Product Categories See All
Track Order Status
SDS Sheet 0065361Printer Friendly View
SECTION 1: IDENTIFICATION 1.1. Product Identifier Product Form: Product Name: 6536 N/C BRAKE CLNR-12 PK CAS No: Synonyms: None 1.2. Intended Use of the Product Use of the substance/mixture: Brake Cleaner. 1.3. Name, Address, and Telephone of the Responsible Party Company American Jetway Corporation 34136 Myrtle Street Wayne, MI 48184-0126 Phone: 1.4. Emergency Telephone Number Emergency | Chemtrec 1-800-262-8200 ID 1195, 734-721-5930 number | SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) Skin |Category 2 corrosion/irri| tation | Serious eye |Category 2A damage/eye | irritation | Specific |Category 3 target organ | toxicity | (single | exposure) | Aspiration |Category 1 toxicity | Flammable |Category 1 aerosols | Gases under |Compressed Gas pressure | 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) |Exclamation Mark |Health Hazard |Flame |Gas Cylinder Signal Word (GHS-US) |DANGER Hazard Statements (GHS-US) |Causes skin irritation |Causes serious eye irritation |May cause drowsiness or dizziness |May be fatal if swallowed and enters airways |Extremely flammable aerosol |Contains gas under pressure; may explode if heated Precautionary Statements |Prevention (GHS-US) |Wash face, hands and any exposed skin thoroughly |after handling |Wear protective gloves/protective clothing/eye |protection/face protection |Avoid breathing dust/fume/gas/mist/vapors/spray |Use only outdoors or in a well-ventilated area |Keep away from heat/sparks/open flames/hot surfaces. |- No smoking |Do not spray on an open flame or other ignition |source |Pressurized container: Do not pierce or burn, even |after use |Response |Specific treatment (see first aid on this label) |IF IN EYES: Rinse cautiously with water for several |minutes. Remove contact lenses, if present and easy |to do. Continue rinsing. |If eye irritation persists: Get medical |advice/attention |IF ON SKIN: Wash with plenty of soap and water. |Take off contaminated clothing and wash before reuse | |If skin irritation occurs: Get medical |advice/attention |IF INHALED: Remove person to fresh air and keep |comfortable for breathing. |Call a POISON CENTER or doctor/physician if you feel |unwell |IF SWALLOWED: Immediately call a POISON CENTER or |doctor/physician |Do NOT induce vomiting |Storage |Store locked up |Store in a well-ventilated place. Keep container |tightly closed |Protect from sunlight. Do not expose to temperatures |exceeding 50 Â°C/122 Â°F |Disposal |Dispose of contents/container to an approved waste |disposal plant 2.3. Other Hazards Other Hazards Not Contributing to the Classification: 1E-05% of the mixture consists of ingredient(s) of unknown toxicity. 2.4. Unknown Acute Toxicity (GHS-US) SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name |Product identifier |% |Classification | | |(GHS-US) ACETONE |67-64-1 |40-50 | HEPTANE |64742-49-0 |40-50 | CARBON DIOXIDE |124-38-9 |1-10 | | | | | | | SECTION 4: FIRST AID MEASURES 4.1. Description of First Aid Measures First-aid Measures General: First-aid Measures After Inhalation: Move to fresh air. If breathing is difficult, give oxygen. Artificial respiration and/or oxygen may be necessary. If breathing has stopped, contact emergency medical services immediately. First-aid Measures After Skin Contact: Wash off immediately with soap and plenty of water while removing all contaminated clothes and shoes. If skin irritation persists, call a physician. First-aid Measures After Eye Contact: Rinse immediately with plenty of water, also under the eyelids, for at least 15 minutes. Keep eye wide open while rinsing. If symptoms persist, call a physician. First-aid Measures After Ingestion: Rinse mouth. Do NOT induce vomiting. Never give anything by mouth to an unconscious person. Drink plenty of water. Call a physician or Poison Control Center immediately. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: Symptoms/Injuries After Inhalation: May cause respiratory irritation. Symptoms/Injuries After Skin Contact: Causes skin irritation. Symptoms/Injuries After Eye Contact: Causes eye irritation. Symptoms/Injuries After Ingestion: May be harmful if swallowed. Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed Notes to physician: Treat symptomatically. SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: Use extinguishing measures that are appropriate to local circumstances and the surrounding environment. Unsuitable Extinguishing Media: Decomposition by contact with water may generate vapors which can be ignited by heat or open flame. 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: Extremely flammable. Explosion Hazard: Explosion Data Sensitivity to Mechanical Impact none. Sensitivity to Static Discharge Yes. Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Firefighting Instructions: Protection During Firefighting: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: Absorb with sand ,clay, or other suitable material. Hard surfaces may be mopped with water. Remove all sources of ignition. Avoid contact with skin, eyes and clothing. Ensure adequate ventilation. Avoid dust formation. Keep people away from and upwind of spill/leak. Take precautionary measures against static discharges. 6.1.1. For Non-emergency Personnel Protective Equipment: Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: Emergency Procedures: 6.2. Environmental Precautions Do not flush into surface water or sanitary sewer system. Beware of vapors accumulating to form explosive concentrations. Vapors can accumulate in low areas. Prevent further leakage or spillage if safe to do so. Do not allow material to contaminate ground water system. Prevent product from entering drains. 6.3. Methods and Material for Containment and Cleaning Up For Containment: Absorb or cover with dry earth, sand or other non-combustible material and transfer to containers. Prevent further leakage or spillage if safe to do so. Methods for Cleaning Up: Soak up with inert absorbent material. Pick up and transfer to properly labeled containers. Clean contaminated surface thoroughly. After cleaning, flush away traces with water. Take precautionary measures against static discharges. 6.4. Reference to Other Sections See heading 8, Exposure Controls and Personal Protection. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: Avoid contact with eyes. Avoid breathing vapors or mists. Contents under pressure. Do not puncture or incinerate cans. Do not stick pin or any other sharp object into opening on top of can. Hygiene Measures: Handle in accordance with good industrial hygiene and safety practice. 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Storage Conditions: Keep away from heat and sources of ignition. Keep container tightly closed in a dry and well-ventilated place. Keep in properly labeled containers. Keep out of the reach of children. Store locked up. Incompatible products: Strong acids, alkalis, or oxidizing agents. Aerosol Level: 3 7.3. Specific End Use(s) SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters Exposure Guidelines Chemical Name ACGIH TLV OSHA PEL NIOSH IDLH ACETONE 67-64-1 STEL: 750 ppm TWA: 500 ppm TWA: 1000 ppm TWA: 2400 mg/m3 (vacated) TWA: 750 ppm (vacated) TWA: 1800 mg/m3 (vacated) STEL: 2400 mg/m3 The acetone STEL does not apply to the cellulose acetate fiber industry. It is in effect for all other sectors (vacated) STEL: 1000 ppm IDLH: 2500 ppm TWA: 250 ppm TWA: 590 mg/m3 HEPTANE 64742-49-0 TLV: 400 ppm STEL: 500 ppm TWA: 500 ppm - CARBON DIOXIDE 124-38-9 STEL: 30000 ppm TWA: 5000 ppm TWA: 5000 ppm TWA: 9000 mg/m3 (vacated) TWA: 10000 ppm (vacated) TWA: 18000 mg/m3 (vacated) STEL: 30000 ppm (vacated) STEL: 54000 mg/m3 IDLH: 40000 ppm TWA: 5000 ppm TWA: 9000 mg/m3 STEL: 30000 ppm STEL: 54000 mg/m3 Other Exposure Guidelines: Vacated limits revoked by the Court of Appeals decision in AFL-CIO v. OSHA, 965 F.2d 962 (11th Cir., 1992). 8.2. Exposure Controls Appropriate Engineering |Showers Controls |Eyewash stations |Ventilation systems. Personal Protective Equipment| Materials for Protective | Clothing | Hand Protection | Eye Protection |Safety glasses with side-shields. Skin and Body Protection |Chemical resistant apron. Protective gloves. Respiratory Protection |If exposure limits are exceeded or irritation is |experienced, NIOSH/MSHA approved respiratory |protection should be worn. Positive-pressure |supplied air respirators may be required for high |airborne contaminant concentrations. Respiratory |protection must be provided in accordance with |current local regulations. Thermal Hazard Protection | SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State |Aerosol Appearance |Clear Odor |Solvent Odor Threshold |No information available pH |No information available Relative Evaporation Rate |No information available (butylacetate=1) | Melting Point |No information available Freezing Point |No information available Boiling Point |No information available Flash Point |-20 Â°C / -4 Â°F, Based on lowest flashpoint of |the products constituent. Auto-ignition Temperature |No information available Decomposition Temperature |No information available Flammability (solid, gas) |No information available Vapor Pressure |No information available Relative Vapor Density at 20 Â°C | Relative Density | Specific Gravity |0.751 Solubility |Practically insoluble Partition coefficient: |No information available n-octanol/water | Viscosity |No information available Lower Flammable Limit |No information available Upper Flammable Limit |No information available 9.2. Other Information VOC Content(%): 43.74 SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity No data available. 10.2 Chemical Stability Stable under recommended storage conditions. 10.3 Possibility of Hazardous Reactions None under normal processing. 10.4 Conditions to Avoid Extremes of temperature and direct sunlight. 10.5 Incompatible Materials Strong acids, alkalis, or oxidizing agents. 10.6 Hazardous Decomposition Products None known based on information supplied. SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: Skin Corrosion/Irritation: Irritating to eyes, respiratory system and skin. Serious Eye Damage/Irritation: Irritating to eyes. Respiratory or Skin Sensitization: None known. Germ Cell Mutagenicity: None known. Carcinogenicity: There are no known carcinogenic chemicals in this product. Reproductive Toxicity: This product does not contain any known or suspected reproductive hazards. Specific Target Organ Toxicity (Single Exposure): May cause respiratory irritation. May cause drowsiness and dizziness. Target Organ Effects: Central nervous system, Central Vascular System (CVS), Eyes, Respiratory system, Skin. Neurological effects: Intentional misuse by deliberately concentrating and inhaling contents may be harmful or fatal. Specific Target Organ Toxicity (Repeated Exposure): None under normal use conditions. Aspiration Hazard: May be fatal if swallowed and enters airways. Symptoms/Injuries After Inhalation: Vapors may irritate throat and respiratory system. May cause drownsiness and dizziness based on components. May cause irritation of respiratory tract. Avoid breathing vapors or mists. Inhalation may cause nose, throat , and respiratory tract irritation. Symptoms/Injuries After Skin Contact: Irritating to skin. Repeated exposure may cause skin dryness or cracking. Prolonged skin contact may defat the skin and produce dermatitis. Avoid contact with skin. Symptoms/Injuries After Eye Contact: Irritating to eyes. Avoid contact with eyes. Symptoms/Injuries After Ingestion: May be harmful or fatal if swallowed. Chronic Symptoms: SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity Chemical Name Toxicity to algae Toxicity to fish Toxicity to microorganisms Toxicity to daphnia and other aquatic invertebrates ACETONE 67-64-1 - 4.74 - 6.33 mL/L LC50 Oncorhynchus mykiss 96h 6210 - 8120 mg/L LC50 Pimephales promelas 96h static 8300 mg/L LC50 Lepomis macrochirus 96h - 10294 - 17704 mg/L EC50 Daphnia magna 48h Static 12600 - 12700 mg/L EC50 Daphnia magna 48h 12.2. Persistence and Degradability No information available. 12.3. Bioaccumulative Potential No information available. Chemical Name log Pow ACETONE 67-64-1 -0.24 12.4. Mobility in Soil 12.5. Other Adverse Effects No information available. SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: Waste Disposal Methods: This material, as supplied, is a hazardous waste according to federal regulations (40 CFR 261). Contaminated packaging: Do not re-use empty containers. Additional Information: SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name |CONSUMER COMMODITY ORM-D or LIMITED QUANTITY Hazard Class | |<PICTOGRAM PHRASE> Identification Number| | Label Codes | | ERG Number | 14.2 In Accordance with IMDG Proper Shipping Name |AEROSOLS Hazard Class |2.1 Identification Number|UN1950 Label Codes | |<PICTOGRAM PHRASE> ntification Of The | | Substance/m | | EmS-No. (Fire) | | EmS-No. (Spillage) | | 14.3 In Accordance with IATA Proper Shipping Name |AEROSOLS, FLAMMABLE Identification Number|UN1950 |<PICTOGRAM PHRASE> Hazard Class |2.1 | Label Codes | | ntification Of The | | Substance/m | | ERG Code (IATA) | SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations <COMPONENT> SARA 313: Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product does not contain any chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372. Clean Water Act: This product does not contain any substances regulated as pollutants pursuant to the Clean Water Act (40 CFR 122.21 and 40 CFR 122.42). CERCLA: This material, as supplied, contains one or more substances regulated as a hazardous substance under the Comprehensive Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302): Chemical Name Hazardous Substances RQs Extremely Hazardous Substances RQs RQ ACETONE 67-64-1 5000 lb RQ 5000 lb final RQ RQ 2270 kg final RQ SARA Section 311/312 Hazard Classes |Acute Health Hazard: |Yes |Chronic Health Hazard: |Yes |Fire Hazard: |Yes |Sudden Release of Pressure Hazard Yes |Reactive Hazard: |no Toxic Substances Control Act (TSCA) |Chemical Name |TSCA | |ACETONE |X | |HEPTANE |X | |CARBON DIOXIDE |X | 15.2 US State Regulations <COMPONENT> California Proposition 65: This product does not contain any known Proposition 65 chemicals. U.S. State Right-to-Know Regulations: Chemical Name New Jersey Massachusetts Pennsylvania ACETONE 67-64-1 X X X CARBON DIOXIDE 124-38-9 X X X EPA Pesticide Registration Number: Not applicable. SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date |03-Jun-2015 Other |This document has been prepared in accordance with the SDS Information |requirements of the OSHA Hazard Communication Standard 29 CFR |1910.1200. GHS Full Text Phrases: ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | Grainger disclaimer.
The information contained in this SDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this 'SDS' shall be created or inferred by any statement in this 'SDS'. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this 'SDS'. The user is responsible for full compliance.