Product Categories See All
Track Order Status
SDS Sheet 0065760Printer Friendly View
SECTION 1: IDENTIFICATION 1.1. Product Identifier Product Form: Product Name: FOOD GRADE SILICONE AEROSOL CAS No: Synonyms: JET-LUBEÂ® FOOD GRADE SILICONE AEROSOL 1.2. Intended Use of the Product Use of the substance/mixture: Lubricants, Greases and Release Products, metal surface treatment product 1.3. Name, Address, and Telephone of the Responsible Party Company Jet-Lube, Inc. 4849 Homestead Rd. Suite 232 Houston, Texas 77028 Phone: 713-670-5700 1.4. Emergency Telephone Number Emergency |CHEMTREC: +1-703-527-3887 (INTERNATIONAL) number |1-800-424-9300 (NORTH AMERICA) SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) Aspiration |Category 1 Toxicity | Flammable |Category 1 aerosols | Gases under |Compressed gas pressure | 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) |Health Hazard |Flame |Gas Cylinder Signal Word (GHS-US) |Danger Hazard Statements (GHS-US) |. Causes mild skin irritation |. May be fatal if swallowed and enters airway |. Extremely flammable aerosol |. Contains gas under pressure; may explode if heated Precautionary Statements |Prevention: (GHS-US) |. Keep away from heat/sparks/open flames/hot |surfaces - No smoking. |. Do not spray on an open flame or other ignition |source |. Pressurized container: Do not pierce or burn, even |after use. | |General Advice |. None | |Ingestion |. IF SWALLOWED: Immediately call a POISON CENTER or |doctor/physician. |. Do NOT induce vomiting. | |Storage |. Store locked up. |. Protect from sunlight. Do not expose to |temperatures exceeding 50 Â°C/122 Â°F |. Protect from sunlight. Store in a well-ventilated |place | |Disposal |. Dispose of contents/container to an approved waste |disposal plant. 2.3. Other Hazards Other Hazards Not Contributing to the Classification: Not applicable. 2.4. Unknown Acute Toxicity (GHS-US) 39.5% of the mixture consists of ingredient(s) of unknown toxicity. SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name 4.1. Description of First Aid Measures First-aid Measures General: First-aid Measures After Inhalation: Move to fresh air. If breathing is difficult, give oxygen. If symptoms persist, call a physician. First-aid Measures After Skin Contact: Wash off immediately with plenty of water. If symptoms persist, call a physician. First-aid Measures After Eye Contact: Rinse thoroughly with plenty of water, also under the eyelids. Keep eye wide open while rinsing. If symptoms persist, call a physician. First-aid Measures After Ingestion: Do NOT induce vomiting. Rinse mouth. Drink plenty of water. If symptoms persist, call a physician. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: No information available. Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed Notes to Physician: Treat symptomatically. SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: Dry chemical. Carbon dioxide (CO 2 ). Water spray. Alcohol-resistant foam. Unsuitable Extinguishing Media: No information available. 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: Containers may explode when heated. Explosion Hazard: Sensitivity to Mechanical Impact None. Sensitivity to Static Discharge Yes. Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Firefighting Instructions: Protection During Firefighting: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: Remove all sources of ignition. Evacuate personnel to safe areas. Ensure adequate ventilation. Use personal protective equipment. Keep people away from and upwind of spill/leak. Pay attention to flashback. Take precautionary measures against static discharges. 6.1.1. For Non-emergency Personnel Protective Equipment: Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: Emergency Procedures: 6.2. Environmental Precautions Prevent further leakage or spillage if safe to do so. Prevent product from entering drains. Do not flush into surface water or sanitary sewer system. See Section 12 for additional Ecological Information. 6.3. Methods and Material for Containment and Cleaning Up For Containment: Prevent further leakage or spillage if safe to do so. Methods for Cleaning Up: Soak up with inert absorbent material. Pick up and transfer to properly labeled containers. Clean contaminated surface thoroughly. 6.4. Reference to Other Sections See heading 8, Exposure Controls and Personal Protection. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: Ensure adequate ventilation. Keep away from open flames, hot surfaces and sources of ignition. Take precautionary measures against static discharges. Use only in an area containing flame proof equipment. To avoid ignition of vapors by static electricity discharge, all metal parts of the equipment must be grounded. Use only in area provided with appropriate exhaust ventilation. Do not breathe vapors or spray mist. Do not eat, drink or smoke when using this product. Hygiene Measures: Handle in accordance with good industrial hygiene and safety practice. 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Storage Conditions: Keep in properly labeled containers. Keep away from heat and sources of ignition. Protect from light. Keep containers tightly closed in a dry, cool and well-ventilated place. 7.3. Specific End Use(s) SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters Chemical Name ACGIH TLV OSHA PEL NIOSH IDLH n-Hexane 110-54-3 STEL: 1000 ppm other than n-Hexane TWA: 50 ppm S* TWA: 500 ppm TWA: 1800 mg/m3 (vacated) TWA: 50 ppm (vacated) TWA: 180 mg/m3 (vacated) STEL: 1000 ppm (vacated) STEL: 3600 mg/m3 IDLH: 1100 ppm Ceiling: 510 ppm 15 min Ceiling: 1800 mg/m3 15 min TWA: 50 ppm TWA: 180 mg/m3 8.2. Exposure Controls Appropriate Engineering |Showers Controls |Eyewash stations |Ventilation systems Personal Protective Equipment| Materials for Protective | Clothing | Hand Protection | Eye Protection |Safety glasses with side-shields. Skin and Body Protection |Long sleeved clothing. Impervious clothing. |Impervious gloves. Respiratory Protection |No protective equipment is needed under normal use |conditions. If exposure limits are exceeded or |irritation is experienced, NIOSH/MSHA approved |respiratory protection should be worn. Thermal Hazard Protection | SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State |Liquid, Aerosol Appearance |Clear Odor |Petroleum solvent Odor Threshold |No information available pH |Neutral Relative Evaporation Rate | (butylacetate=1) | Melting Point |No data available Freezing Point |No data available Boiling Point |> 60 Â°C / 140 Â°F Flash Point |< -18 Â°C / 0 Â°F Auto-ignition Temperature |No data available Decomposition Temperature |No data available Flammability (solid, gas) |No data available Vapor Pressure |No data available Relative Vapor Density at 20 Â°C |No data available Relative Density | Specific Gravity |0.666 Solubility |Insoluble Partition coefficient: |No data available n-octanol/water | Viscosity |~1 (@ 40Â°C) Lower Flammable Limit |No data available Upper Flammable Limit |No data available 9.2. Other Information VOC Content (%): No data available SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity No data available. 10.2 Chemical Stability Stable under recommended storage conditions. 10.3 Possibility of Hazardous Reactions None under normal processing. 10.4 Conditions to Avoid Heat, flames and sparks. Do not expose to extreme temperatures. 10.5 Incompatible Materials Strong oxidizing agents. 10.6 Hazardous Decomposition Products Carbon oxides. SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: 39.5% of the mixture consists of ingredient(s) of unknown toxicity. Skin Corrosion/Irritation: Serious Eye Damage/Irritation: Respiratory or Skin Sensitization: No information available. Germ Cell Mutagenicity: No information available. Carcinogenicity: Contains no ingredients above reportable quantities listed as a carcinogen. Reproductive Toxicity: No information available. Specific Target Organ Toxicity (Single Exposure): No information available. Specific Target Organ Toxicity (Repeated Exposure): No information available. Aspiration Hazard: No information available. Symptoms/Injuries After Inhalation: May cause irritation of respiratory tract. Inhalation of high vapor concentrations may cause symptoms like headache, dizziness, tiredness, nausea and vomiting. Symptoms/Injuries After Skin Contact: Substance may cause slight skin irritation. Prolonged skin contact may defat the skin and produce dermatitis. Symptoms/Injuries After Eye Contact: May cause slight irritation. Symptoms/Injuries After Ingestion: Low order of toxicity based on components. Potential for aspiration if swallowed. Aspiration may cause pulmonary edema and pneumonitis. May be fatal if swallowed and enters airways. Chronic Symptoms: SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity Chemical Name Toxicity to Algae Toxicity to Fish Toxicity to Microorganisms Daphnia Magna (Water Flea) Naphtha, petroleum, hydrotreated light 64742-49-0 LC50 96 h: = 2.6 mg/L (Chaetogammarus marinus) n-Hexane 110-54-3 LC50 96 h: 2.1-2.98 mg/L flow-through (Pimephales promelas) 12.2. Persistence and Degradability No information available. 12.3. Bioaccumulative Potential No information available. 12.4. Mobility in Soil 12.5. Other Adverse Effects No information available. SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: Waste Disposal Methods Dispose of in accordance with federal, state, and local regulations. Contaminated Packaging Do not re-use empty containers. Additional Information: SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name |Aerosols Hazard Class |2.1 |<PICTOGRAM PHRASE> Identification Number|UN1950 | Label Codes | | ERG Number | 14.2 In Accordance with IMDG Proper Shipping Name |Aerosols Hazard Class |2 Identification Number|UN1950 Label Codes | |<PICTOGRAM PHRASE> ntification Of The | | Substance/m | | EmS-No. (Fire) |D | EmS-No. (Spillage) |U | 14.3 In Accordance with IATA Proper Shipping Name |Aerosols, flammable Identification Number|UN1950 |<PICTOGRAM PHRASE> Hazard Class |2.1 | Label Codes | | ntification Of The | | Substance/m | | ERG Code (IATA) |10L SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product contains a chemical or chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372: Chemical Name CAS-No Weight % SARA 313 - Threshold Values % n-Hexane 110-54-3 1.8 1.0 SARA Section 311/312 Hazard Classes |Acute Health Hazard: Yes |Chronic Health Hazard: No |Fire Hazard: Yes |Sudden Release of Pressure Hazard: Yes |Reactive Hazard: No Toxic Substances Control Act (TSCA) |Complies 15.2 US State Regulations <COMPONENT> California Proposition 65: This product does not contain any Proposition 65 chemicals. U.S. State Right-to-Know Regulations: "X" designates that the ingredients are listed on the state right to know list. Chemical Name New Jersey Massachusetts Pennsylvania Illinois Rhode Island Hydrochlorofluorocarbon 152a X X X X X n-Hexane X X X X X SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date |03-Dec-2014 Other |This document has been prepared in accordance with the SDS Information |requirements of the OSHA Hazard Communication Standard 29 CFR |1910.1200. GHS Full Text Phrases: ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | Grainger disclaimer.
The information contained in this SDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this 'SDS' shall be created or inferred by any statement in this 'SDS'. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this 'SDS'. The user is responsible for full compliance.