Product Categories See All
Track Order Status
SDS Sheet 0046800Printer Friendly View
Safety Data Sheet | | Date of Issue: 06/01/2015 |Revision Date: 06/01/2015 |Revision Number: 1.0 Imperial Supplies Part Number: 0046800 SECTION 1: IDENTIFICATION 1.1. Product Identifier Product Form: Product Name: Diesel Treat CAS No: Synonyms: 1.2. Intended Use of the Product Use of the substance/mixture: 1.3. Name, Address, and Telephone of the Responsible Party Company R.B. Howes & Co., Inc. / Howes Lubricator 60 Ocean State Drive North Kingstown, RI Phone: T 401-294-5500, 1-800 GET HOWES (438-4693) 1.4. Emergency Telephone Number Emergency |CHEMTREC 1 (800) 424-9300 number | SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) Flammable |4 Liquid | Skin |2 Irritation | Carcinogenicit|2 y | Specific |1 target organ | toxicity - | Repeated | exposure | Aspiration |1 Toxicity | 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) |Exclamat|Health | | | | |ion mark|hazard | | | | Signal Word (GHS-US) |Danger Hazard Statements (GHS-US) |Combustible liquid. Causes skin irritation. |Suspected of causing cancer. Causes damage to organs |through prolonged or repeated exposure. May be fatal |if swallowed and enters airways. Precautionary Statements |Keep away from flames and hot surfaces. - No (GHS-US) |smoking. Wash hands thoroughly after handling. |Obtain special instructions before use. Do not |handle until all safety precautions have been read |and understood. Wear protective gloves/protective |clothing/eye protection/face protection. Do not |breathe dust/fume/gas/mist/vapors/spray. Do not eat, |drink or smoke when using this product. If exposed |or concerned: Get medical advice/attention. If on |skin: Wash with plenty of water. If skin irritation |occurs: Get medical advice/attention. Take off |contaminated clothing and wash it before reuse. If |swallowed: Immediately call a poison center/doctor. |Do NOT induce vomiting. Store in a well-ventilated |place. Keep cool. Store locked up. Dispose of |contents/container in accordance with |local/regional/national/international regulations. 2.3. Other Hazards Other Hazards Not Contributing to the Classification: No additional information available. 2.4. Unknown Acute Toxicity (GHS-US) 31 percent of the mixture consists of ingredient(s) of unknown acute toxicity. SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name |Product identifier |% |Classification | | |(GHS-US) Distillates, petroleum, |(CAS No) 64742-46-7 |40 - 70 |Flam. Liq. 4 hydrotreated middle | | |Acute Tox. 4 | | |(Inhalation) | | |Asp. Tox. 1 Stoddard solvent |(CAS No) 8052-41-3 |15 - 40 |Skin Irrit. 2 | | |STOT RE 1 | | |Asp. Tox. 1 Petroleum distillates, |(CAS No) 64742-47-8 |10 - 30 |Flam. Liq. 3 hydrotreated light | | |Asp. Tox. 1 Solvent naphtha, petroleum, |(CAS No) 64742-95-6 |1 - 5 |Flam. Liq. 3 light aromatic | | |Skin Irrit. 2 | | |Eye Irrit. 2A | | |Asp. Tox. 1 Benzene, 1,2,4-trimethyl- |(CAS No) 95-63-6 |1 - 5 |Flam. Liq. 3 | | |Acute Tox. 4 | | |(Inhalation) | | |Skin Irrit. 2 | | |Eye Irrit. 2A | | |STOT SE 3 Fatty acid amine reaction |Trade secret |1 - 5 |Skin Irrit. 2 product | | |Eye Irrit. 2A Nonane |(CAS No) 111-84-2 |1 - 5 |Flam. Liq. 3 | | |Acute Tox. 4 | | |(Inhalation) | | |Skin Irrit. 2 | | |STOT SE 3 | | |Asp. Tox. 1 Naphthalene |(CAS No) 91-20-3 |0.1 - 1 |Acute Tox. 4 | | |(Oral) | | |Carc. 2 Ethylbenzene |(CAS No) 100-41-4 |< 0.1 |Flam. Liq. 2 | | |Acute Tox. 4 | | |(Inhalation) | | |Skin Irrit. 2 | | |Eye Irrit. 2B | | |Carc. 2 | | |Asp. Tox. 1 Cumene |(CAS No) 98-82-8 |< 0.1 |Flam. Liq. 3 | | |Carc. 2 | | |STOT SE 3 | | |Asp. Tox. 1 * The specific chemical identity and exact percentage (concentration) of composition has been withheld as a trade secret in accordance with paragraph (i) of Â§1910.1200. SECTION 4: FIRST AID MEASURES 4.1. Description of First Aid Measures First-aid Measures General: First-aid Measures After Inhalation: If inhaled, remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. Get medical advice/attention if you feel unwell. First-aid Measures After Skin Contact: In case of contact, immediately flush skin with plenty of water. Remove contaminated clothing and shoes. Wash clothing before reuse. Call a physician if irritation develops and persists. First-aid Measures After Eye Contact: In case of contact, immediately flush eyes with plenty of water. Remove contact lenses, if worn. If irritation persists, get medical attention. First-aid Measures After Ingestion: If swallowed, do NOT induce vomiting. Never give anything by mouth to an unconscious person. Get immediate medical advice/attention. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: Symptoms/Injuries After Inhalation: May cause respiratory tract irritation. Vapours may cause drowsiness and dizziness. Symptoms/Injuries After Skin Contact: Causes skin irritation. Symptoms may include redness, edema, drying, defatting and cracking of the skin. Symptoms/Injuries After Eye Contact: May cause eye irritation. Symptoms may include discomfort or pain, excess blinking and tear production, with possible redness and swelling. Symptoms/Injuries After Ingestion: May be fatal if swallowed and enters airways. This product may be aspirated into the lungs and cause chemical pneumonitis. May cause stomach distress, nausea or vomiting. Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed Symptoms may not appear immediately. In case of accident or if you feel unwell, seek medical advice immediately (show the label or SDS where possible). SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: Powder, water fog, foam, carbon dioxide. Unsuitable Extinguishing Media: Do not use water jet. 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: Products of combustion may include, and are not limited to: oxides of carbon. Explosion Hazard: Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Firefighting Instructions: Protection During Firefighting: Keep upwind of fire. Wear full fire fighting turn-out gear (full Bunker gear) and respiratory protection (SCBA). Use water spray to keep fire-exposed containers cool. SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: Use personal protection recommended in Section 8. Isolate the hazard area and deny entry to unnecessary and unprotected personnel. Eliminate sources of ignition. 6.1.1. For Non-emergency Personnel Protective Equipment: Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: Emergency Procedures: 6.2. Environmental Precautions 6.3. Methods and Material for Containment and Cleaning Up For Containment: Contain and/or absorb spill with inert material (e.g. sand, vermiculite), then place in a suitable container. Do not flush to sewer or allow to enter waterways. Use appropriate Personal Protective Equipment (PPE). Methods for Cleaning Up: Scoop up material and place in a disposal container. Spilled material may present a slipping hazard. Provide ventilation. 6.4. Reference to Other Sections See section 8 for further information on protective clothing and equipment and section 13 for advice on waste disposal. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: Keep away from sources of ignition - No smoking. Avoid contact with skin and eyes. Do not breathe dust/fume/gas/mist/vapors/ spray. Do not swallow. Handle and open container with care. When using do not eat, drink or smoke. Use only outdoors or in a well-ventilated area. Hygiene Measures: 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Proper grounding procedures to avoid static electricity should be followed. Storage Conditions: Keep locked up and out of reach of children. Keep container tightly closed and in a well-ventilated place. Keep cool. 7.3. Specific End Use(s) SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters Distillates, petroleum, hydrotreated middle (64742-46-7) ACGIH Not applicable OSHA Not applicable Stoddard solvent (8052-41-3) ACGIH ACGIH TWA (ppm) 100 ppm OSHA OSHA PEL (TWA) (mg/mÂ³) 2900 mg/mÂ³ OSHA OSHA PEL (TWA) (ppm) 500 ppm Petroleum distillates, hydrotreated light (64742-47-8) ACGIH Not applicable OSHA Not applicable Solvent naphtha, petroleum, light aromatic (64742-95-6) ACGIH Not applicable OSHA Not applicable Benzene, 1,2,4-trimethyl- (95-63-6) ACGIH Not applicable OSHA Not applicable Fatty acid amine reaction product ACGIH Not applicable OSHA Not applicable Nonane (111-84-2) ACGIH ACGIH TWA (ppm) 200 ppm OSHA Not applicable Naphthalene (91-20-3) ACGIH ACGIH TWA (ppm) 10 ppm OSHA OSHA PEL (TWA) (mg/mÂ³) 50 mg/mÂ³ OSHA OSHA PEL (TWA) (ppm) 10 ppm Ethylbenzene (100-41-4) ACGIH ACGIH TWA (ppm) 20 ppm OSHA OSHA PEL (TWA) (mg/mÂ³) 435 mg/mÂ³ OSHA OSHA PEL (TWA) (ppm) 100 ppm Cumene (98-82-8) ACGIH ACGIH TWA (ppm) 50 ppm OSHA OSHA PEL (TWA) (mg/mÂ³) 245 mg/mÂ³ OSHA OSHA PEL (TWA) (ppm) 50 ppm 8.2. Exposure Controls Appropriate Engineering |Use ventilation adequate to keep exposures (airborne Controls |levels of dust, fume, vapor, etc.) below recommended |exposure limits. Personal Protective Equipment| Materials for Protective | Clothing | Hand Protection |Wear chemically resistant protective gloves. Eye Protection |Safety glasses or goggles are recommended when using |product. Skin and Body Protection |Wear suitable protective clothing. Respiratory Protection |In case of insufficient ventilation, wear suitable |respiratory equipment. Respirator selection must be |based on known or anticipated exposure levels, the |hazards of the product and the safe working limits |of the selected respirator. Thermal Hazard Protection | SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State |Liquid Appearance |No data available Odor |Distinctive Odor Threshold |No data available pH |No data available Relative Evaporation Rate (butyl |No data available acetate=1) | Melting Point |No data available Freezing Point |No data available Boiling Point |164 Â°C (327 Â°F) Flash Point |> 65.5 Â°C (> 150 Â°F) Auto-ignition Temperature |No data available Decomposition Temperature |No data available Flammability (solid, gas) |Flammable Vapor Pressure |< 0.1 mm Hg Relative Vapor Density at 20 Â°C |> 1 (air = 1) Relative Density |< 0.9 (H2O = 1) Specific Gravity | Solubility |Insoluble. Partition coefficient: |No data available n-octanol/water | Viscosity |No data available Lower Flammable Limit | Upper Flammable Limit | 9.2. Other Information VOC content : 823 g/l SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity No dangerous reaction known under conditions of normal use. 10.2 Chemical Stability Stable under normal storage conditions. 10.3 Possibility of Hazardous Reactions No dangerous reaction known under conditions of normal use. 10.4 Conditions to Avoid Heat. Incompatible materials. Sources of ignition. 10.5 Incompatible Materials Strong oxidizers. 10.6 Hazardous Decomposition Products May include, and are not limited to: oxides of carbon. SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: Not classified. Skin Corrosion/Irritation: Causes skin irritation. Serious Eye Damage/Irritation: Based on available data, the classification criteria are not met. Respiratory or Skin Sensitization: Based on available data, the classification criteria are not met. Germ Cell Mutagenicity: Based on available data, the classification criteria are not met. Carcinogenicity: Suspected of causing cancer. Reproductive Toxicity: Based on available data, the classification criteria are not met. Specific Target Organ Toxicity (Single Exposure): Based on available data, the classification criteria are not met. Specific Target Organ Toxicity (Repeated Exposure): Causes damage to organs through prolonged or repeated exposure. Aspiration Hazard: May be fatal if swallowed and enters airways. Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Chronic Symptoms: SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity May cause long-term adverse effects in the aquatic environment. 12.2. Persistence and Degradability Diesel Treat: Not established. 12.3. Bioaccumulative Potential Diesel Treat: Not established. 12.4. Mobility in Soil No additional information available. 12.5. Other Adverse Effects Effect on the global warming: No known ecological damage caused by this product. SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: This material must be disposed of in accordance with all local, state, provincial, and federal regulations. The generation of waste should be avoided or minimized wherever possible. Additional Information: Handle empty containers with care because residual vapours are flammable. SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name |Combustible liquid, n.o.s. (Petroleum distillates) Hazard Class |Combustible liquid |<PICTOGRAM PHRASE> Identification Number|NA1993 | Label Codes | | ERG Number | 14.2 In Accordance with IMDG Proper Shipping Name | Hazard Class | Identification Number| Label Codes | |<PICTOGRAM PHRASE> ntification Of The | | Substance/m | | EmS-No. (Fire) | | EmS-No. (Spillage) | | 14.3 In Accordance with IATA Proper Shipping Name | Identification Number| |<PICTOGRAM PHRASE> Hazard Class | | Label Codes | | ntification Of The | | Substance/m | | ERG Code (IATA) | SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations Benzene, 1,2,4-trimethyl- (95-63-6) Listed on United States SARA Section 313 SARA Section 313 - Emission Reporting 1.0 % Nonane (111-84-2) EPA TSCA Regulatory Flag T - T - indicates a substance that is the subject of a Section 4 test rule under TSCA. Naphthalene (91-20-3) Listed on United States SARA Section 313 EPA TSCA Regulatory Flag T - T - indicates a substance that is the subject of a Section 4 test rule under TSCA. SARA Section 313 - Emission Reporting 0.1 % Ethylbenzene (100-41-4) Listed on United States SARA Section 313 SARA Section 313 - Emission Reporting 0.1 % Cumene (98-82-8) Listed on United States SARA Section 313 EPA TSCA Regulatory Flag T - T - indicates a substance that is the subject of a Section 4 test rule under TSCA. SARA Section 313 - Emission Reporting 1.0 % SARA Section 311/312 Hazard Classes | Toxic Substances Control Act (TSCA) |All components of this product are listed, or |excluded from listing, on the United States |Environmental Protection Agency Toxic |Substances Control Act (TSCA) inventory. 15.2 US State Regulations Diesel Treat State or local regulations This product contains chemicals known to the State of California to cause cancer. SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date |06/01/2015 Other |None. Information | GHS Full Text Phrases: ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | Grainger disclaimer.
The information contained in this SDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this 'SDS' shall be created or inferred by any statement in this 'SDS'. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this 'SDS'. The user is responsible for full compliance.