Product Categories See All
Track Order Status
SDS Sheet 0067340Printer Friendly View
Safety Data Sheet | | Date of Issue: 03/31/2014 |Revision Date: 03/31/2014 |Revision Number: Imperial Supplies Part Number: 0067340 SECTION 1: IDENTIFICATION 1.1. Product Identifier Product Form: Product Name: PENRAY ELECTRIC MOTOR CLEANER CAS No: Synonyms: 1.2. Intended Use of the Product Use of the substance/mixture: ELECTRIC MOTOR CLEANER. 1.3. Name, Address, and Telephone of the Responsible Party Company The Penray Companies, Inc. 440 Denniston Ct. 60090 Wheeling, IL Phone: (800) 373-6729 firstname.lastname@example.org 1.4. Emergency Telephone Number Emergency | (800) 373-6729 CHEMTREC (800) 424-9300 CHEMTREC International +1 number |(703) 527-3887 24 hr SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) Skin |2 irritation | Carcinogenicit|1B y | Specific |Single target organ |exposure 3 toxicity | 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) |Gas |Exclamat|Health | | | |cylinder|ion mark|hazard | | | Signal Word (GHS-US) |Danger Hazard Statements (GHS-US) |Contains gas under pressure; may explode if heated. |Causes skin irritation. May cause cancer. May cause |drowsiness or dizziness. Precautionary Statements |Wash hands thoroughly after handling. Obtain special (GHS-US) |instructions before use. Do not handle until all |safety precautions have been read and understood. |Wear protective gloves/protective clothing/eye |protection/face protection. Avoid breathing |gas/mist/vapors/spray. Use only outdoors or in a |well-ventilated area. If exposed or concerned: Get |medical advice/attention. If on skin: Wash with |plenty of water. Take off contaminated clothing and |wash it before reuse. If skin irritation occurs: Get |medical advice/attention. If inhaled: Remove person |to fresh air and keep comfortable for breathing. |Call a poison center/doctor if you feel unwell. |Store locked up. Store in a well-ventilated place. |Protect from sunlight. Dispose of contents and |container in accordance with all local, regional, |national and international regulations. 2.3. Other Hazards Other Hazards Not Contributing to the Classification: No additional information available 2.4. Unknown Acute Toxicity (GHS-US) 3 % of the mixture consists of ingredient(s) of unknown acute toxicity. SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name |Product identifier |% |Classification | | |(GHS-US) Tetrachloroethylene |127-18-4 |60 - 100|Skin Irrit. 2 | | |Carc. 1B | | |STOT SE 3 Carbon dioxide |124-38-9 |1 - 5 |Compressed gas | | | | | | | | | SECTION 4: FIRST AID MEASURES 4.1. Description of First Aid Measures First-aid Measures General: First-aid Measures After Inhalation: If inhaled, remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. Get medical advice/attention if you feel unwell. First-aid Measures After Skin Contact: In case of contact, immediately flush skin with plenty of water. Remove contaminated clothing and shoes. Wash clothing before reuse. Call a physician if irritation develops and persists. First-aid Measures After Eye Contact: In case of contact, immediately flush eyes with plenty of water. Remove contact lenses, if worn. If irritation persists, get medical attention. First-aid Measures After Ingestion: If swallowed, do NOT induce vomiting unless directed to do so by medical personnel. Never give anything by mouth to an unconscious person. Get medical advice/attention if you feel unwell. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: Symptoms/Injuries After Inhalation: Vapors may cause narcosis with headache, difficulty breathing, light headedness, drowsiness, unconsciousness and possibly death. May cause respiratory tract irritation. Symptoms/Injuries After Skin Contact: Causes skin irritation. Symptoms may include redness, edema, drying, defatting and cracking of the skin. Symptoms/Injuries After Eye Contact: May cause eye irritation. Symptoms may include discomfort or pain, excess blinking and tear production, with possible redness and swelling. Symptoms/Injuries After Ingestion: May be harmful if swallowed. May cause stomach distress, nausea or vomiting. Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed Symptoms may not appear immediately. In case of accident or if you feel unwell, seek medical advice immediately (show the label or SDS where possible). SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: Treat for surrounding material. Unsuitable Extinguishing Media: Not available. 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: Products of combustion may include, and are not limited to: oxides of carbon. Explosion Hazard: Contains gas under pressure; may explode if heated. Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Firefighting Instructions: Protection During Firefighting: Keep upwind of fire. Wear full fire fighting turn-out gear (full Bunker gear) and respiratory protection (SCBA). Use water spray to keep fire-exposed containers cool. SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: Use personal protection recommended in Section 8. Isolate the hazard area and deny entry to unnecessary and unprotected personnel. 6.1.1. For Non-emergency Personnel Protective Equipment: Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: Emergency Procedures: 6.2. Environmental Precautions 6.3. Methods and Material for Containment and Cleaning Up For Containment: Contain and/or absorb spill with inert material (e.g. sand, vermiculite), then place in a suitable container. Do not flush to sewer or allow to enter waterways. Use appropriate Personal Protective Equipment (PPE). Methods for Cleaning Up: Scoop up material and place in a disposal container. Provide ventilation. 6.4. Reference to Other Sections See section 8 for further information on protective clothing and equipment and section 13 for advice on waste disposal. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: Pressurized container: Do not pierce or burn, even after use. Avoid contact with skin and eyes. Avoid breathing gas/mist/vapors/spray. Do not swallow. Handle and open container with care. When using do not eat, drink or smoke. Use only outdoors or in a well-ventilated area. Hygiene Measures: Launder contaminated clothing before reuse. Wash hands before eating, drinking, or smoking. 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Storage Conditions: Keep out of the reach of children. Store locked up. Protect from sunlight. Store in a well-ventilated place. 7.3. Specific End Use(s) Not available. SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters Tetrachloroethylene (127-18-4) USA ACGIH ACGIH TWA (ppm) 25 ppm USA ACGIH ACGIH STEL (ppm) 100 ppm USA OSHA OSHA PEL (TWA) (ppm) 100 ppm USA OSHA OSHA PEL (Ceiling) (ppm) 200 ppm Carbon dioxide (124-38-9) USA ACGIH ACGIH TWA (ppm) 5000 ppm USA ACGIH ACGIH STEL (ppm) 30000 ppm USA OSHA OSHA PEL (TWA) (mg/mÂ³) 9000 mg/mÂ³ USA OSHA OSHA PEL (TWA) (ppm) 5000 ppm 8.2. Exposure Controls Appropriate Engineering |Use ventilation adequate to keep exposures (airborne Controls |levels of dust, fume, vapor, etc.) below recommended |exposure limits. Personal Protective Equipment|Avoid all unnecessary exposure. Materials for Protective | Clothing | Hand Protection |Wear chemically resistant protective gloves. Eye Protection |Safety glasses or goggles are recommended when using |product. Skin and Body Protection |Wear suitable protective clothing. Respiratory Protection |A NIOSH approved respirator is recommended in poorly |ventilated areas or when permissible exposure limits |may be exceeded. Respirator selection must be based |on known or anticipated exposure levels, the hazards |of the product and the safe working limits of the |selected respirator. Thermal Hazard Protection | SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State |Gas/Pressurized Liquid. Appearance |Clear. Odor |Chlorine. Odor Threshold |No data available. Ph |No data available. Relative Evaporation Rate (butyl |No data available. acetate=1) | Melting Point |No data available. Freezing Point |No data available. Boiling Point |No data available. Flash Point |No data available. Auto-ignition Temperature | Decomposition Temperature |No data available. Flammability (solid, gas) |Not flammable Vapor Pressure |No data available. Relative Vapor Density at 20 Â°C |No data available. Relative Density |1.60 - 1.65 Specific Gravity | Solubility |No data available. Partition coefficient: | n-octanol/water | Viscosity |Kinematic, dynamic: No data available. Lower Flammable Limit | Upper Flammable Limit | 9.2. Other Information No additional information available SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity No dangerous reaction known under conditions of normal use. 10.2 Chemical Stability Stable under normal storage conditions. Contents under pressure. Container may explode if heated. Do not puncture. Do not burn. 10.3 Possibility of Hazardous Reactions No dangerous reaction known under conditions of normal use. 10.4 Conditions to Avoid Heat. Incompatible materials. 10.5 Incompatible Materials Amines. Bases. Strong oxidizing agents. Metals. 10.6 Hazardous Decomposition Products May include, and are not limited to: oxides of carbon, hydrogen chloride, other poisonous chlorine compounds. SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: Not classified 7014 LD50 oral rat > 2000 mg/kg LD50 dermal rabbit > 2000 mg/kg LC50 inhalation rat (mg/l) > 5 mg/l/4h Tetrachloroethylene (127-18-4) LD50 oral rat 2629 mg/kg LD50 dermal rabbit > 3228 mg/kg LC50 inhalation rat (ppm) 4000 ppm/4h Skin Corrosion/Irritation: Causes skin irritation. Serious Eye Damage/Irritation: Based on available data, the classification criteria are not met. Respiratory or Skin Sensitization: Based on available data, the classification criteria are not met. Germ Cell Mutagenicity: Based on available data, the classification criteria are not met. Carcinogenicity: May cause cancer. Tetrachloroethylene (127-18-4) IARC group 2A National Toxicity Program (NTP) Status 1, 3 Reproductive Toxicity: Based on available data, the classification criteria are not met. Specific Target Organ Toxicity (Single Exposure): May cause drowsiness or dizziness. Specific Target Organ Toxicity (Repeated Exposure): Based on available data, the classification criteria are not met. Aspiration Hazard: Based on available data, the classification criteria are not met. Symptoms/Injuries After Inhalation: Vapors may cause narcosis with headache, difficulty breathing, light headedness, drowsiness, unconsciousness and possibly death. May cause respiratory irritation. Symptoms/Injuries After Skin Contact: Causes skin irritation. Symptoms may include redness, edema, drying, defatting and cracking of the skin. Symptoms/Injuries After Eye Contact: May cause eye irritation. Symptoms may include discomfort or pain, excess blinking and tear production, with possible redness and swelling. Symptoms/Injuries After Ingestion: May be harmful if swallowed. May cause stomach distress, nausea or vomiting. Chronic Symptoms: SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity Ecology - general: May cause long-term adverse effects in the aquatic environment. 12.2. Persistence and Degradability 7014 Persistence and degradability Not established. 12.3. Bioaccumulative Potential 7014 Bioaccumulative potential Not established. 12.4. Mobility in Soil No additional information available 12.5. Other Adverse Effects No additional information available SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: This material must be disposed of in accordance with all local, state, provincial, and federal regulations. The generation of waste should be avoided or minimized wherever possible. Additional Information: SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name |Aerosols Hazard Class |2.2 (6.1) |<PICTOGRAM PHRASE> | |Gas Cylinder | |Skull & Crossbones Identification Number|UN1950 | Label Codes | | ERG Number | 14.2 In Accordance with IMDG Proper Shipping Name | Hazard Class | Identification Number| Label Codes | |<PICTOGRAM PHRASE> ntification Of The | | Substance/m | | EmS-No. (Fire) | | EmS-No. (Spillage) | | 14.3 In Accordance with IATA Proper Shipping Name | Identification Number| |<PICTOGRAM PHRASE> Hazard Class | | Label Codes | | ntification Of The | | Substance/m | | ERG Code (IATA) | SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations <COMPONENT> SARA Section 311/312 Hazard Classes | Toxic Substances Control Act (TSCA) |Tetrachloroethylene (127-18-4): Listed |Carbon dioxide (124-38-9): Listed 15.2 US State Regulations <COMPONENT> 7014 State or local regulations This product contains a chemical known to the State of California to cause cancer. SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date |03/31/2014 Other |This document has been prepared in accordance with the SDS Information |requirements of the OSHA Hazard Communication Standard 29 CFR |1910.1200. GHS Full Text Phrases: ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | Grainger disclaimer.
The information contained in this SDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this 'SDS' shall be created or inferred by any statement in this 'SDS'. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this 'SDS'. The user is responsible for full compliance.