg/m3 OSHA P0 ethanol 64-17-5 TWA 1,000 ppm ACGIH TWA 1,000 ppm 1,900 mg/m3 NIOSH REL TWA 1,000 ppm 1,900 mg/m3 OSHA Z-1 TWA 1,000 ppm 1,900 mg/m3 OSHA P0 carbon dioxide 124-38-9 TWA 5,000 ppm ACGIH STEL 30,000 ppm ACGIH TWA 5,000 ppm 9,000 mg/m3 NIOSH REL ST 30,000 ppm 54,000 mg/m3 NIOSH REL TWA 5,000 ppm 9,000 mg/m3 OSHA Z-1 TWA 10,000 ppm 18,000 mg/m3 OSHA P0 STEL 30,000 ppm 54,000 mg/m3 OSHA P0 heptane 142-82-5 TWA 85 ppm 350 mg/m3 NIOSH REL C 440 ppm 1,800 mg/m3 NIOSH REL TWA 500 ppm 2,000 mg/m3 OSHA Z-1 TWA 400 ppm 1,600 mg/m3 OSHA P0 STEL 500 ppm 2,000 mg/m3 OSHA P0 8.2. Exposure Controls Appropriate Engineering | Controls | Personal Protective Equipment| Materials for Protective | Clothing | Hand Protection |Material: Neoprene. |Remarks: The suitability for a specific workplace |should be discussed with the producers of the |protective gloves. Eye Protection |Eye wash bottle with pure water Tightly fitting |safety goggles. Skin and Body Protection |Impervious clothing. Choose body protection |according to the amount and concentration of the |dangerous substance at the work place. Respiratory Protection |In the case of vapour formation use a respirator |with an approved filter. In the case of dust or |aerosol formation use respirator with an approved |filter. Thermal Hazard Protection | SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State | Appearance |Aerosol containing a compressed gas Odor |aliphatic, solvent-like Odor Threshold |no data available pH |no data available Relative Evaporation Rate |not determined (butylacetate=1) | Melting Point |no data available Freezing Point |no data available Boiling Point |not applicable Flash Point |not applicable Auto-ignition Temperature |not determined Decomposition Temperature | Flammability (solid, gas) | Vapor Pressure |no data available Relative Vapor Density at 20 Â°C |no data available Relative Density |no data available Specific Gravity | Solubility |not applicable Partition coefficient: |no data available n-octanol/water | Viscosity |no data available Lower Flammable Limit |not determined Upper Flammable Limit |not determined 9.2. Other Information SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity Stable. 10.2 Chemical Stability Stable under normal conditions. 10.3 Possibility of Hazardous Reactions Vapours may form explosive mixture with air. No decomposition if stored and applied as directed. 10.4 Conditions to Avoid Heat, flames and sparks. 10.5 Incompatible Materials Strong oxidizing agents. 10.6 Hazardous Decomposition Products Carbon dioxide (CO2) Carbon monoxide. SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: Skin Corrosion/Irritation: Product: Remarks: slight irritation. Serious Eye Damage/Irritation: Product: Remarks: slight irritation. Respiratory or Skin Sensitization: no data available. Germ Cell Mutagenicity: no data available. Carcinogenicity: no data available. Reproductive Toxicity: no data available. Specific Target Organ Toxicity (Single Exposure): no data available. Specific Target Organ Toxicity (Repeated Exposure): no data available. Aspiration Hazard: no data available. Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Chronic Symptoms: SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity no data available. 12.2. Persistence and Degradability no data available. 12.3. Bioaccumulative Potential Product: Partition coefficient: n-octanol/water : Remarks: no data available Components: heptane : Partition coefficient: n-octanol/water: log Pow: > 3.0 log Pow: 5 12.4. Mobility in Soil no data available. 12.5. Other Adverse Effects no data available. Product: Regulation: 40 CFR Protection of Environment; Part 82 Protection of Stratospheric Ozone - CAA Section 602 Class I Substances. Remarks: This product neither contains, nor was manufactured with a Class I or Class II ODS as defined by the U.S. Clean Air Act Section 602 (40 CFR 82, Subpt. A, App.A + B). Additional ecological information: An environmental hazard cannot be excluded in the event of unprofessional handling or disposal., Very toxic to aquatic life., May cause long lasting harmful effects to aquatic life. SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: Dispose of in accordance with local regulations. Additional Information: Contaminated packaging: Empty remaining contents. Dispose of as unused product. Do not re-use empty containers. Do not burn, or use a cutting torch on, the empty drum. SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name | Hazard Class | |<PICTOGRAM PHRASE> Identification Number| | Label Codes | | ERG Number | 14.2 In Accordance with IMDG Proper Shipping Name |Aerosols, flammable Hazard Class |2.1 Identification Number|UN1950 Label Codes | |<PICTOGRAM PHRASE> ntification Of The | | Substance/m | | EmS-No. (Fire) | | EmS-No. (Spillage) | | 14.3 In Accordance with IATA Proper Shipping Name |Cargo Air: Aerosols, flammable |Passenger Air: Aerosols, flammable Identification Number|UN1950 |<PICTOGRAM PHRASE> Hazard Class |2.1 | Label Codes | | ntification Of The | | Substance/m | | ERG Code (IATA) | SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations <COMPONENT> EPCRA - Emergency Planning and Community Right-to-Know Act: CERCLA Reportable Quantity: This material does not contain any components with a CERCLA RQ. SARA 304 Extremely Hazardous Substances Reportable Quantity: This material does not contain any components with a section 304 EHS RQ. SARA 302: SARA 302: No chemicals in this material are subject to the reporting requirements of SARA Title III, Section 302. SARA 313: This material does not contain any chemical components with known CAS numbers that exceed the threshold (De Minimis) reporting levels established by SARA Title III, Section 313. SARA Section 311/312 Hazard Classes |Fire Hazard |Sudden Release of Pressure Hazard |Acute Health Hazard. Toxic Substances Control Act (TSCA) |On TSCA Inventory. 15.2 US State Regulations <COMPONENT> California Prop 65: This product does not contain any chemicals known to State of California to cause cancer, birth defects, or any other reproductive harm. SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date |02/11/2015 Other |This document has been prepared in accordance with the SDS Information |requirements of the OSHA Hazard Communication Standard 29 CFR |1910.1200. GHS Full Text Phrases: ----|Hazard statements: |Extremely flammable aerosol. Contains gas -- | |under pressure; may explode if heated. Causes | |skin irritation. May cause drowsiness or | |dizziness. ----|Precautionary statements: |Prevention: -- | |Keep away from heat, hot surfaces, sparks, | |open flames and other ignition sources. No | |smoking. Do not spray on an open flame or | |other ignition source. Pressurized container: | |Do not pierce or burn, even after use. Avoid | |breathing dust/ fume/ gas/ mist/ vapours/ | |spray. Wash skin thoroughly after handling. | |Use only outdoors or in a well-ventilated | |area. Wear protective gloves. | |Response: | |IF ON SKIN: Wash with plenty of soap and | |water. IF INHALED: Remove victim to fresh air | |and keep at rest in a position comfortable | |for breathing. Call a POISON CENTER or | |doctor/ physician if you feel unwell. If skin | |irritation occurs: Get medical advice/ | |attention. Take off contaminated clothing and | |wash before reuse. | |Storage: | |Store in a well-ventilated place. Keep | |container tightly closed. Store locked up. | |Protect from sunlight. Do not expose to | |temperatures exceeding 50 Â°C/ 122 Â°F. | |Disposal: | |Dispose of contents/container in accordance | |with local regulation. ----| | -- | | ----| | -- | | ----| | -- | | Grainger disclaimer.
The information contained in this SDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this 'SDS' shall be created or inferred by any statement in this 'SDS'. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this 'SDS'. The user is responsible for full compliance.