Product Categories See All
Track Order Status
MSDS Sheet 0066550Printer Friendly View
Permatex, Inc. 10 Columbus Blvd. Hartford, CT 06106 USA Telephone: 1-87-PERMATEX (877) 376-2839 Emergency: 800-255-3924 International Emergency: +01-813-248-0585 MATERIAL SAFETY DATA SHEET 1. Product Identification Product Name: THROTTLE BODY , CARB & CHOKE CLEANER 12 OZ Item No: 80279 Product Type: Aerosol cleaner 2. Composition/Information on Ingredients Component Weight% ACGIH; OSHA PEL TLV-TWA ACETONE 40-70 500 ppm 1000 ppm; 2400 67-64-1 mg/mÂ³ XYLENE 10-30 100 ppm 100 ppm; 435 mg/mÂ³ 1330-20-7 METHYL ACETATE <10 200 ppm 200 ppm; 610 mg/mÂ³ 79-20-9 CARBON DIOXIDE <10 5000 ppm 5000 ppm; 9000 124-38-9 mg/mÂ³ ETHYL BENZENE <5 100 ppm 100 ppm; 435 mg/mÂ³ 100-41-4 3. Hazards Identification Toxicity: May cause eye and skin irritation. Exposure to vapors or mist may result in irritation of the respiratory tract. Deliberately concentrating and inhaling the vapor may be harmful or fatal. Long term exposure to high concentrations may cause lung, liver or kidney damage. Reports have associated repeated and prolonged overexposure to solvents with permanent brain and nervous system damage (sometimes referred to as "solvent" or "painter's syndrome"). Symptoms include fatigue, concentration difficulties, anxiety, depression, rapid mood swings, and short-term memory loss. Primary Routes of Eye and skin contact, ingestion, inhalation Entry: Signs and Symptoms Excessive accidental exposure may cause headache, of Exposure: dizziness, nausea and in extreme cases, unconsciousness and respiratory depression. May cause redness to eyes and irritation to nasal passages. Component Weight % NTP ACGIH IARC Carcinogens ACETONE 40-70 Not known A4 - Not 67-64-1 Classifiable as a Human Carcinogen XYLENE 10-30 Male rat-no A4 - Not Group 3: 1330-20-7 evidence; Classifiable as Monograph 71, female rat-no a Human 1999; Monograph evidence; male Carcinogen 47, 1989 mice-no evidence; female mice-no evidence ETHYL BENZENE <5 Male rat-clear A3 Confirmed Group 2B 100-41-4 evidence; animal Monograph 77, female carcinogen with 2000 rat-some unknown evidence; male relevance to mice-some humans evidence; female mice-some evidence Medical Conditions Heart disease, respiratory disorders, liver and kidney Recognized as Being diseases, amenia, rhythm disorders of the heart. Aggravated by Preexisting eye, skin and respiratory disorders may be Exposure: aggravated by overexposure to this product. 4. First Aid Measures Ingestion: Do not induce vomiting. Slowly dilute with 1-2 glass of water or milk and seek medical attention. Never give anything by mouth to an unconscious person. Inhalation: Move to fresh air in case of accidental inhalation of vapours. Oxygen or artificial respiration if needed. Obtain medical attention. Skin contact: Wash off with soap and water. If skin irritation persists, call a physician. Eye Contact: In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get medical attention if irritation persists. 5. Fire Fighting Measures Flash Point Â°F(CÂ°): Extremely flammable aerosol based on flame projection test Recommended Carbon Dioxide, Dry Chemicals, Foam. Extinguishing Media: Special Firefighters should wear self-contained breathing Fire-Fighting apparatus. Keep containers cool. Use equipment or Procedures: shielding required to protect against bursting or venting of containers. Water spray may be ineffective on flames but should be used to keep fire-exposed containers cool. Hazardous Products Oxides of carbon of Combustion: Unusual Contents under pressure. Exposure to temperatures over Fire/Explosion 120 degrees F. may cause bursting or venting. Use Hazards: equipment of shielding to protect personnel from bursting containers. Lower Explosive Not determined. Limit: Upper Explosive Not determined. Limit: 6. Accidental Release Measures Spill Procedures: Eliminate all sources of ignition. Maintain good ventilation. Take up with an inert absorbent. Store in a closed waste container until disposal. 7. Handling and Storage Storage: Store away from heat, sparks or open flame. Do not store at temperatures above 100Â°F (38Â°C). Exposure to high temperatures may cause container to burst. Handling: Avoid prolonged skin contact. Do not inhale vapors. Do not puncture or incinerate container. Do not use near heat, sparks or open flame. Extinguish all flames, pilot lights and heaters. Turn off stoves, electric tools and appliances, and other sources of ignition. Intentionally concentrating and inhaling the vapor may be harmful or fatal. Use only in a well ventilated area. Vapors may accumulate readily and may ignite explosively. Wash thoroughly after handling. 8. Exposure Controls/Personal Protection Eyes: Safety glasses. Skin: Neoprene and nitrile gloves recommended. Ventilation: General; local exhaust ventilation as necessary to control any air contaminants to within their exposure limits (or to the lowest feasible levels when limits have not been established) during the use of this product. Respiratory An approved organic vapor respirator should be worn when Protection: exposures are expected to exceed the applicable limits. 9. Physical and Chemical Properties Appearance: Clear liquid Odor: Solvent Boiling Point: 100Â°F pH: Does not apply Solubility in Water: Nil Specific Gravity: 0.8 VOC(Wt.%): 19.5% Vapor Pressure: Not determined Vapor Density Heavier than air (Air=1): Evaporation Rate: Faster than ether 10. Stability and Reactivity Chemical Stability: Stable at normal conditions Hazardous Will not occur Polymerization: Incompatibilities: Strong oxidizers, Acids, Strong alkalis, Reducing agents Conditions to Avoid: Keep away from heat, sparks and open flame. - No smoking. Hazardous Products Oxides of carbon of Combustion: 11.Toxicological Information See Section 3 12. Ecological Information No data available 13.Disposal Considerations Recommended Method Disposal should be made in accordance with federal, of Disposal: state and local regulations. This container may be recycled in aerosol recycling centers. Before offering for recycling, empty the can by using the product according to the label. If recycling is not available, wrap the container and discard in the trash. US EPA Waste Number: D001 as per 40CFR 261.21 14. Transportation Information DOT (49CFR 172) Ground Transport (DOT) DOT Shipping Name: Consumer Commodity Hazard Class: ORM-D UN/ID Number: None IATA Proper Shipping Consumer Commodity (Not more than 1 liter) Name: Class or Division: Class 9 UN/ID Number ID 8000 IMDG Proper Shipping: Aerosols, Limited Quantity Hazard Class: Class 2.1 UN Number: UN 1950 Marine Pollutant: None 15. Regulatory Information SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313 Toxic Chemical. XYLENE, ETHYL BENZENE California WARNING: This product contains chemicals known the to Proposition 65: the State of California to cause cancer and birth defects or other reproductive harm. TSCA Inventory All components of this product are listed (or exempt) on Status: the EPA TSCA inventory. 16. Other Information Estimated NFPA HEALTH 2, FLAMMABILITY 3, REACTIVITY 0. Rating: Estimated HMIS HEALTH 2, FLAMMABILITY 3, PHYSICAL HAZARD 0 Classification: NFPA is a registered trademark of the National Fire Protection Assn. HMIS is a registered trademark of the National Paint and Coatings Assn. Prepared By: Denise Boyd, Revision October 16, Manager-Environmental, Health & Date: 2009 Safety Company: Permatex. Inc. 10 Columbus Revision 1 Blvd. Hartford, CT USA 06106 Number: Telephone No.: 1-87-Permatex (877) 376-2839
The information contained in this MSDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this 'MSDS' shall be created or inferred by any statement in this 'MSDS'. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this 'MSDS'. The user is responsible for full compliance.