Product Categories See All
Track Order Status
SDS Sheet 0056170Printer Friendly View
Safety Data Sheet | | Date of Issue: 5/27/2015 |Revision Date: |Revision Number: 01 Imperial Supplies Part Number: 0056170 SECTION 1: IDENTIFICATION 1.1. Product Identifier Product Form: Product Name: CONVOY II, BLACK CAS No: Synonyms: 1.2. Intended Use of the Product Use of the substance/mixture: Protective Coating 1.3. Name, Address, and Telephone of the Responsible Party Company Kelley Technical Coatings 1445 South 15th Street P.O. Box 3726 Louisville, Kentucky 40201-3726 Phone: 502-636-2561 1.4. Emergency Telephone Number Emergency | Day: 502-636-2561, Night: 800-424-9300 number | SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) Acute |4 Toxicity- Oral| Skin Irritant |2 Eye |2b Damage/Irritat| ion | 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) |Exclamat| | | | | |ion mark| | | | | Signal Word (GHS-US) |Warning Hazard Statements (GHS-US) |H302 Harmful if swallowed |H315 Causes skin irritation |H320 Causes eye irritation Precautionary Statements |Prevention: (GHS-US) |P202 Do not handle until all safety precautions have |been read and understood. |P264 Wash hands and/or face thoroughly after |handling. |P270 Do not eat, drink or smoke when using this |product. |Response: |P312 Call a poison center or doctor if you feel |unwell. |P330 If swallowed,rinse mouth. |P363 Wash contaminated clothing and wash before |reuse. |P302 + P352 IF ON SKIN: Wash with plenty of soap and |water. |P332 + P313 If skin irritation occurs: Get medical |advice/attention. |P337 + P313 If eye irritation persists: Get medical |advice/attention. |Storage/ Disposal: |P501 Dispose of contents/container in accordance |with federal, state, provincial, and local |regulations. 2.3. Other Hazards Other Hazards Not Contributing to the Classification: OSHA Regulatory Status: This material is considered hazardous by the OSHA Hazard Communication Standard (29 CFR1910.1200). 2.4. Unknown Acute Toxicity (GHS-US) SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name |Product identifier |% |Classification | | |(GHS-US) Nepheline syenite |37244-96-5 |30 - 40%| Magnesium silicate |14807-96-6 |10 - 20%| Pumice |1332-09-8 |1 - 5% | Ethylene glycol |107-21-1 |1 - 5% | Butoxy dipropanol |29911-28-2 |1 - 5% | Carbon black |1333-86-4 |1 - 5% | Crystalline silica, (quartz) |14808-60-7 |0.1 - 1%| SECTION 4: FIRST AID MEASURES 4.1. Description of First Aid Measures First-aid Measures General: Show this safety data sheet to the doctor in attendance. First-aid Measures After Inhalation: Move to fresh air. Restore breathing. If breathing is difficult, get immediate medical attention. First-aid Measures After Skin Contact: Wash affected area thoroughly with soap and water. If skin irritation persists, get immediate medical attention. First-aid Measures After Eye Contact: Flush with plenty of cool water for at least15 minutes, holding eyelids apart for thorough irrigation. If irritation persists, get immediate medical attention. First-aid Measures After Ingestion: Do not induce vomiting - seek immediate medical attention. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed Notes to Physician: Treat symptomatically. SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: Use extinguishing measures that are appropriate to local circumstances and the surrounding environment. Unsuitable Extinguishing Media: 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: Closed containers may rupture if exposed to fire or extreme heat. Explosion Hazard: Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Firefighting Instructions: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. Protection During Firefighting: SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: Use personal protective equipment. Remove all sources of ignition. 6.1.1. For Non-emergency Personnel Protective Equipment: Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: Emergency Procedures: 6.2. Environmental Precautions Prevent further leakage or spillage if safe to do so. Do not allow material to contaminate ground water system. Prevent product from entering drains. Do not flush into surface water or sanitary sewer system. Local authorities should be advised if significant spillages cannot be contained. 6.3. Methods and Material for Containment and Cleaning Up For Containment: Methods for Cleaning Up: Dam up. Soak up with inert absorbent material. Pick up and transfer to properly labeled containers. Clean contaminated surface thoroughly. 6.4. Reference to Other Sections See heading 8, Exposure Controls and Personal Protection. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: Wear personal protective equipment. Avoid contact with skin, eyes and clothing. Ensure adequate ventilation. Avoid breathing vapors, spray mists or sanding dust. In case of insufficient ventilation, wear suitable respiratory equipment. Hygiene Measures: Avoid contact with skin, eyes and clothing. Remove and wash contaminated clothing before re-use. Wash thoroughly after handling. 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Storage Conditions: Keep container tightly closed. Keep out of the reach of children. 7.3. Specific End Use(s) SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters Exposure Limits: Hazardous Components OSHA PEL ACGIH TLV Nepheline syenite 5 ppm (R) NE Magnesium silicate 20 mppcf 2 mg/m3 (R) Pumice 15 mg/m3 10 mg/m3 Ethylene glycol 50 ppm (C) 50 ppm (C)(STEL) Butoxy dipropanol NE NE Carbon black 3.5 mg/m3 3 mg/m3 (I) Crystalline silica, (quartz) 10 mg/m3/%Sio2 +2 (R) 0.025 mg/m3 (R) 8.2. Exposure Controls Appropriate Engineering |Ensure adequate ventilation, especially in confined Controls |areas. Personal Protective Equipment| Materials for Protective | Clothing | Hand Protection | Eye Protection |Safety goggles or full face shield. Skin and Body Protection |Protective gloves and impervious clothing. Respiratory Protection |In case of insufficient ventilation, wear suitable |respiratory equipment. Thermal Hazard Protection | SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State | Appearance |liquid Odor |Little or no odor Odor Threshold |Not determined pH |Not available Relative Evaporation Rate |Not available (butylacetate=1) | Melting Point |Not determined Freezing Point |32 F Boiling Point |212 F Flash Point |Greater than 201 Auto-ignition Temperature |Not applicable Decomposition Temperature |Not determined Flammability (solid, gas) |Not applicable Vapor Pressure |Not available Relative Vapor Density at 20 Â°C |Not available Relative Density |12.72 LB/GAL Specific Gravity |1.53 Solubility |Not determined Partition coefficient: |Not determined n-octanol/water | Viscosity |Not available Lower Flammable Limit |Not applicable Upper Flammable Limit |Not applicable 9.2. Other Information VOC lb/gal: 0.67 VOC (lb/gal) less exempt: 1.22 VOC (g/L): 80.47 VOC (g/L) less exempt: 145.99 SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity 10.2 Chemical Stability Stable under normal conditions. 10.3 Possibility of Hazardous Reactions None under normal conditions of use. 10.4 Conditions to Avoid Prevent from freezing. 10.5 Incompatible Materials Materials to Avoid: No materials to be especially mentioned. 10.6 Hazardous Decomposition Products None under normal use. SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: Skin Corrosion/Irritation: Serious Eye Damage/Irritation: Respiratory or Skin Sensitization: Germ Cell Mutagenicity: Carcinogenicity: The information below indicates whether each agency has listed any ingredient as a carcinogen: Component IARC NTP OSHA carbon black 2B - Possible Human Carcinogen Not listed Listed crystalline silica, (quartz) l - Human carcinogen Known Human Carcinogen Listed Reproductive Toxicity: Specific Target Organ Toxicity (Single Exposure): Specific Target Organ Toxicity (Repeated Exposure): Aspiration Hazard: Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Chronic Symptoms: SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity No ecological information available. 12.2. Persistence and Degradability 12.3. Bioaccumulative Potential 12.4. Mobility in Soil 12.5. Other Adverse Effects SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: Dispose of in accordance with federal, state, provincial, and local regulations. Local requirements may vary, consult your sanitation department or state-designated environmental protection agency for more disposal options. Additional Information: SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name |Not regulated Hazard Class | |<PICTOGRAM PHRASE> Identification Number| | Label Codes | | ERG Number | 14.2 In Accordance with IMDG Proper Shipping Name |Not regulated Hazard Class | Identification Number| Label Codes | |<PICTOGRAM PHRASE> ntification Of The | | Substance/m | | EmS-No. (Fire) | | EmS-No. (Spillage) | | 14.3 In Accordance with IATA Proper Shipping Name |Not regulated Identification Number| |<PICTOGRAM PHRASE> Hazard Class | | Label Codes | | ntification Of The | | Substance/m | | ERG Code (IATA) | SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations <COMPONENT> SARA 313 Section 313 OF Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). If listed below, this product contains a chemical or chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372. Chemical Designation Cas No. Weight % ethylene glycol 107-21-1 < 5% Clean Air Act, Section 112 Hazardous Air Pollutants (HAPS) (see 40 CFR 61) Chemical Designation Cas No. Weight % ethylene glycol 107-21-1 1 - 5% Any Target HAP listed in this section is not an OSHA Carcinogen unless listed as such in Section 11 under Chronic Toxicity. SARA Section 311/312 Hazard Classes |Acute Health Hazard: YES |Chronic Health Hazard: YES |Fire Hazard: NO |Sudden Release of Pressure Hazard: NO |Reactive Hazard: NO Toxic Substances Control Act (TSCA) |Yes - All components are listed or exempt 15.2 US State Regulations <COMPONENT> California Proposition 65: This product may contain small amounts of materials known to the state of California to cause cancer or reproductive harm. SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date | Other |This document has been prepared in accordance with the SDS Information |requirements of the OSHA Hazard Communication Standard 29 CFR |1910.1200. GHS Full Text Phrases: ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | Grainger disclaimer.
The information contained in this SDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this 'SDS' shall be created or inferred by any statement in this 'SDS'. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this 'SDS'. The user is responsible for full compliance.