Product Categories See All
Track Order Status
Sheet 0046430Printer Friendly View
Safety Data Sheet | | Date of Issue: |Revision Date: November 6, |Revision Number: |2013 | Imperial Supplies Part Number: 0046430 SECTION 1: IDENTIFICATION 1.1. Product Identifier Product Form: Product Name: LiquiFix CAS No: Synonyms: 1.2. Intended Use of the Product Use of the substance/mixture: Lubricant Protectant, Penetrant 1.3. Name, Address, and Telephone of the Responsible Party LiQuifix LLC 110 Lenox Avenue Stamford. CT 06 877-235-3772 1.4. Emergency Telephone Number Emergency | (800) 424-9300 number | SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) Not Hazardous | | | 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) |None | | | | | |Required| | | | | Signal Word (GHS-US) | Hazard Statements (GHS-US) | Precautionary Statements | (GHS-US) | 2.3. Other Hazards Other Hazards Not Contributing to the Classification: None known 2.4. Unknown Acute Toxicity (GHS-US) SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substance Name |Product identifier |% |Classification | | |(GHS-US) | | | | | | | | | | | | | | | Full text of H-phrases: See Section 16 3.2. Mixture Name |Product identifier |% |Classification | | |(GHS-US) Mineral Oil |8042-47-5 |50-90% | Petroleum Distillates |64742-52-5 |10-50% | |64742-47-8 | | | | | | | | | | | SECTION 4: FIRST AID MEASURES 4.1. Description of First Aid Measures First-aid Measures General: First-aid Measures After Inhalation: Remove victim to fresh air. If breathing has stopped give artificial respiration If breathing is difficult have qualified personnel administer oxygen. Get medical attention. First-aid Measures After Skin Contact: Wash thoroughly with soap and water Remove contaminated clothing and launder before reuse. Get medical attention if irritation develops. First-aid Measures After Eye Contact: Immediately flush eye with water while lifting the upper and lower lids. Get medical attention if irritation persists. First-aid Measures After Ingestion: Do not induce vomiting. Get immediate medical attention by calling a Poison Control Center or hospital emergency department. 4.2. Most important symptoms and effects, both acute and delayed Symptoms/Injuries: May cause mild eye and skin irritation. Accidental ingestion may cause gastrointestinal effects with nausea and diarrhea. Symptoms/Injuries After Inhalation: Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Chronic Symptoms: 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed Get immediate medical attention in cases of ingestion. SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: Use water fog, foam, carbon dioxide, dry chemical. Water or foam may cause frothing. Unsuitable Extinguishing Media: 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: Explosion Hazard: At elevated temperatures containers may rupture. Combustion products: Thermal decomposition may yield carbon monoxide, carbon dioxide and hydrocarbons. Reactivity: 5.3. Advice for Firefighters Precautionary Measures Fire: Firefighting Instructions: Protection During Firefighting: Firefighters should wear full emergency equipment and a NIOSH approved positive pressure self-contained breathing apparatus. Cool fire exposed containers and structures with water. SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: Wear appropriate protective equipment as described in Section 8. 6.1.1. For Non-emergency Personnel Protective Equipment: Emergency Procedures: 6.1.2. For Emergency Responders Protective Equipment: Emergency Procedures: 6.2. Environmental Precautions Prevent entry in storm sewers and waterways. Report spill as required by local and federal regulations. 6.3. Methods and Material for Containment and Cleaning Up For Containment: Methods for Cleaning Up: Dike spill and collect into closable containers for disposal with an inert absorbent. 6.4. Reference to Other Sections See heading 8, Exposure Controls and Personal Protection. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: Hygiene Measures: Avoid eye and prolonged/repeated skin contact. Avoid breathing vapors and mists. Wash thoroughly after handling. Remove oil-soaked clothing and launder before re-use Discard oil soaked shoes and other items than cannot be laundered. 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Storage Conditions: Protect containers from physical damage. Store in a cool area away from oxidizers. Empty containers retain product residues. Do not cut. weld, braze, etc on or near empty containers. Follow all SDS precautions in handling empty containers. 7.3. Specific End Use(s) SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters INGREDIENTS CAS#/ EINECS # EXPOSURE LIMITS Mineral Oil 8042-47-5 5 mg/ m3 TWA OSHA PEL (as Oil Mist) 5 mg/m3 TWA ACGIH TLV (inhalable fraction) (as mineral oil) Petroleum Distillates 64742-52-5 64742-47-8 5 mg/m3 TWA OSHA PEL (as Oil Mist) 5 mg/m3 TWA ACGIH TLV (inhalable fraction) (as mineral oil) 8.2. Exposure Controls Appropriate Engineering |General ventilation should be adequate for normal Controls |use. For operations where the occupational exposure |limit may be exceeded, mechanical ventilation such |as local exhaust may be needed. Personal Protective Equipment|Other Protective Equipment: For operations where |contact can occur, an eye wash facility should be |available. Materials for Protective | Clothing | Hand Protection | Eye Protection |Avoid eye contact. Safety glasses or goggles |recommended if splashing is possible. Skin and Body Protection |Skin Protection: Avoid prolonged skin contact. |Rubber or other impervious gloves are recommended |where prolonged or repeated skin contact is likely. |Other Protective Equipment: For operations where |contact can occur, an eye wash facility should be |available. Respiratory Protection |None needed for normal use with adequate ventilation |Use a NIOSH approved respirator with organic vapor |cartridges or supplied air respirator if needed. |Selection of respiratory protection depends on the |contaminant type form and concentration. Select in |accordance with OSHA 1910 134 and good industrial |Hygiene practice. Thermal Hazard Protection | SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State | Appearance |Light straw colored liquid. Odor |Mild petroleum odor. Odor Threshold |No data available. pH |Not available Relative Evaporation Rate |1.1 (butylacetate=1) | Melting Point |Not Available Freezing Point |Not Available Boiling Point |450 Deg. F (232 Deg. C) Flash Point |275 Deg. F/154 Deg C Auto-ignition Temperature |Not Determined Decomposition Temperature |Not Determined Flammability (solid, gas) |Not applicable Vapor Pressure |(@ 20C Mm Hg): 1.0 Relative Vapor Density at 20 �C |Less Than 1 Relative Density |0.86 Specific Gravity |0.86 Solubility |Negligible Partition coefficient: |Not Available n-octanol/water | Viscosity |21.5 cSt @40�C Lower Flammable Limit |0.5 (petroleum distillate) Upper Flammable Limit |4.8 (petroleum distillate) 9.2. Other Information Voc: 77 G/L SECTION 10: STABILITY AND REACTIVITY 10.1 Reactivity Not reactive. 10.2 Chemical Stability This material is stable. 10.3 Possibility of Hazardous Reactions Will not occur. 10.4 Conditions to Avoid Avoid excessive heat. 10.5 Incompatible Materials Avoid strong oxidizers and strong acids. 10.6 Hazardous Decomposition Products Thermal decomposition may yield carbon monoxide carbon dioxide and hydrocarbons. SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects Acute Toxicity: Product: Oral rat LD50 > 5 g/kg: Dermal rabbit LD50 2 g/kg. Skin Corrosion/Irritation: Prolonged contact may cause drying and cracking of skin. Serious Eye Damage/Irritation: May cause mild irritation with redness and tearing. Respiratory or Skin Sensitization: Germ Cell Mutagenicity: Carcinogenicity: None of the components is listed as a carcinogen or suspect carcinogen by NTP, IARC, ACGIH or OSHA. Reproductive Toxicity: Specific Target Organ Toxicity (Single Exposure): Specific Target Organ Toxicity (Repeated Exposure): Aspiration Hazard: Symptoms/Injuries After Inhalation: Vapors or mists may cause upper respiratory tract irritation, headache, dizziness, drowsiness, anesthesia and unconsciousness. Symptoms/Injuries After Skin Contact: Symptoms/Injuries After Eye Contact: Symptoms/Injuries After Ingestion: Swallowing may cause gastrointestinal irritation, nausea, vomiting, and diarrhea. Chronic Symptoms: Prolonged or repeated exposure may cause dermatitis. SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity No data available. 12.2. Persistence and Degradability No data available 12.3. Bioaccumulative Potential No data available 12.4. Mobility in Soil No data available 12.5. Other Adverse Effects No data available SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Waste Disposal Recommendations: This product as sold does not meet the definition of a US EPA hazardous waste. Dispose in accordance with all local, state and federal regulations. Additional Information: SECTION 14: TRANSPORT INFORMATION 14.1 In Accordance with DOT Proper Shipping Name |Not Regulated Hazard Class |None |<PICTOGRAM PHRASE> Identification Number|None | Label Codes | | ERG Number | 14.2 In Accordance with IMDG Proper Shipping Name |Not Regulated Hazard Class |None Identification Number|None Label Codes | |<PICTOGRAM PHRASE> ntification Of The | | Substance/m | | EmS-No. (Fire) | | EmS-No. (Spillage) | | 14.3 In Accordance with IATA Proper Shipping Name |Not Regulated Identification Number|None |<PICTOGRAM PHRASE> Hazard Class |None | Label Codes | | ntification Of The | | Substance/m | | ERG Code (IATA) | SECTION 15: REGULATORY INFORMATION 15.1 US Federal Regulations <COMPONENT>This product does not contain chemicals regulated under SARA Section 302. EPA SARA 311 Hazard Classification; Not Hazardous. EPA SARA 313: This product contains the following chemicals that are regulated under SARA Title III. section 313 None. SARA Section 311/312 Hazard Classes |Not Hazardous Toxic Substances Control Act (TSCA) |Alt of the components of this product are |listed on the TSCA inventory. 15.2 US State Regulations <COMPONENT>California Proposition 65: This product is not known to contain any chemicals which are known to the State of California to cause cancer or reproductive harm. SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision date |11/06/2013 Other |This document has been prepared in accordance with the SDS Information |requirements of the OSHA Hazard Communication Standard 29 CFR |1910.1200. GHS Full Text Phrases: ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | ----| | -- | | Grainger disclaimer.
The information contained in this was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this '' shall be created or inferred by any statement in this ''. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this ''. The user is responsible for full compliance.