Product Categories See All
Track Order Status
SDS Sheet 0052050Printer Friendly View
Safety Data Sheet | | Date of Issue: |Revision Date: 5/12/2009 |Revision Number: Imperial Supplies Part Number: 0052050 SECTION 1: IDENTIFICATION 1.1. Product Identifier Product Form: Product Name: Coform Sorbent Media CAS No: Synonyms: 1.2. Intended Use of the Product Use of the substance/mixture: Absorbent Mat 1.3. Name, Address, and Telephone of the Responsible Party NPS Corporation 3303 Spirit Way Green Bay, WI 54304 1-770-587-8976 1.4. Emergency Telephone Number Emergency | 1-800-424-9300, 1-877-561-6587 number | SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) | | | 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) | | | | | | Signal Word (GHS-US) | Hazard Statements (GHS-US) | Precautionary Statements | (GHS-US) | 2.3. Other Hazards Other Hazards Not Contributing to the Classification: 2.4. Unknown Acute Toxicity (GHS-US) SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name |Product identifier |% |Classification | | |(GHS-US) Polypropylene |9003-07-0 |up to | | |100% | Cellulose Pulp |Mixture |up to | | |100% | | | | | | | | | | SECTION 4: FIRST AID MEASURES 4.1. Description of First Aid Measures First-aid Measures General: First-aid Measures After Inhalation: No first aid should be needed. First-aid Measures After Skin Contact: No first aid should be needed. First-aid Measures After Eye Contact: Immediately flush eye(s) with plenty of water. Obtain medical attention if irritation persists. First-aid Measures After Ingestion: No first aid should be needed. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: Symptoms/Injuries After Inhalation: Dust may form explosive mixture in air. Inhalation of dust that may be generated from cutting or other processing of product may cause mucous membrane and upper respiratory irritation. Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed None currently known. SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: Water, water fog, foam, carbon dioxide, dry chemical. Unsuitable Extinguishing Media: 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: Explosion Hazard: Dust may form explosive mixture in air. Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Firefighting Instructions: Protection During Firefighting: In the event of fire, wear self contained breathing apparatus. SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: Pick up and place in a suitable container for use or disposal. Avoid dust formation. 6.1.1. For Non-emergency Personnel Protective Equipment: Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: Emergency Procedures: 6.2. Environmental Precautions 6.3. Methods and Material for Containment and Cleaning Up For Containment: Methods for Cleaning Up: 6.4. Reference to Other Sections See heading 8, Exposure Controls and Personal Protection. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: Minimize the generation and accumulation of dust. Keep in a dry, cool place. Hygiene Measures: 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Storage Conditions: 7.3. Specific End Use(s) SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters Exposure limit(s) 15 mg/m3 PEL-TWA (total dust) 10 mg/m3 TLV-TWA (inhalable dust) as PNOS (particulates not otherwise specified) 8.2. Exposure Controls Appropriate Engineering |Ventilation: No special ventilation normally Controls |required. Provide appropriate exhaust ventilation at |places where dust is formed. Personal Protective Equipment| Materials for Protective | Clothing | Hand Protection |Protective Gloves: Not required. Eye Protection |Follow facility requirements. Skin and Body Protection | Respiratory Protection |No personal respiratory protective equipment |normally required. If the exposure limit is exceeded |or for symptoms of overexposure, wear an appropriate |NIOSH (or local authority) certified respirator. Thermal Hazard Protection | SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State | Appearance |White or colored fabric Odor |No odor. Odor Threshold | pH |Not applicable Relative Evaporation Rate |Not applicable (butylacetate=1) | Melting Point |Not applicable Freezing Point | Boiling Point | Flash Point | Auto-ignition Temperature | Decomposition Temperature | Flammability (solid, gas) | Vapor Pressure |Not applicable Relative Vapor Density at 20 Â°C | Relative Density | Specific Gravity |Not applicable Solubility |Partially soluble Partition coefficient: |Not applicable n-octanol/water | Viscosity | Lower Flammable Limit | Upper Flammable Limit | 9.2. Other Information Percent Volatile by Volume (%) : 0% SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity 10.2 Chemical Stability Stable 10.3 Possibility of Hazardous Reactions Hazardous Polymerization: Does not occur. 10.4 Conditions to Avoid Keep away from open flames, hot surfaces and sources of ignition. 10.5 Incompatible Materials Strong oxidizing agents. 10.6 Hazardous Decomposition Products Carbon monoxide, carbon dioxide. SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: Product: Oral LD50 (rat) >5000 mg/kg Based on an assessment of the ingredients. Skin Corrosion/Irritation: Serious Eye Damage/Irritation: Respiratory or Skin Sensitization: Germ Cell Mutagenicity: Carcinogenicity: None of the components of this product is listed as a carcinogen by IARC, NTP, US OSHA or the European Directive (67/548/EEC). Reproductive Toxicity: No adverse effects on reproduction are known. Specific Target Organ Toxicity (Single Exposure): Specific Target Organ Toxicity (Repeated Exposure): Aspiration Hazard: Symptoms/Injuries After Inhalation: Inhalation of dust that may be generated from cutting or other processing of product may cause mucous membrane and upper respiratory irritation. Symptoms/Injuries After Skin Contact: None expected. Symptoms/Injuries After Eye Contact: None expected. Symptoms/Injuries After Ingestion: No unusual hazards expected. Chronic Symptoms: Prolonged overexposure to dust may cause lung changes. SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity No adverse effects on the environment are expected. 12.2. Persistence and Degradability 12.3. Bioaccumulative Potential 12.4. Mobility in Soil 12.5. Other Adverse Effects SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: Dispose in accordance with all state, local and federal regulations. Additional Information: SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name |Not regulated Hazard Class | |<PICTOGRAM PHRASE> Identification Number| | Label Codes | | ERG Number | 14.2 In Accordance with IMDG Proper Shipping Name |Not regulated Hazard Class | Identification Number| Label Codes | |<PICTOGRAM PHRASE> ntification Of The | | Substance/m | | EmS-No. (Fire) | | EmS-No. (Spillage) | | 14.3 In Accordance with IATA Proper Shipping Name |Not regulated Identification Number| |<PICTOGRAM PHRASE> Hazard Class | | Label Codes | | ntification Of The | | Substance/m | | ERG Code (IATA) | SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations <COMPONENT> International Regulations Canadian WHMIS Classification: Not a controlled product. This product has been classified in accordance with the hazard criteria of the CPR and the MSDS contains all the information required by the CPR. EU Labeling: Not applicable SARA 313 This Product Contains the Following Chemicals Subject to Annual Release Reporting Requirements Under the SARA Section 313 (40 CFR 372): None. SARA Section 311/312 Hazard Classes |Not Hazardous Toxic Substances Control Act (TSCA) |All of the components of this product are |listed on the TSCA Inventory or exempted from |TSCA. 15.2 US State Regulations <COMPONENT>California Proposition 65: This product does not contain chemicals listed per the Safe Drinking Water and Toxic Enforcement Act of 1986. SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date |5/12/2009 Other |This document has been prepared in accordance with the SDS Information |requirements of the OSHA Hazard Communication Standard 29 CFR |1910.1200. GHS Full Text Phrases: ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | Grainger disclaimer.
The information contained in this SDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this 'SDS' shall be created or inferred by any statement in this 'SDS'. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this 'SDS'. The user is responsible for full compliance.