Start an Order |
|
|
|
| Start an Order |
|||
| Home > Products > Chemicals & Paint > MSDS Sheets > MSDS 9160 -- [Back] | |||
|
MSDS 9160 9160: Form Gasket #1 [6]MSDS Last updated: 01/14/2008
Permatex, Inc.
10 Columbus Blvd.
Hartford, CT 06106 USA
Telephone: 1-87-Permatex
(877) 376-2839
Emergency: 800-255-3924
International Emergency: 813-248-0585
Material Safety Data Sheet
1. PRODUCT IDENTIFICATION
Product Name: 1BR 3 OZ FORM A GASKET #1 SEALANT
Item No: 80008
Product Type: Sealant
2. COMPOSITION/INFORMATION ON INGREDIENTS
Component Weight% ACGIH TLV: TWA OSHA PEL:
KAOLIN 40-60 2 mg/m3 dust TWA 15 mg/m3 dust:
1332-58-7 5 mg/m3 respir
TWA
ROSIN 20-30 sensitizer; reduce
8050-09-7 exposure to as 15 mg/m3 total
low as possible dust: 5 mg/m3
respir.
ETHANOL 10-30 1000 ppm: STEL 1000 ppm TWA:
64-17-5 1000 ppm 1900 mg/m3 TWA
VEGETABLE OIL 1-10 Not Listed Not Listed
68187-84-8
2-PROPANOL <5 200 ppm TWA 400 ppm TWA:
67-63-0 980 mg/m3 TWA
TITANIUM DIOXIDE 0.1-1.0 10 mg/m3 TWA 15 mg/m3 TWA
13463-67-7 ACGIH (total dust)
METHANOL 0.1-1.0 200 ppm TWA: 200 ppm TWA:
67-56-1 262 mg/m3 TWA 260 mg/m3 TWA
3. HAZARDS IDENTIFICATION
Toxicity: May cause eye, skin and respiratory irritation. This product contains
encapsulated silicon dioxide (quartz silica). No exposure to free
respirable silica is anticipated during normal use of this product.
Silica may be released by grinding or machining of coated material.
Use NIOSH-approved dust/mist respirator when grinding or machining.
Primary Routes of Entry: Eye and skin contact, ingestion, inhalation
Signs and Symptoms of Exposure: Excessive accidental exposure may cause
headache, dizziness, nausea and mild respiratory irritation.
Overexposure may cause eye and skin redness.
Component Weight% NTP ACGIH IARC
Carcinogens
KAOLIN 40-60 A4-Not classifiable
1332-58-7 as a human carcinogen
ETHANOL 10-30 A4 - Not Classifiable Group 1
64-17-5 as a Human (drinking
carcinogen alcohol):
Vol. 44,
pg 35, 1988
2-PROPANOL <5 A4 - Not classifiable Group 3
67-63-0 as a human Monograph 71,
carcinogen 1999;
Supp.7, 1987;
Monograph 15,
1977
TITANIUM DIOXIDE 0.1-1.0 male rat- A4 Group 2B: Vol
13463-67-7 negative, 93: 2006: Vol
female rat- 47, 1989
negative,
male mice-
negative,
female mice-
negative.
Medical Conditions Recognized as Preexisting eye, skin and respiratory
Being Aggravated by Exposure: disorders may be aggravated by
overexposure to this product.
4. FIRST AID MEASURES
Ingestion: Do not induce vomiting. Slowly dilute with 1-2 glasses of
water or milk and seek medical attention. Never
give anything by mouth to an unconscious person.
Inhalation: Move to fresh air in case of accidental inhalation of
vapors. Oxygen or artificial respiration if needed.
Obtain medical attention.
Skin Contact: Wash off immediately with soap and plenty of water removing
all contaminated clothes and shoes. If skin
irritation persists, call a physician.
Eye Contact: In case of contact, immediately flush eyes with plenty of
water for at least 15 minutes and get medical
attention if irritation persists.
5. FIRE FIGHTING MEASURES
Flash Point (°F/C): Does not apply. Per ASTM D4359 this product
is a solid.
Recommended Extinguishing Media: Carbon Dioxide, Dry Chemicals, Foam
Special Fire-Fighting Procedures: Firefighters should wear self contained
breathing apparatus. Water spray may be ineffective
on flmaes but should be used to keep fire-exposed
containers cool.
Hazardous Products of Combustion: Aldehydes, Oxides of carbon, Carboxylic
acids.
Unusual Fire/Explosion Hazards: Closed containers may rupture or explode
when exposed to extreme heat.
Lower Explosive Limit: Not determined.
Upper Explosive Limit: Not determined.
6. ACCIDENTAL RELEASE MEASURES
Spill Procedures: Eliminate all sources of ignition. Maintain good
ventilation. Take up with an inert absorbent. Store in a
closed waste container until disposal. Residues may be
cleaned up with isopropyl alcohol.
7. HANDLING AND STORAGE
Storage: Store away from heat, sparks or open flame. Do not store at
temperatures above 120 degrees F.
Handling: Avoid contact with skin and eyes. Do not inhale vapors. Keep
container closed when not in use.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Eyes: Safety glasses
Skin: Rubber or plastic gloves.
Ventilation: General; local exhaust ventilation as necessary to control
any air contaminants to within their exposure
limits (or to the lowest feasible levels when limits have
not been established) during the use of this product.
Respiratory Protection: An approved respirator (i.e. NIOSH, etc.) should be worn
when exposures are expected to exceed the
applicable limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance: Reddish brown paste
Odor: Alcoholic
Boiling Point: >180°F
pH: Does not apply
Solubility in Water: Partial
Specific Gravity: 1.4-1.5
VOC Content (Wt.%): 13.5%
Vapor Pressure: 33 mm Hg @ 68 degrees F.
Vapor Density (Air=1): 2.07
Evaporation Rate: 7.7 (ether = 1)
10. STABILITY AND REACTIVITY
Chemical Stability: Stable at normal conditions
Hazardous Polymerization: WILL NOT OCCUR.
Incompatibilities: Strong oxidizers
Conditions to Avoid: Keep away from heat, sparks and open flame.
Hazardous Products of Combustion: Aldehydes, Oxides of carbon.
Carboxylic acids.
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Recommended Method of Disposal: Disposal should be made in accordance with
federal, state and local regulations.
US EPA Waste Number: NH - Not a RCRA Hazardous Waste Material
14. TRANSPORTATION INFORMATION
DOT (49CFR 172)
Domestic Ground Transport
DOT Shipping Name: Unrestricted
Hazard Class: None
UN/ID Number: None
Marine Pollutant: None
IATA
Proper Shipping Name: Not regulated
Class or Division: None
UN/NA Number: None
IMDG
Proper Shipping: Unrestricted
Hazard Class: None
UN Number: None
15. REGULATORY INFORMATION
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313
Toxic Chemical.
NONE
CALIFORNIA PROP 65:
No California Prop 65 chemicals are known to be present.
TSCA Inventory Status:
Listed on Inventory: YES All components of this product are listed (or exempt)
on the EPA TSCA inventory.
16. OTHER INFORMATION
Estimated NFPA Rating: HEALTH 2, FLAMMABILITY 1, REACTIVITY O.
Estimated HMIS Classification: HEALTH 2, FLAMMABILITY 1, PHYSICAL HAZARD 0
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Prepared By: Denise Boyd, Health and Safety Manager
Revision Date: December/03/2007
Company: Permatex. Inc. 10 Columbus Blvd. Hartford, CT USA 06106
Revision 1
Number:
The information contained in this MSDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this MSDS shall be created or inferred by any statement in this MSDS. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this MSDS. The user is responsible for full compliance. For more product information by email, click here Imperial Supplies LLC does not provide services and products outside the United States |
Printer-Friendly View
