MSDS Sheet 6568

• All Products
• Fasteners
   » Grade 8
   » Grade 5
   » Threaded Fasteners
• Hardware
• Rivet & Rivet Guns
• Vehicle Lighting
• Electrical Products
• Tubing & Tube Fittings
• Air Brake Products
• Hose & Hose Ends
• Cutting Tools
• Abrasives
• Safety Products &
  Welding Supplies
• Chemicals & Paint
   » MSDS Information
   » CA/OTC Information
• Shop Supplies
• Vehicle Parts &
  Accessories
• Assortments &
  Steel Equipment
   » Assortment Listing

• Online Catalog Index
• Discontinued &
Overstock Specials

Printer-Friendly View

MATERIAL SAFETY DATA SHEET Section 1 -- PRODUCT AND COMPANY IDENTIFICATION PART NUMBER 6568 & 6568-1 PRODUCT NAME PENTRATING OIL HMIS CODES Health 2 Flammability 4 Reactivity 0 MANUFACTURER'S NAME IMPERIAL SUPPLIES LLC 789 PACKER DR GREEN BAY, WI 54307 800-558-2808 - INFORMATION NUMBER 800-255-3924 - EMERGENCY NUMBER (CHEM-TEL) DATE OF PREPARATION 17-JUN-03 Section 2 -- COMPOSITION / INFORMATION ON INGREDIENTS % by WT CAS No. INGREDIENT UNITS VAPOR PRESSURE -------------------------------------------------------------------------------- 10 74-98-6 Propane ACGIH TLV 2500 ppm 760 mm OSHA PEL 1000 ppm 10 106-97-8 Butane ACGIH TLV 800 ppm 760 mm OSHA PEL 800 ppm 20 64742-88-7 Mineral Spirits ACGIH TLV 100 ppm 2 mm OSHA PEL 100 ppm 10 8008-20-6 Kerosine, petroleum ACGIH TLV Not Available 0.7 mm OSHA PEL Not Available 50 64742-52-5 Heavy Naphthenic Petroleum Oil ACGIH TLV Not Available OSHA PEL Not Available Section 3 -- HAZARDS IDENTIFICATION ROUTES OF EXPOSURE INHALATION of vapor or spray mist. EYE or SKIN contact with the product, vapor or spray mist. EFFECTS OF OVEREXPOSURE Irritation of eyes, skin and upper respiratory system. May cause nervous system depression. Extreme overexposure may result in unconsciousness and possibly death. SIGNS AND SYMPTOMS OF OVEREXPOSURE Headache, dizziness, nausea, and loss of coordination are indications of excessive exposure to vapors or spray mists. Redness and itching or burning sensation may indicate eye or excessive skin exposure. MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE None generally recognized. CANCER INFORMATION For complete discussion of toxicology data refer to Section 11. Section 4 -- FIRST AID MEASURES If INHALED: If affected, remove from exposure. Restore breathing. Keep warm and quiet. If on SKIN: Wash affected area thoroughly with soap and water. Remove contaminated clothing and launder before re-use. If in EYES: Flush eyes with large amounts of water for 15 minutes. Get medical attention. If SWALLOWED: Do not induce vomiting. Get medical attention immediately. Section 5 -- FIRE FIGHTING MEASURES FLASH POINT LEL UEL Propellant < 0 F 0.7 9.5 EXTINGUISHING MEDIA Carbon Dioxide, Dry Chemical, Foam UNUSUAL FIRE AND EXPLOSION HAZARDS Containers may explode when exposed to extreme heat. Application to hot surfaces requires special precautions. During emergency conditions overexposure to decomposition products may cause a health hazard. Symptoms may not be immediately apparent. Obtain medical attention. SPECIAL FIRE FIGHTING PROCEDURES Full protective equipment including self-contained breathing apparatus should be used. Water spray may be ineffective. If water is used, fog nozzles are preferable. Water may be used to cool closed containers to prevent pressure build-up and possible autoignition or explosion when exposed to extreme heat. Section 6 -- ACCIDENTAL RELEASE MEASURES STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED Remove all sources of ignition. Ventilate the area. Remove with inert absorbent. Section 7 -- HANDLING AND STORAGE STORAGE CATEGORY Not Available PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE Keep away from heat, sparks, and open flame. Vapors will accumulate readily and may ignite explosively. During use and until all vapors are gone: Keep area ventilated - Do not smoke - Extinguish all flames, pilot lights, and heater - Turn off stoves, electric tools and appliances, and any other sources of ignition. Consult NFPA Code. Use approved Bonding and Grounding procedures. Contents under pressure. Do not puncture, incinerate, or expose to temperature above 120F. Heat from sunlight, radiators, stoves, hot water, and other heat sources could cause container to burst. Do not take internally. Keep out of the reach of children. Section 8 -- EXPOSURE CONTROLS / PERSONAL PROTECTION PRECAUTIONS TO BE TAKEN IN USE Use only with adequate ventilation. Avoid contact with skin and eyes. Avoid breathing vapor and spray mist. Wash hands after using. VENTILATION Local exhaust preferable. General exhaust acceptable if the exposure to materials in Section 2 is maintained below applicable exposure limits. Refer to OSHA Standards 1910.94, 1910.107, 1910.108. RESPIRATORY PROTECTION If personal exposure cannot be controlled below applicable limits by ventilation, wear a properly fitted organic vapor / particulate respirator approved by NIOSH / MSHA for protection against materials in Section 2. PROTECTIVE GLOVES None required for normal application of aerosol products where minimal skin contact is expected. For long or repeated contact, wear chemical resistant gloves. EYE PROTECTION Wear safety spectacles with unperforated sideshields. OTHER PRECAUTIONS Intentional misuse by deliberately concentrating and inhaling the contents can be harmful or fatal. Section 9 -- PHYSICAL AND CHEMICAL PROPERTIES PRODUCT WEIGHT 6.34 lb/gal 759 g/l SPECIFIC GRAVITY 0.76 BOILING POINT <0 - 572 F <-18 - 300 C MELTING POINT Not Available VOLATILE VOLUME 58 % EVAPORATION RATE Faster than ether VAPOR DENSITY Heavier than air SOLUBILITY IN WATER N.A. VOLATILE ORGANIC COMPOUNDS (VOC Theoretical) Volatile Weight 50.00 % Less Water and Federally Exempt Solvents Section 10 -- STABILITY AND REACTIVITY STABILITY -- Stable CONDITIONS TO AVOID None known. INCOMPATIBILITY None known. HAZARDOUS DECOMPOSITION PRODUCTS By fire: Carbon Dioxide, Carbon Monoxide HAZARDOUS POLYMERIZATION Will not occur Section 11 -- TOXICOLOGICAL INFORMATION CHRONIC HEALTH HAZARDS No ingredient in this product is an IARC, NTP, or OSHA listed carcinogen. Prolonged overexposure to solvent ingredients in Section 2 may cause adverse effects to the liver and urinary systems. Reports have associated repeated and prolonged overexposure to solvents with permanent brain and nervous system damage. TOXICOLOGY DATA CAS No. Ingredient Name -------------------------------------------------------------------------------- 74-98-6 Propane LC 50 RAT 4HR Not Available LD 50 RAT Not Available 106-97-8 Butane LC 50 RAT 4HR Not Available LD 50 RAT Not Available 64742-88-7 Mineral Spirits LC 50 RAT 4HR Not Available LD 50 RAT Not Available 8008-20-6 Kerosene, petroleum LC 50 RAT 4HR Not Available LD 50 RAT Not Available 64742-52-5 Heavy Naphthenic Petroleum Oil LC 50 RAT 4HR Not Available LD 50 RAT Not Available Section 12 -- ECOLOGICAL INFORMATION ECOTOXICOLOGICAL INFORMATION No data available. Section 13 -- DISPOSAL CONSIDERATIONS WASTE DISPOSAL METHOD Waste from this product may be hazardous as defined under the Resource Conversation and Recovery Act (RCRA) 40 CFR 261. Waste must be tested for ignitability to determine the applicable EPA hazardous waste numbers. Do not incinerate. Depressurize container. Dispose of in accordance with Federal, State / Provincial, and Local regulations regarding pollution. Section 14 -- TRANSPORT INFORMATION No data available. Section 15 -- REGULATORY INFORMATION SARA 313 (40 CFR 372.65C) SUPPLIER NOTIFICATION CAS No. CHEMICAL / COMPOUND % by WT % Element No ingredients in this product are subject to SARA 313 (40 CFR 372.65C) Supplier Notification. CALIFORNIA PROPOSITION 65 WARNING; This product contains chemicals known to the State of California to cause cancer and birth defects or other reproductive harm. TSCA CERTIFICATION All chemicals in this product are listed, or are exempt from listing, on the TSCA Inventory. Section 16 -- OTHER INFORMATION This product has been classified in accordance with the hazard criteria of the CPR and the MSDS contains all of the information required by the CPR. The above information pertains to this product as currently formulated, and is based on the information available at this time. Addition of reducers or other additives to this product may substantially alter the composition and hazards of the product. Since conditions of use are outside our control, we make no warranties, express or implied, and assume no liability in connection with any use of this information.