Product Categories See All
Track Order Status
SDS Sheet 0065860Printer Friendly View
SECTION 1: IDENTIFICATION 1.1. Product Identifier Product Form: Product Name: 6586-0 A/C COIL CLEANER-6 PK CAS No: Synonyms: None 1.2. Intended Use of the Product Use of the substance/mixture: AC Coil Cleaner. 1.3. Name, Address, and Telephone of the Responsible Party Company American Jetway Corporation 34136 Myrtle Street Wayne, MI 48184-0126 Phone: 734-721-5930 1.4. Emergency Telephone Number Emergency |Chemtrec 1-800-424-9300, 734-721-5930 number | SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) Acute Toxicity|Category 3 - Oral | Acute toxicity|Category 3 - Inhalation | (Gases) | Skin |Category 1 corrosion/irri| tation | Serious eye |Category 1 damage/eye | irritation | Carcinogenicit|Category 1A y | Specific |Category 1 target organ | toxicity | (single | exposure) | Flammable |Category 1 aerosols | Gases under |Compressed Gas pressure | 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) |Skull and Crossbones |Health Hazard |Corrosion|Flame |Gas Cylinder | Signal Word (GHS-US) |DANGER Hazard Statements (GHS-US) |Toxic if swallowed |Toxic if inhaled |Causes severe skin burns and eye damage |May cause cancer |Causes damage to organs (Blood, Central Nervous |System, Eyes, Gastrointestinal Tract, Liver, |Reproductive System, and Skin). |Extremely flammable aerosol |Contains gas under pressure; may explode if heated Precautionary Statements |Prevention (GHS-US) |Obtain special instructions before use |Do not handle until all safety precautions have been |read and understood |Wear protective gloves/protective clothing/eye |protection/face protection |Wash face, hands and any exposed skin thoroughly |after handling |Do not eat, drink or smoke when using this product |Use only outdoors or in a well-ventilated area |Do not breathe dust/fume/gas/mist/vapors/spray |Keep away from heat/sparks/open flames/hot surfaces. |- No smoking |Do not spray on an open flame or other ignition |source |Pressurized container: Do not pierce or burn, even |after use |Response |Specific treatment (see first aid on this label) |Immediately call a POISON CENTER or |doctor/physician. |IF IN EYES: Rinse cautiously with water for several |minutes. Remove contact lenses, if present and easy |to do. Continue rinsing. |Immediately call a POISON CENTER or |doctor/physician. |IF ON SKIN (or hair): Remove/Take off immediately |all contaminated clothing. Rinse skin with |water/shower |Wash contaminated clothing before reuse |IF INHALED: Remove person to fresh air and keep |comfortable for breathing. |Immediately call a POISON CENTER or |doctor/physician.IF SWALLOWED: Immediately call a |POISON CENTER or doctor/physician |Rinse mouth |Do NOT induce vomiting |Storage |Store locked up |Store in a well-ventilated place. Keep container |tightly closed |Protect from sunlight. Do not expose to temperatures |exceeding 50 Â°C/122 Â°F |Disposal |Dispose of contents/container to an approved waste |disposal plant 2.3. Other Hazards Other Hazards Not Contributing to the Classification: Toxic to aquatic life with long lasting effects 0% of the mixture consists of ingredient(s) of unknown toxicity. 2.4. Unknown Acute Toxicity (GHS-US) SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name |Product identifier |% |Classification | | |(GHS-US) ISOPROPYL ALCOHOL |67-63-0 |20-30 | PROPANE/ISOBUTANE/N-BUTANE |68476-86-8 |20-30 | ETHANOL |64-17-5 |10-20 | METHANOL |67-56-1 |1-10 | MONOETHANOLAMINE |141-43-5 |0.1-1 | METHYL ISOBUTYL KETONE |108-10-1 |0.1-1 | SODIUM NITRITE |7632-00-0 |0.1-1 | SECTION 4: FIRST AID MEASURES 4.1. Description of First Aid Measures First-aid Measures General: First-aid Measures After Inhalation: Move to fresh air. If breathing is difficult, give oxygen. Artificial respiration and/or oxygen may be necessary. If breathing has stopped, contact emergency medical services immediately. First-aid Measures After Skin Contact: Wash off immediately with soap and plenty of water while removing all contaminated clothes and shoes. If skin irritation persists, call a physician. First-aid Measures After Eye Contact: Rinse immediately with plenty of water, also under the eyelids, for at least 15 minutes. Keep eye wide open while rinsing. Call a physician immediately. First-aid Measures After Ingestion: Rinse mouth. Do NOT induce vomiting. Never give anything by mouth to an unconscious person. Drink plenty of water. Call a physician or Poison Control Center immediately. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: Symptoms/Injuries After Inhalation: Irritating to respiratory system. Symptoms/Injuries After Skin Contact: Causes severe skin burns. Symptoms/Injuries After Eye Contact: Causes severe eye damage. Symptoms/Injuries After Ingestion: May be fatal if swallowed and enters airways. Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed Notes to physician: Treat symptomatically. SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: Water fog.Dry chemical. Carbon dioxide (CO2). Cool containers/tanks with water spray. Unsuitable Extinguishing Media: Keep away from heat and sources of ignition. Do not smoke. Cool containers / tanks with water spray. 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: Extremely flammable. Keep product and empty container away from heat and sources of ignition. Risk of ignition. In the event of fire and/or explosion do not breathe fumes. In the event of fire, cool tanks with water spray. Explosion Hazard: Hazardous Combustion Products: Vapors may form explosive mixtures with air. Sensitivity to Mechanical Impact: none. Sensitivity to Static Discharge: May be ignited by heat, sparks or flames. Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Firefighting Instructions: Protection During Firefighting: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: Avoid contact with eyes. Avoid breathing vapors or mists. Contents under pressure. Do not puncture or incinerate cans.Do no stick pin or any other sharp object into opening on top of can. Avoid skin contact. Use with adequate ventilation. Keep container away from heat,flames, and all other sources of ignition. Keep can away from all sources of electricity such as electric motors and batteries. Do not spray on hot surfaces. Other information: ELIMINATE all ignition sources (no smoking, flares, sparks or flames in immediate area). 6.1.1. For Non-emergency Personnel Protective Equipment: Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: Emergency Procedures: 6.2. Environmental Precautions Beware of vapors accumulating to form explosive concentrations. Vapors can accumulate in low areas. Prevent further leakage or spillage if safe to do so. Do not allow material to contaminate ground water system. Prevent product from entering drains. Do not flush into surface water or sanitary sewer system. Should not be released into the environment. 6.3. Methods and Material for Containment and Cleaning Up For Containment: Prevent further leakage or spillage if safe to do so. Absorb or cover with dry earth, sand or other non-combustible material and transfer to containers. Methods for Cleaning Up: Pick up and transfer to properly labeled containers. Soak up with inert absorbent material. Clean contaminated surface thoroughly. After cleaning, flush away traces with water. Take precautionary measures against static discharges. Sweep up and shovel into suitable containers for disposal. 6.4. Reference to Other Sections See heading 8, Exposure Controls and Personal Protection. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: Avoid contact with skin, eyes and clothing. Handle in accordance with good industrial hygiene and safety practice. Remove and wash contaminated clothing before re-use. Keep away from open flames, hot surfaces and sources of ignition. Take precautionary measures against static discharges. Do not breathe vapors/dust. Do not smoke. Hygiene Measures: Handle in accordance with good industrial hygiene and safety practice. 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Storage Conditions: Keep container tightly closed in a dry and well-ventilated place. Keep away from open flames, hot surfaces and sources of ignition. Keep in properly labeled containers. Keep out of the reach of children. Store locked up. Incompatible products: Strong acids, alkalis, or oxidizing agents. Aerosol Level: 2 7.3. Specific End Use(s) SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters Exposure Guidelines: Chemical Name ACGIH TLV OSHA PEL NIOSH IDLH ISOPROPYL ALCOHOL 67-63-0 STEL: 400 ppm TWA: 200 ppm TWA: 400 ppm TWA: 980 mg/m3 (vacated) TWA: 400 ppm (vacated) TWA: 980 mg/m3 (vacated) STEL: 500 ppm (vacated) STEL: 1225 mg/m3 IDLH: 2000 ppm TWA: 400 ppm TWA: 980 mg/m3 STEL: 500 ppm STEL: 1225 mg/m3 PROPANE/ISOBUTANE/N-BUTANE 68476-86-8 74-98-6: TWA: 1000 ppm 106-97-8: STEL: 1000 ppm 75-28-5: STEL: 1000 ppm 74-98-6:TWA: 1000 ppm TWA: 1800 mg/m3 (vacated) TWA: 1000 ppm (vacated) TWA: 1800 mg/m3 106-97-8: (vacated) TWA: 800 ppm (vacated) TWA: 1900 mg/m3 74-98-6:IDLH: 2100 ppm TWA: 1000 ppm TWA: 1800 mg/m3 106-97-8:TWA: 800 ppm TWA: 1900 mg/m3 75-28-5:TWA: 800 ppm TWA: 1900 mg/m3 ETHANOL 64-17-5 STEL: 1000 ppm TWA: 1000 ppm TWA: 1900 mg/m3 (vacated) TWA: 1000 ppm (vacated) TWA: 1900 mg/m3 IDLH: 3300 ppm TWA: 1000 ppm TWA: 1900 mg/m3 METHANOL 67-56-1 STEL: 250 ppm TWA: 200 ppm Skin - potential significant contribution to overall exposure by the cutaneous route TWA: 200 ppm TWA: 260 mg/m3 (vacated) TWA: 200 ppm (vacated) TWA: 260 mg/m3 (vacated) STEL: 250 ppm (vacated) STEL: 325 mg/m3 (vacated) S* IDLH: 6000 ppm TWA: 200 ppm TWA: 260 mg/m3 STEL: 250 ppm STEL: 325 mg/m3 MONOETHANOLAMINE 141-43-5 STEL: 6 ppm TWA: 3 ppm TWA: 3 ppm TWA: 6 mg/m3 (vacated) TWA: 3 ppm (vacated) TWA: 8 mg/m3 (vacated) STEL: 6 ppm (vacated) STEL: 15 mg/m3 IDLH: 30 ppm TWA: 3 ppm TWA: 8 mg/m3 STEL: 6 ppm STEL: 15 mg/m3 METHYL ISOBUTYL KETONE 108-10-1 STEL: 75 ppm TWA: 20 ppm TWA: 100 ppm TWA: 410 mg/m3 (vacated) TWA: 50 ppm (vacated) TWA: 205 mg/m3 (vacated) STEL: 75 ppm (vacated) STEL: 300 mg/m3 IDLH: 500 ppm TWA: 50 ppm TWA: 205 mg/m3 STEL: 75 ppm STEL: 300 mg/m3 Other Exposure Guidelines: Vacated limits revoked by the Court of Appeals decision in AFL-CIO v. OSHA, 965 F.2d 962 (11th Cir., 1992). 8.2. Exposure Controls Appropriate Engineering |Showers Controls |Eyewash stations |Ventilation systems. Personal Protective Equipment| Materials for Protective | Clothing | Hand Protection | Eye Protection |Safety glasses with side-shields. Skin and Body Protection |Chemical resistant apron. Protective gloves. Respiratory Protection |If exposure limits are exceeded or irritation is |experienced, NIOSH/MSHA approved respiratory |protection should be worn. Positive-pressure |supplied air respirators may be required for high |airborne contaminant concentrations. Respiratory |protection must be provided in accordance with |current local regulations. Thermal Hazard Protection | SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State |Aerosol Appearance |Clear Odor |Solvent Odor Threshold |No information available pH |11.5 Relative Evaporation Rate |No information available (butylacetate=1) | Melting Point |No information available Freezing Point |No information available Boiling Point |No information available Flash Point |-104.4 Â°C / -156 Â°F, Based on propellant Auto-ignition Temperature |No information available Decomposition Temperature |No information available Flammability (solid, gas) |No information available Vapor Pressure |No information available Relative Vapor Density at 20 Â°C |No information available Relative Density | Specific Gravity |.833 Solubility |Practically insoluble Partition coefficient: |No information available n-octanol/water | Viscosity |No information available Lower Flammable Limit |No information available Upper Flammable Limit |No information available 9.2. Other Information VOC Content(%): 67.44 SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity No data available. 10.2 Chemical Stability Stable under recommended storage conditions. 10.3 Possibility of Hazardous Reactions None under normal processing. 10.4 Conditions to Avoid Extremes of temperature and direct sunlight. 10.5 Incompatible Materials Strong acids, alkalis, or oxidizing agents. 10.6 Hazardous Decomposition Products None known based on information supplied. SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: Neurological effects Intentional misuse by deliberately concentrating and inhaling contents may be harmful or fatal. Skin Corrosion/Irritation: Causes severe burns. Serious Eye Damage/Irritation: Risk of serious damage to eyes. Respiratory or Skin Sensitization: None known. Germ Cell Mutagenicity: None known. Carcinogenicity: The table below indicates whether each agency has evaluated a listed ingredient as a carcinogen. Reproductive Toxicity: This product does not contain any known or suspected reproductive hazards. Specific Target Organ Toxicity (Single Exposure): Causes damage to central nervous system ,eyes, gastrointestinal tract, kidney, liver, respiratory system. and skin. Blood, Central nervous system, Eyes, Gastrointestinal tract (GI), Liver, Reproductive system, Respiratory system, Skin. Specific Target Organ Toxicity (Repeated Exposure): No information available. Aspiration Hazard: Not applicable. Symptoms/Injuries After Inhalation: Vapors may irritate throat and respiratory system. May cause drownsiness and dizziness based on components. May cause irritation of respiratory tract. Symptoms of overexposure are dizziness, headache, tiredness, nausea, unconsciousness, cessation of breathing. Intentional misuse by deliberately concentrating and inhaling contents may be harmful or fatal. Symptoms of overexposure may be headache, dizziness, tiredness, nausea and vomiting. Irritating to respiratory system. Symptoms/Injuries After Skin Contact: Contact causes severe skin irritation and possible burns. Avoid contact with skin. Symptoms/Injuries After Eye Contact: Irritating to eyes. Corrosive to the eyes and may cause severe damage including blindness. Avoid contact with eyes. Symptoms/Injuries After Ingestion: Very toxic if swallowed. May be harmful or fatal if ingested. Chronic Symptoms: SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity Ecotoxicity: Chemical Name Toxicity to algae Toxicity to fish Toxicity to microorganisms Toxicity to daphnia and other aquatic invertebrates ISOPROPYL ALCOHOL 67-63-0 1000 mg/L EC50 Desmodesmus subspicatus 96h 1000 mg/L EC50 Desmodesmus subspicatus 72h 11130 mg/L LC50 Pimephales promelas 96h static 9640 mg/L LC50 Pimephales promelas 96h flow-through 1400000 ?g/L LC50 Lepomis macrochirus 96h - 13299 mg/L EC50 Daphnia magna 48h ETHANOL 64-17-5 - 12.0 - 16.0 mL/L LC50 Oncorhynchus mykiss 96h static 13400 - 15100 mg/L LC50 Pimephales promelas 96h flow-through 100 mg/L LC50 Pimephales promelas 96h static - 9268 - 14221 mg/L LC50 Daphnia magna 48h 2 mg/L EC50 Daphnia magna 48h Static METHANOL 67-56-1 - 13500 - 17600 mg/L LC50 Lepomis macrochirus 96h flow-through 18 - 20 mL/L LC50 Oncorhynchusmykiss 96h static 19500 - 20700 mg/L LC50 Oncorhynchus mykiss 96h flow through 28200 mg/L LC50 Pimephales promelas 96h flow-through 100mg/L LC50 Pimephales promelas 96h static - - MONOETHANOLAMINE 141-43-5 15 mg/L EC50 Desmodesmus subspicatus 72h 114 - 196 mg/L LC50 Oncorhynchus mykiss 96h static 300 - 1000 mg/L LC50 Lepomis macrochirus 96h static 227 mg/L LC50 Pimephales promelas 96h flow-through 3684 mg/L LC50 Brachydanio rerio 96h static 200 mg/L LC50 Oncorhynchus mykiss 96h flow-through - 65 mg/L EC50 Daphnia magna 48h METHYL ISOBUTYL KETONE 108-10-1 400 mg/L EC50 Pseudokirchneriella subcapitata 96h 496 - 514 mg/L LC50 Pimephales promelas 96h flow-through - 170 mg/L EC50 Daphnia magna 48h SODIUM NITRITE 7632-00-0 - 0.092 - 0.13 mg/L LC50 Oncorhynchus mykiss 96h flow-through 0.4 - 0.6 mg/L LC50 Oncorhynchus mykiss 96h semi-static 0.65 - 1 mg/L LC50 Oncorhynchus mykiss 96h static 0.19 mg/L LC50 Oncorhynchus mykiss 96h flow-through 2.3 mg/L LC50 Pimephales promelas 96h flow-through 20 mg/L LC50 Pimephales promelas 96h static - - 12.2. Persistence and Degradability No information available. 12.3. Bioaccumulative Potential No information available. Chemical Name log Pow ISOPROPYL ALCOHOL 67-63-0 0.05 PROPANE/ISOBUTANE/N-BUTANE 68476-86-8 2.8 ETHANOL 64-17-5 -0.32 METHANOL 67-56-1 -0.77 MONOETHANOLAMINE 141-43-5 -1.91 METHYL ISOBUTYL KETONE 108-10-1 1.19 SODIUM NITRITE 7632-00-0 -3.7 12.4. Mobility in Soil 12.5. Other Adverse Effects No information available. SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: It must undergo special treatment, e.g. at suitable disposal site, to comply with local regulations. Additional Information: Contaminated packaging: Do not re-use empty containers. SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name |CONSUMER COMMODITY ORM-D or LIMITED QUANTITY Hazard Class | |<PICTOGRAM PHRASE> Identification Number| | Label Codes | | ERG Number | 14.2 In Accordance with IMDG Proper Shipping Name |AEROSOLS, FLAMMABLE Hazard Class |2.1 Identification Number|UN1950 Label Codes | |<PICTOGRAM PHRASE> ntification Of The | | Substance/m | | EmS-No. (Fire) | | EmS-No. (Spillage) | | 14.3 In Accordance with IATA Proper Shipping Name |AEROSOLS, FLAMMABLE Identification Number|UN1950 |<PICTOGRAM PHRASE> Hazard Class |2.1 | Label Codes | | ntification Of The | | Substance/m | | ERG Code (IATA) | SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations <COMPONENT> SARA 313: Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product contains a chemical or chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372: Chemical Name CAS-No Weight %* SARA 313 - Threshold Values % ISOPROPYL ALCOHOL - 67 63-0 67-63-0 20-30 1.0 METHANOL - 67-56-1 67-56-1 1-10 1.0 METHYL ISOBUTYL KETONE - 108-10-1 108-10-1 0.1-1 1.0 SODIUM NITRITE - 7632-00-0 7632-00-0 0.1-1 1.0 Clean Water Act: This product contains the following substances which are regulated pollutants pursuant to the Clean Water Act (40 CFR 122.21 and 40 CFR 122.42): Chemical Name CWA - Reportable Quantities CWA - Toxic Pollutants CWA - Priority Pollutants CWA - Hazardous Substances SODIUM NITRITE 7632-00-0 100 lb X CERCLA: This material, as supplied, contains one or more substances regulated as a hazardous substance under the Comprehensive Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302): Chemical Name Hazardous Substances RQs Extremely Hazardous Substances RQs RQ METHANOL 67-56-1 5000 lb RQ 5000 lb final RQ RQ 2270 kg final RQ METHYL ISOBUTYL KETONE 108-10-1 5000 lb RQ 5000 lb final RQ RQ 2270 kg final RQ SODIUM NITRITE 7632-00-0 100 lb RQ 100 lb final RQ RQ 45.4 kg final RQ SARA Section 311/312 Hazard Classes |Acute Health Hazard |Yes |Chronic Health Hazard |Yes |Fire Hazard |Yes |Sudden Release of Pressure Hazard |Yes |Reactive Hazard |no Toxic Substances Control Act (TSCA) |Chemical Name |TSCA | |ISOPROPYL ALCOHOL |X | |PROPANE/ISOBUTA NE/N-BUTANE |X | |ETHANOL |X | |METHANOL |X | |MONOETHANOLAMINE |X | |METHYL ISOBUTYL KETONE |X | |SODIUM NITRITE |X | 15.2 US State Regulations <COMPONENT> California Proposition 65: This product contains the following Proposition 65 chemicals: Chemical Name California Prop. 65 ETHANOL - 64-17-5 Carcinogen Developmental METHANOL - 67-56-1 Carcinogen METHYL ISOBUTYL KETONE - 108-10-1 Carcinogen Developmental U.S. State Right-to-Know Regulations: Chemical Name New Jersey Massachusetts Pennsylvania ISOPROPYL ALCOHOL 67-63-0 X X X ETHANOL 64-17-5 X X X METHANOL 67-56-1 X X X MONOETHANOLAMINE 141-43-5 X X X METHYL ISOBUTYL KETONE 108-10-1 X X X SODIUM NITRITE 7632-00-0 X X X EPA Pesticide Registration Number: Not applicable. SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date |07-May-2015 Other |This document has been prepared in accordance with the SDS Information |requirements of the OSHA Hazard Communication Standard 29 CFR |1910.1200. GHS Full Text Phrases: ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | Grainger disclaimer.
The information contained in this SDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this 'SDS' shall be created or inferred by any statement in this 'SDS'. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this 'SDS'. The user is responsible for full compliance.