MSDS 9129
All MSDS Go Back
Permatex, Inc.
10 Columbus Blvd.
Hartford, CT 06106 USA
Telephone: 1-87-PERMATEX
(877) 376-2839
Emergency: 800-255-3924 (ChemTel)
International Emergency: +01-813-248-0585
MATERIAL SAFETY DATA SHEET
1. Product Identification
Product Name: 14H THREAD SEALANT W/PTFE 4 FL.OZ.
Item No: 80632
Product Type: Sealant
2. Composition/Information on Ingredients
Component Weight% ACGIH; OSHA PEL
TLV-TWA
ETHANOL 20-40 1000 ppm 1000 ppm; 1900
64-17-5 mg/m³
TALC 20-40 2 mg/m³ 20 mppcf
14807-96-6
CASTOR OIL 20-40 Not listed Not listed
8001-79-4
POLYVINYL RESIN <10 Not listed Not listed
63148-65-2
2-PROPANOL <5 200 ppm 400 ppm; 980 mg/m³
67-63-0
TITANIUM DIOXIDE <3 10 mg/m³ 15 mg/m³
13463-67-7
METHANOL <2 200 ppm 200 ppm; 260 mg/m³
67-56-1
POLYTETRAFLUOROETHYLENE <2 Not listed Not listed
9002-84-0
3. Hazards Identification
Toxicity: May cause eye, skin and respiratory irritation. Methanol
may cause blindness or death if swallowed.
Primary Routes of Eye and skin contact, ingestion, inhalation
Entry:
Signs and Symptoms Excessive accidental exposure may cause headache,
of Exposure: dizziness, nausea and mild respiratory irritation.
Overexposure may cause eye and skin redness.
Component Weight% NTP ACGIH IARC
Carcinogens
ETHANOL 20-40 A4-Not
64-17-5 Classifiable as
a human
carcinogen
TALC 20-40 Male A4-Not Group 3
14807-96-6 rat-some classifiable as Supplement 7,
evidence, a human 1987
female carcinogen Monograph 42,
rat-clear 1987
evidence,
male mice-no
evidence,
female
mice-no
evidence
2-PROPANOL <5 A4-Not Group 3
67-63-0 Classifiable as Monograph 71,
a human 1999; Supp.7,
carcinogen 1987;
Monograph 15,
1977
TITANIUM DIOXIDE <3 male A4 Group 2B; Vol
13463-67-7 rat-negative 93, 2006; Vol
, female 47, 1989
rat-negative
, male
mice-negativ
e, female
mile-negativ
e
POLYTETRAFLUOROETHYLENE <2 Group 3
9002-84-0 Supplement 7,
1987;
Monograph 19,
1979
Medical Conditions Preexisting eye, skin and respiratory disorders may be
Recognized as Being aggravated by overexposure to this product.
Aggravated by
Exposure:
4. First Aid Measures
Ingestion: Do not induce vomiting. Slowly dilute with 1-2 glasses of
water or milk and seek medical attention. Never give
anything by mouth to an unconscious person.
Inhalation: Move to fresh air in case of accidental inhalation of
vapours. Obtain medical attention.
Skin contact: Wash off with soap and water. If skin irritation
persists, call a physician.
Eye Contact: In case of contact, immediately flush eyes with plenty of
water for at least 15 minutes and get medical attention
if irritation persists.
5. Fire Fighting Measures
Flash Point °F(C°): 74°F TTC
Recommended Carbon Dioxide, Dry Chemicals, Foam.
Extinguishing Media:
Special Firefighters should wear self-containing breathing
Fire-Fighting apparatus. Water spray may be ineffective on flames but
Procedures: should be used to keep fire-exposed containers cool.
Hazardous Products Oxides of carbon, Fluoride compounds
of Combustion:
Unusual Closed containers may rupture or explode when exposed to
Fire/Explosion extreme heat.
Hazards:
Lower Explosive 2.3
Limit:
Upper Explosive 12.7
Limit:
6. Accidental Release Measures
Spill Procedures: Eliminate all sources of ignition. Maintain good
ventilation. Take up with an inert absorbent. Store in a
closed waste container until disposal. Residues may be
cleaned up with isopropyl alcohol.
7. Handling and Storage
Storage: Store away from heat, sparks or open flame. Do not store
at temperatures above 100°F (38°C).
Handling: Avoid contact with skin and eyes. Do not inhale vapors.
Keep container closed when not in use.
8. Exposure Controls/Personal Protection
Eyes: Safety glasses.
Skin: Neoprene or nitrile gloves recommended.
Ventilation: General; local exhaust ventilation as necessary to
control any air contaminants to within their exposure
limits (or to the lowest feasible levels when limits have
not been established) during the use of this product.
Respiratory An approved organic vapor respirator should be worn when
Protection: exposures are expected to exceed the applicable limits.
9. Physical and Chemical Properties
Appearance: White paste
Odor: Alcohol
Boiling Point: 180°F
pH: Does not apply
Solubility in Water: Partial
Specific Gravity: 1.06-1.10
VOC(Wt.%): 36.5%; 395 g/L
Vapor Pressure: 33 mm Hg @ 68°F
Vapor Density 2.07
(Air=1):
Evaporation Rate: 7.7 (ether = 1)
10. Stability and Reactivity
Chemical Stability: Stable in normal conditions
Hazardous Will not occur
Polymerization:
Incompatibilities: Strong oxidizers
Conditions to Avoid: Keep away from heat, sparks and open flame. -No smoking.
Hazardous Products Oxides of carbon, Fluoride compounds
of Combustion:
11.Toxicological Information
See Section 3
12. Ecological Information
No data available
13.Disposal Considerations
Recommended Method Disposal should be made in accordance with federal, state
of Disposal: and local regulations.
US EPA Waste Number: D001 as per 40CFR 261.21
14. Transportation Information
DOT (49CFR 172)
Ground Transport
(DOT)
DOT Shipping Name: Consumer Commodity (not more than one liter)
Hazard Class: ORM-D
UN/ID Number: None
IATA
Proper Shipping Consumer Commodity (Not more than 1 liter)
Name:
Class or Division: Class 9
UN/ID Number ID8000
IMDG
Proper Shipping: Adhesives containing flammable liquid, Limited Quantity
Hazard Class: Class 3 PGIII
UN Number: UN 1133
Marine Pollutant: None
15. Regulatory Information
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313
Toxic Chemical.
Methanol
California No California Prop 65 chemicals are known to be present.
Proposition 65:
TSCA Inventory All components of this product are listed (or exempt) on
Status: the EPA TSCA inventory.
16. Other Information
Estimated NFPA HEALTH 2, FLAMMABILITY 3, REACTIVITY 0.
Rating:
Estimated HMIS HEALTH 2, FLAMMABILITY 3, PHYSICAL HAZARD 0
Classification:
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Prepared By: Denise Boyd, Revision August 11, 2010
Manager-Environmental, Health & Date:
Safety
Company: Permatex. Inc. 10 Columbus Blvd. Revision 7
Hartford, CT USA 06106 Number:
Telephone No.: 1-87-Permatex (877) 376-2839
The information contained in this MSDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this MSDS shall be created or inferred by any statement in this MSDS. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this MSDS. The user is responsible for full compliance.