Product Categories See All
Track Order Status
SDS Sheet 0065030Printer Friendly View
Safety Data Sheet Date of Issue: |Revision Date: May 26, 2014|Revision Number: 1.0 Imperial Supplies Part Number: 0065031 SECTION 1: IDENTIFICATION 1.1. Product Identifier Product Form: Product Name: PB Penetrating Catalyst (Aerosol) CAS No: Synonyms: 1.2. Intended Use of the Product Use of the substance/mixture: Lubricant 1.3. Name, Address, and Telephone of the Responsible Party Company The Blaster Corporation 8500 Sweet Valley Drive Valley View, Ohio 44125 - USA Phone: (216) 901-5800 1.4. Emergency Telephone Number Emergency | CHEMTREC: (800) 424-9300 number | SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) Flammable |2 Aerosol | Gases Under | Pressure | (Dissolved | Gas) | Serious Eye |2A Irritation | Carcinogenicit|2 y | Aspiration |1 Hazard | 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) |Flame |Gas |Exclamat|Health | | | |Cylinder|ion Mark|Hazard | | Signal Word (GHS-US) |Danger Hazard Statements (GHS-US) |Flammable aerosol. Contains gas under pressure; may |explode if heated. Causes serious eye irritation. |Suspected of causing cancer. May be fatal if |swallowed and enters airways. Precautionary Statements |Prevention: Keep away from heat/sparks/open (GHS-US) |flames/hot surfaces. -No smoking. Do not spray on an |open flame or other ignition source. Pressurized |container: Do not pierce or burn, even after use. |Wash hands thoroughly after handling. Obtain special |instructions before use. Do not handle until all |safety precautions have been read and understood. |Wear protective gloves/protective clothing/eye |protection/face protection. |Response: If exposed or concerned: Get medical |advice/attention. If in eyes: Rinse cautiously with |water for several minutes. Remove contact lenses, if |present and easy to do. Continue rinsing. If eye |irritation persists: Get medical advice/attention. |If swallowed: Immediately call a poison center or |doctor. Do NOT induce vomiting. |Storage: Protect from sunlight. Do not expose to |temperatures exceeding 50 ÂºC/122 ÂºF. Store in a |well-ventilated place. Store locked up. |Disposal: Dispose of contents and container in |accordance with all local, regional, national and |international regulations. 2.3. Other Hazards Other Hazards Not Contributing to the Classification: Not applicable. 2.4. Unknown Acute Toxicity (GHS-US) 8 % of the mixture consists of ingredient(s) of unknown acute toxicity. SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name |Product identifier |% |Classification | | |(GHS-US) Distillates (petroleum), |64742-47-8 |50-60 | hydrotreated light | | | Solvent naphtha (petroleum), |64742-94-5 |20-30 | heavy aromatic | | | Distillates (petroleum), |64742-52-5 |20-30 | hydrotreated heavy naphthenic | | | Carbon dioxide |124-38-9 |1-5 | Naphthalene |91-20-3 |2-3 | Dinonylphenol, ethoxylated, |39464-64-7 |0.5-1.5 | phosphated | | | SECTION 4: FIRST AID MEASURES 4.1. Description of First Aid Measures First-aid Measures General: First-aid Measures After Inhalation: If breathing is difficult, remove to fresh air and keep at rest in a position comfortable for breathing. Get medical advice/attention if you feel unwell. First-aid Measures After Skin Contact: In case of contact, immediately flush skin with plenty of water. Remove contaminated clothing and shoes. Wash clothing before reuse. Call a physician if irritation develops and persists. First-aid Measures After Eye Contact: In case of contact, immediately flush eyes with plenty of water for at least 15 minutes. If easy to do, remove contact lenses, if worn. If irritation persists, get medical attention. First-aid Measures After Ingestion: If swallowed, do NOT induce vomiting unless directed to do so by medical personnel. Never give anything by mouth to an unconscious person. Get immediate medical advice/attention. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: Symptoms/Injuries After Inhalation: May be fatal if swallowed and enters airways. This product may be aspirated into the lungs and cause chemical pneumonitis. May cause stomach distress, nausea or vomiting. Symptoms/Injuries After Skin Contact: May cause skin irritation. Symptoms may include redness, drying, defatting and cracking of the skin. Symptoms/Injuries After Eye Contact: Causes serious eye irritation. Symptoms may include discomfort or pain, excess blinking and tear production, with marked redness and swelling of the conjunctiva. Symptoms/Injuries After Ingestion: May cause respiratory tract irritation. Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed Note to Physicians: Symptoms may not appear immediately. Specific Treatments: In case of accident or if you feel unwell, seek medical advice immediately (show the label or SDS where possible). SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: Dry chemical, carbon dioxide or foam. Unsuitable Extinguishing Media: Water may be ineffective for extinguishing fire. 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: Explosion Hazard: May include, and are not limited to: oxides of carbon, hydrocarbons. Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Firefighting Instructions: Protection During Firefighting: Keep upwind of fire. Wear full fire fighting turn-out gear (full Bunker gear) and respiratory protection (SCBA). Cool closed containers exposed to fire with water. Do not use a solid water stream as it may scatter and spread fire. Containers may explode when heated. SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: Use personal protection recommended in Section 8. Isolate the hazard area and deny entry to unnecessary and unprotected personnel. Eliminate sources of ignition. 6.1.1. For Non-emergency Personnel Protective Equipment: Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: Emergency Procedures: 6.2. Environmental Precautions 6.3. Methods and Material for Containment and Cleaning Up For Containment: Contain and/or absorb spill with inert material (e.g. sand, vermiculite), then place in a suitable container. Do not flush to sewer or allow to enter waterways. Use appropriate Personal Protective Equipment (PPE). Methods for Cleaning Up: Scoop up material and place in a disposal container. Vapors may be heavier than air and may travel along the ground to a distant ignition source and flash back. Provide ventilation. 6.4. Reference to Other Sections See heading 8, Exposure Controls and Personal Protection. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: Keep away from sources of ignition. - No smoking. Avoid contact with skin and eyes. Avoid breathing dust/fume/gas/mist/vapours/ spray. Do not swallow. When using do not eat, drink or smoke. Do not spray on an open flame or other ignition source. Use only outdoors or in a well-ventilated area. Pressurized container: Do not pierce or burn, even after use. (See section 8) Hygiene Measures: Launder contaminated clothing before reuse. Wash hands before eating, drinking, or smoking. 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Storage Conditions: Keep locked up and out of reach of children. Do not expose to temperatures exceeding 50 Â°C/ 122 Â°F. Store in dry, cool, wellventilated area. (See section 10) 7.3. Specific End Use(s) SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters Occupational Exposure Limits Ingredient OSHA-PEL ACGIH-TLV Distillates (petroleum), hydrotreated light 100 ppm 200 mg/mÂ³ Solvent naphtha (petroleum), heavy aromatic Not available Not available. Distillates (petroleum), hydrotreated heavy naphthenic 5 mg/mÂ³ (mist) 5 mg/mÂ³ (mist) Carbon dioxide 5000 ppm; 9000 mg/m3 5000 ppm Naphthalene 10 ppm; 50 mg/m3 10 ppm Dinonylphenol, ethoxylated, phosphated Not available. Not available. 8.2. Exposure Controls Appropriate Engineering |Use ventilation adequate to keep exposures (airborne Controls |levels of dust, fume, vapor, etc.) below recommended |exposure limits. Personal Protective Equipment| Materials for Protective | Clothing | Hand Protection |Wear chemically resistant protective gloves. Eye Protection |Safety glasses with side-shields. Skin and Body Protection |Wear suitable protective clothing. Respiratory Protection |A NIOSH approved respirator is recommended in poorly |ventilated areas or when permissible exposure limits |may be exceeded. Respirator selection must be based |on known or anticipated exposure levels, the hazards |of the product and the safe working limits of the |selected respirator. Thermal Hazard Protection | SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State |Gas/pressurized liquid. Appearance |Viscous / Oily. Odor |Heavy aromatic. Odor Threshold |Not available. pH |Not available. Relative Evaporation Rate |<1 (n-butyl acetate = 1) (butylacetate=1) | Melting Point |Not available. Freezing Point |Not available. Boiling Point |177.8 Â°C (352 Â°F) Flash Point |65.6 Â°C (150 Â°F) Auto-ignition Temperature |Not available. Decomposition Temperature |Not available. Flammability (solid, gas) |Flammable. Vapor Pressure |Not available. Relative Vapor Density at 20 Â°C | Relative Density |0.91 (Water = 1) Specific Gravity |0.91 (Water = 1) Solubility |Negligible. Partition coefficient: |Not available. n-octanol/water | Viscosity |Not available. Lower Flammable Limit |Not available. Upper Flammable Limit |Not available. 9.2. Other Information VOC Content: < 25% SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity No dangerous reaction known under conditions of normal use. 10.2 Chemical Stability Stable under normal storage conditions. Flammable aerosol. Contents under pressure. Container may explode if heated. Do not puncture. Do not burn 10.3 Possibility of Hazardous Reactions No dangerous reaction known under conditions of normal use. 10.4 Conditions to Avoid Heat. Incompatible materials. Sources of ignition. Excessive water. 10.5 Incompatible Materials Strong oxidizing agents. Strong reducing agents. Moisture. 10.6 Hazardous Decomposition Products May include, and are not limited to: oxides of carbon, hydrocarbons. SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: Ingredient IDLH LC50 LD50 Distillates (petroleum), hydrotreated light Not available Inhalation >5.2 mg/L 4h rat Oral >5000 mg/kg, rat; Dermal >2000 mg/kg, rabbit Solvent naphtha (petroleum), heavy aromatic Not available Inhalation >5.28 mg/L 4h rat Oral >5000 mg/kg, rat; Dermal >2000 mg/kg, rabbi Distillates (petroleum), hydrotreated heavy naphthenic Not available Inhalation >5.0 mg/L 4h rat Oral >5000 mg/kg, rat; Dermal >2000 mg/kg, rabbi Carbon dioxide 40000 ppm Not available Not available Naphthalene 250 ppm Not available Oral 490 mg/kg, rat; Dermal >2500 mg/kg, rat; Dermal >20 g/kg, rabbit Dinonylphenol, ethoxylated, phosphated Not available Not available Not available Calculated overall Chemical Acute Toxicity Values LC50 (inhalation) LD50 (oral) LD50 (dermal) > 5 mg/L 4h, rat > 2000 mg/kg, rat > 2000 mg/kg, rabbit Ingredient Chemical Listed as Carcinogen or Potential Carcinogen (NTP, IARC, OSHA, ACGIH, CP65)* Distillates (petroleum), hydrotreated light Not listed. Solvent naphtha (petroleum), heavy aromatic Not listed. Distillates (petroleum), hydrotreated heavy naphthenic Not listed. Carbon dioxide Not listed. Naphthalene G-A4, I-2B, N-2, CP65 Dinonylphenol, ethoxylated, phosphated Not listed. Skin Corrosion/Irritation: Based on available data, the classification criteria are not met. Serious Eye Damage/Irritation: Causes serious eye irritation. Respiratory or Skin Sensitization: Based on available data, the classification criteria are not met. Germ Cell Mutagenicity: Based on available data, the classification criteria are not met. Carcinogenicity: Possible carcinogen. Reproductive Toxicity: Based on available data, the classification criteria are not met. Specific Target Organ Toxicity (Single Exposure): Based on available data, the classification criteria are not met. Specific Target Organ Toxicity (Repeated Exposure): Based on available data, the classification criteria are not met. Aspiration Hazard: May be fatal if swallowed and enters airways. Symptoms/Injuries After Inhalation: May cause respiratory tract irritation. Symptoms/Injuries After Skin Contact: May cause skin irritation. Symptoms may include redness, drying, defatting and cracking of the skin. Symptoms/Injuries After Eye Contact: Causes serious eye irritation. Symptoms may include discomfort or pain, excess blinking and tear production, with marked redness and swelling of the conjunctiva. Symptoms/Injuries After Ingestion: May be fatal if swallowed and enters airways. This product may be aspirated into the lungs and cause chemical pneumonitis. May cause stomach distress, nausea or vomiting. Chronic Symptoms: SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity May cause long-term adverse effects in the aquatic environment. 12.2. Persistence and Degradability Not available 12.3. Bioaccumulative Potential Not available 12.4. Mobility in Soil Not available 12.5. Other Adverse Effects Not available SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: This material must be disposed of in accordance with all local, state, provincial, and federal regulations. The generation of waste should be avoided or minimized wherever possible. Additional Information: Flammable vapours may accumulate in the container. Do not incinerate empty containers. SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name |AEROSOLS, flammable, limited quantities Hazard Class |2.1 |<PICTOGRAM PHRASE> Identification Number|UN1950 | Label Codes | | ERG Number | 14.2 In Accordance with IMDG Proper Shipping Name | Hazard Class | Identification Number| Label Codes | |<PICTOGRAM PHRASE> ntification Of The | | Substance/m | | EmS-No. (Fire) | | EmS-No. (Spillage) | | 14.3 In Accordance with IATA Proper Shipping Name | Identification Number| |<PICTOGRAM PHRASE> Hazard Class | | Label Codes | | ntification Of The | | Substance/m | | ERG Code (IATA) | SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations <COMPONENT> SARA Title III Ingredient Section 302 (EHS) TPQ (lbs.) Section 304 EHS RQ (lbs.) CERCLA RQ (lbs.) Section 313 Distillates (petroleum) hydrotreated light Not listed. Not listed. Not listed. Not listed. Solvent naphtha (petroleum), heavy aromatic Not listed. Not listed. Not listed. Not listed. Distillates (petroleum) Hydrotreated heavy naphthenic Not listed. Not listed. Not listed. Not listed. Carbon dioxide Not listed. Not listed. Not listed. Not listed. Naphthalene Not listed. Not listed. 100 313 Dinonylphenol, ethoxylated, phosphated Not listed. Not listed. Not listed. Not listed. SARA Section 311/312 Hazard Classes | Toxic Substances Control Act (TSCA) |Global Inventories: |Ingredient USA TSCA |Distillates (petroleum), hydrotreated light |Yes. |Solvent naphtha (petroleum), heavy aromatic |Yes. |Distillates (petroleum), hydrotreated heavy |naphthenic Yes. |Carbon dioxide |Yes. |Naphthalene |Yes. |Dinonylphenol, ethoxylated, phosphated |Yes. 15.2 US State Regulations <COMPONENT> This product contains a chemical known to the State of California to cause cancer. SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date |May 26, 2014 Other |This document has been prepared in accordance with the SDS Information |requirements of the OSHA Hazard Communication Standard 29 CFR |1910.1200. GHS Full Text Phrases: ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | Grainger disclaimer.
The information contained in this SDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this 'SDS' shall be created or inferred by any statement in this 'SDS'. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this 'SDS'. The user is responsible for full compliance.