Product Categories See All
Track Order Status
SDS Sheet 0056430Printer Friendly View
Safety Data Sheet Date of Issue: |Revision Date: 6/25/15 |Revision Number: Imperial Supplies Part Number: 0056430 SECTION 1: IDENTIFICATION 1.1. Product Identifier Product Form: Product Name: NAB Battery Acid Cleaner & Neutralizer CAS No: Synonyms: Alkaline Solution 1.2. Intended Use of the Product Use of the substance/mixture: 1.3. Name, Address, and Telephone of the Responsible Party Company: NPS Corporation 3303 Spirit Way Green Bay, WI 54304 Phone: 800-558-5066 1.4. Emergency Telephone Number Emergency | CHEMTREC: (800) 424-9300 (USA); +1 (703) 527-3887 (International number |and Maritime) SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) Corrosive to |Category 1 Metals | Skin |Category 2 irritation | Eye irritation|Category 2A 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) |Corrosio| | | | | |n | | | | | Signal Word (GHS-US) |Warning Hazard Statements (GHS-US) |Corrosive to Metals - Category 1 |Skin irritation - Category 2 |Eye irritation - Category 2A Precautionary Statements |Keep only in original container. (GHS-US) |Store in corrosive resistant container with inner |liner. |Absorb spillage to prevent material damage. |Wash hands thoroughly after handling. |If on Skin: Wash with plenty of soap and water. |If skin irritation occurs get medical |advice/attention. |Take off contaminated clothing and wash before |reuse. Wear protective gloves. |Wear eye protection such as goggles or safety |glasses with side shields. |If in eyes: Rinse cautiously with water for 15 |minutes. |Remove contact lenses, if present and easy to do. |Continue rinsing. |If eye irritation persists get medical |advice/attention. |Do not eat, drink or smoke when using this product. |If swallowed: Immediately call a poison |center/physician, Rinse mouth. |Dispose of contents/container in accordance with |local State, federal or international regulations. | 2.3. Other Hazards Other Hazards Not Contributing to the Classification: Not applicable 2.4. Unknown Acute Toxicity (GHS-US) SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name |Product identifier |% |Classification | | |(GHS-US) Sodium Carbonate |497-19-8 |<5 | Phosphoric acid |7664-38-2 |<1 | Surfactant Blend |Trade secret |<5 | Potassium hydroxide |1310-58-3 |10-30 | 2-Hydroxyethanoic acid |79-14-1 |<1 | Terpene hydrocarbons |8028-48-6 |<1 | Dipropylene glycol methyl ether |34590-94-8 |<5 | SECTION 4: FIRST AID MEASURES 4.1. Description of First Aid Measures First-aid Measures General: First-aid Measures After Inhalation: If inhaled remove victim to fresh air and keep at rest. Call a poison center or physician if you feel unwell. First-aid Measures After Skin Contact: Wash with plenty of soap and water. Take off contaminated clothing and wash before reuse. If skin irritation occurs get medical advice/attention. First-aid Measures After Eye Contact: If product gets in eyes flush with water for at least 15 minutes. If eye irritation persists seek medical advice/attention. First-aid Measures After Ingestion: Do NOT induce vomiting unless instructed by medical personal. Never give anything by mouth to an unconscious person. Get medical attention. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: May cause skin irritation or burns. Symptoms/Injuries After Eye Contact: May cause eye irritation or burns. Symptoms/Injuries After Ingestion: Indigestion may cause gastrointestinal irritation, nausea, vomiting, diarrhea and burns to the mouth, throat and esophagus. Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed Treat symptomatically SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: Water fog, Carbon dioxide, Dry chemical, Foam Unsuitable Extinguishing Media: Not available 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: Non known Explosion Hazard: Carbon oxides, other unidentified organic compounds. Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Firefighting Instructions: Protection During Firefighting: Protective equipment for fire-fighters: Firefighters should wear proper protective equipment (Bunker gear) and self-contained breathing apparatus with full face operated in positive pressure mode. SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: All persons dealing with the clean-up should the appropriate chemically protective equipment. Keep people away from and upwind of spill/leak. Restrict access to area until completion of clean-up. 6.1.1. For Non-emergency Personnel Protective Equipment: Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: Emergency Procedures: 6.2. Environmental Precautions 6.3. Methods and Material for Containment and Cleaning Up For Containment: Methods for Cleaning Up: Do not allow material to contaminate ground water system. If necessary, dike well ahead of the spill to prevent run-off into drains, sewers, or any natural waterway or drinking supply. Ventilate the area. Scoop up material and place into suitable container(s). Dispose of according to local, state and federal regulations. 6.4. Reference to Other Sections See heading 8, Exposure Controls and Personal Protection. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: Obtain special instructions before use. Do not handle until all safety precautions have been read and understand. Wear protective gloves and eye/face protection. Adequate ventilation should be supplied. Avoid contact with skin, eyes and clothing. Keep away from heat. Keep container tightly closed. Hygiene Measures: Avoid contact with eyes, skin and clothing. Do not eat, drink or smoke when using this product. Wash hands after handling. Remove and wash all contaminated clothing before re-use. Handle in accordance with good industrial hygiene and safety practice. 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Storage Conditions: Store in cool, dry and well ventilated place. Containers should be clearly identified, clear of obstructions and accessible only to authorized personnel. Protect from sunlight. Have appropriate fire extinguishers/sprinkler system in place. Spill clean-up equipment should be in or near storage area. Incompatible materials: Strong oxidizers, Strong acids. 7.3. Specific End Use(s) SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters Chemical Name ACGIH-TLV OSHA-PEL Sodium Carbonate 2mg/m3 2mg/m3 Phosphoric acid 1.0mg/m3 1.0mg/m3 Surfactant Blend Not available Not available Potassium hydroxide 2mg/m3 2mg/m3 2-Hydroxyethanoic acid 25mg/m3 25mg/m3 Terpene hydrocarbons 30ppm 300ppm Dipropylene glycol methyl ether 100ppm 100ppm 8.2. Exposure Controls Appropriate Engineering |Use in well ventilated area. Apply technical Controls |measures to comply with occupational exposure limits |if needed. Personal Protective Equipment|Ensure that eyewash stations and a safety shower are |close to the workstation(s). Materials for Protective | Clothing | Hand Protection | Eye Protection |Goggles or safety glasses with side shields. Skin and Body Protection |Wear protective gloves. Where extensive exposure to |the product is possible, use resistant apron/suit |and boots. Respiratory Protection |If airborne concentrations are above the permissible |exposure limit use NIOSH approved respirators. Thermal Hazard Protection | SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State | Appearance |Clear orange liquid. Odor |Mild orange odor. Odor Threshold |Not available pH |13.8 Relative Evaporation Rate |Not available (butylacetate=1) | Melting Point |~ -3C (26.6F) Freezing Point |~ -3C (26.6F) Boiling Point |>100C (212F) Flash Point |>93.3C (199.4F) Auto-ignition Temperature |Not available Decomposition Temperature |Not available Flammability (solid, gas) |Not available Vapor Pressure |Not available Relative Vapor Density at 20 Â°C |Not available Relative Density |1.3 Specific Gravity | Solubility |Solubility in water: Complete Partition coefficient: |Not available n-octanol/water | Viscosity |Not available Lower Flammable Limit |Not available Upper Flammable Limit |Not available 9.2. Other Information Volatiles (% by wt) = ~1.0 Volatile organic compounds: Terpene hydrocarbons, Dipropylene glycol methyl ether SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity Not normally reactive. 10.2 Chemical Stability Stable under normal conditions. 10.3 Possibility of Hazardous Reactions Hazardous polymerization does not occur. 10.4 Conditions to Avoid Heat. Contact with incompatible materials. 10.5 Incompatible Materials Strong oxidizers, Strong acids. 10.6 Hazardous Decomposition Products Carbon oxides. SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: The calculated ATE value for this mixture is well above classification parameters. Skin Corrosion/Irritation: Serious Eye Damage/Irritation: Respiratory or Skin Sensitization: No data available to indicate product may be a sensitizer. Germ Cell Mutagenicity: Not hazardous by OSHA/WHMIS criteria. Carcinogenicity: No components are listed as carcinogens by ACGIH, IARC, OSHA or NTP. Reproductive Toxicity: Not hazardous by OSHA/WHMIS criteria. Specific Target Organ Toxicity (Single Exposure): Not available. Specific Target Organ Toxicity (Repeated Exposure): Not available. Aspiration Hazard: Symptoms/Injuries After Inhalation: May cause respiratory irritation. May cause headache, nausea, dizziness and other symptoms of central nervous system depression. Symptoms/Injuries After Skin Contact: May cause burns or irritation. Symptoms may include redness, edema, drying, defatting and cracking of the skin. Symptoms/Injuries After Eye Contact: May cause severe irritation or damage. Symptoms/Injuries After Ingestion: Ingestion may cause gastrointestinal irritation, nausea, vomiting and diarrhea. Chronic Symptoms: SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity No data is available on the product itself. 12.2. Persistence and Degradability This product itself has not been tested. 12.3. Bioaccumulative Potential This product itself has not been tested. 12.4. Mobility in Soil This product itself has not been tested. 12.5. Other Adverse Effects None known. SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: Handle in accordance with good industrial hygiene and safety practice. Refer to protective measures listed in sections 7 and 8. Additional Information: Dispose in accordance with all applicable federal, state, provincial and local regulation. Contact your federal, state, provincial and local authorities for specific rules. SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name |Not Regulated Hazard Class | |<PICTOGRAM PHRASE> Identification Number| | Label Codes | | ERG Number | 14.2 In Accordance with IMDG Proper Shipping Name | Hazard Class | Identification Number| Label Codes | |<PICTOGRAM PHRASE> ntification Of The | | Substance/m | | EmS-No. (Fire) | | EmS-No. (Spillage) | | 14.3 In Accordance with IATA Proper Shipping Name | Identification Number| |<PICTOGRAM PHRASE> Hazard Class | | Label Codes | | ntification Of The | | Substance/m | | ERG Code (IATA) | SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations <COMPONENT> US CERCLA Reportable quantity (RQ): Not available SARA Title III: Sec. 302, Extremely Hazardous Substances, 40 CFR 355: No extremely hazardous substances are present in this material. SARA Title III: Sec. 311 and 312, MSDS Requirements, 40 CFR 370 Hazard Classes: Reactive Hazard, Acute Health Hazard, Chronic Health Hazard. Under SARA Section 311 and 312, the EPA has established threshold quantities for the reporting of hazardous chemicals. The current thresholds are 500 pounds for the threshold planning quantity (TPQ), whichever is lower, for extremely hazardous substances and 10,000 pounds for all other hazardous chemicals. SARA Title III: Sec. 313, Toxic Chemicals Notification, 40 CFR 372: No components are present in this material. SARA Section 311/312 Hazard Classes | Toxic Substances Control Act (TSCA) |All listed ingredients appear on the Toxic |Substances Control Act. 15.2 US State Regulations <COMPONENT> California Proposition 65: This product does contain a chemical known to the State of California to cause, birth defects or other reproductive harm. SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date |6/25/15 Other |This document has been prepared in accordance with the SDS Information |requirements of the OSHA Hazard Communication Standard 29 CFR |1910.1200. GHS Full Text Phrases: ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | Grainger disclaimer.
The information contained in this SDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this 'SDS' shall be created or inferred by any statement in this 'SDS'. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this 'SDS'. The user is responsible for full compliance.